鸡西730煤机电器图册

1、MG300（200、250）/730（530、630）-WD采煤机出厂图册鄂尔多斯恒邦 专用鸡西煤矿机械有限公司产品编号： 201A24MJ007 发放时间： 年 月 日 第1.1页 前 言整机主要参数表项 目内 容采高范围 m2.34.2装机功率 kW730截割功率 kW2300牵引功率 kW250过煤高度mm600滚筒直径m2.0滚筒截深mm 630摇臂型式整体弯摇臂牵引力 kN687调速方式交流变频工作面倾角15泵站功率 kW30机面高度 mm1.489m 下切深度 mm465滚筒转速 r/min35摇臂摆动中心距mm7575摇臂长度 mm2160牵引速度 m/min7.1牵引型式齿轮

2、销排供电电压 V1140配套输送机SGZ764/630整机布置式积木式组合整机重量 t 55MG300/730-WD型交流电牵引采煤机是采用多电机驱动、横向布置，装机功率大，采煤机截割部设计强度为300kW，电机容量调整范围为200300kW，通过调整截割电机容量，可实现一机多型。即MG200/530-WD、MG250/630-WD、MG300/730-WD三种采煤机型，是中厚煤层综采工作面的理想首选机型之一。本机可通过更换行走部和支承组件分别适应764与800运输机，以适应不同的煤层地质条件而其它部件通用。主要适用于2.33.7m，煤质硬度f 4，煤层倾角15（或40）的综采工作面（或高档普

3、采）。可在周围空气中的甲烷、煤尘、硫化氢、二氧化碳等不超过煤矿安全规程中所规定的安全含量的矿井中使用。产品型号及含义：M G 300 / 730 - W D 电牵引 无链牵引 总装机功率（kW） 单侧截割功率（kW） 滚筒式 采煤机 总装机功率730kW，截割功率为2300kW，牵引功率为250kW，调高泵站功率为30kW。牵引型式为齿轮-齿轨式。操作控制点位置设置在机身中间，可直接操作按钮或手把，也可以采用两端操作站或遥控器离机遥控。随机所带图册为受控文件，具有唯一的分发号（即合同号）、更改标识（是否含变更图册）及受控文件专用图章。图册详细描述了MG300/730-WD型交流电牵引采煤机的构

4、成。随机所带图册可作为采煤机使用单位定购配件使用。因局部改进及配套变化，与本图册不同之处，附带产品变更图册。如封面说明含变更图册，订购配件则依据变更图册为准！封面无受控文件专用图章，仅做为学习文件及订购配件参考。目 录24MJD总图0.124MJ01B电控部1.124MJ0102操作盖1.924MJ0103A显示盖板1.1024MJ0104开关腔前盖1.1124MJ-FT5A电气原理图1.1224MJ-FT6A电气接线图1.1624MJ02B左牵引部2.114MJ0201行星减速器2.514MJ0202惰轮轴组件2.710MJ0101一轴2.810MJ0102二轴2.9MDP0216液压制动器

5、2.1024MJ03B右牵引部2.1124MJ0601过滤器2.1615MJ0201控制阀组2.1724MJ0304压力表组2.1824MJ21B行走部3.1MHJ0301行走轮组件3.324MJ34A左截割部4.114MJ0402一轴4.514MJ0403二轴4.614MJ0404A三轴4.714MJ0405四轴4.814MJ0407A行星减速器4.1014MJ0408A内喷雾供水装置（左）4.1214MJ0411C润滑管路4.1424MJ35A右截割部4.1514MJ0505A内喷雾供水装置（右）4.1924MJ06B液压系统5.110MJ0504液压锁5.524MJ07冷却喷雾系统6.1

6、24MJ0701外喷雾分水阀6.324MJ0703水阀6.410MJ0602 分水阀6.514MJ15托缆装置7.110MJ0502B调高油缸8.114MJ17T支承组件（滑靴式）9.124MJD总图24MJD（730）整机明细表序号图号图名数量单重总重序号图号图名数量单重总重124MJ34A左截割部174397439302020504001GB/T 6171-2000 螺母 M42330.5981.794224MJ-8左操作站护罩159.8459.843124MJ-13油缸铰轴压盖25.9811.96324MJ08-1压板40.2921.1683210MJ-3A铰轴231.162.24207

7、1503004GB/T 70.1-2000 螺钉 M616120.0050.063314MJ17T支承组件（滑靴式）2154.795309.59524MJ21B行走部21469.262938.52342040503011GB/T 93-1987 垫圈 20100.0150.15610MJ-2定位销412.349.2352011109008GB/T 5783-2000 螺栓 M207020.2120.424714MJ15拖缆装置11021023610MJ0502B调高油缸2466.107932.214824MJ02B左牵引部16710.646710.643715T4-2000660采煤机螺旋滚筒

8、222954590924MJ02-2前盖板151.351.33824MJ-5C弯丝杠169.569.51024MJ07冷却喷雾系统172.882872.88283914MJ-6皮带盖板28.5171124MJ-3铰轴231.863.64010MJ-13压板22.635.261210MJ-7压板22.154.3412011109004GB/T 5783-2000 螺栓 M205060.1520.912132011107003GB/T 5783-2000 螺栓 M1225590.0251.4754220MJ-53垫圈80.342.72142040502007GB/T 93-1987 垫圈 1259

9、0.0040.2364324MJ-2C丝杠166.166.11514MJ06-10螺栓 M363150121.75214420MJ-54压板60.10.61624MJ03-3前盖板192.892.8452011106002GB/T 5783-2000 螺栓 M1016120.0130.1561724MJ03B右牵引部19205.069205.06462040502006GB/T 93-1987 垫圈 10120.0030.0361824MJ-12摇臂铰轴盖板45.4821.92472011110001GB/T 5783-2000 螺栓 M245090.2292.0611924MJ-9右操作站护

10、罩191.2291.22482040503013GB/T 93-1987 垫圈 2490.0210.1892024MJ35A右截割部1743974394924MJ06B机外油管组152.252.22124MJ-3C轴275.5151502011109002GB/T 5783-2000 螺栓 M204080.1210.9682224MJ-4C轴254.37108.74512071508002GB/T 70.1-2000 螺钉 M163040.0770.30823GY42液压螺母M42352.211522040502009GB/T 93-1987 垫圈 1640.0070.028242040504

11、015GB/T 93-1987 垫圈 36340.0521.7682524MJ-7C螺栓M363205222.3451.482614MJ-2方螺母220.6614.522724MJ01B电控部1855085502824MJ-15B整机铭牌11.61.62924MJ-1C丝杠23570 24MJ01B电控部24MJ01B电控部明细表序号图号图名数量单重总重序号图号图名数量单重总重124MJ0101B电控箱壳体15884.465884.46302071506003GB/T 70.1-2000 螺钉 M123050.0390.195224MJ0105牵引变压器腔前盖165.8865.88312040

12、902008GB/T 97.2-2002 垫圈 12120.0050.0634MJA19-2护板20.170.343224MJ0116隔离开关支架119.4119.4144MJA19-3护板10.150.153326MJ08-22A瓦斯传感器压板20.1850.375104030700003变频器键盘 TX312R100342071503002GB/T 70.1-2000 螺钉 M61240.0050.026104020600001GJC4 甲烷传感器(配接甲烷传感器电源模块)1113524MJ01-11压条20.0180.036724MJ0104开关腔前盖181.6681.663620707

13、04002GB/T 67-2000 螺钉 M3540082071503011GB/T 70.1-2000 螺钉 M65040.0130.052372040501001GB/T 93-1987 垫圈 3300092040501004GB/T 93-1987 垫圈 66200382040901002GB/T 97.2-2002 垫圈 330001014MJ30-8垫板10.4350.435392071502003GB/T 70.1-2000 螺钉 M51260.0030.018112071505005GB/T 70.1-2000 螺钉 M1030520.0271.404402040501003GB

14、/T 93-1987 垫圈 51800122040502006GB/T 93-1987 垫圈 10960.0020.19241104020201022变压器 ZQSG-160/1.14/0.38-7301580580132040902007GB/T 97.2-2002 垫圈 10320.0040.128422011108003GB/T 5783-2000 螺栓 M163530.0640.192142071504010GB/T 70.1-2000 螺钉 M85040.0240.096432100500011GB/T 1972-2005 碟形弹簧 A31.560.010.0615204050100

15、5GB/T 93-1987 垫圈 81040.0020.2084424MJ0110B左上盖板165.98865.9881624MJ0103A显示盖板161.20961.2094524MJ0109B右上盖板154.38854.388172011107021GB/T 5783-2000 螺栓 M12302900.038.74624MJ01-7支板40.291.16182040502007GB/T 93-1987 垫圈 123040.0041.216472071505004GB/T 70.1-2000 螺钉 M102540.0250.11924MJ0114支架组件19.759.754812MJ012

16、9-11尼龙套管240.24.820104030200002变送器 TXBS-730166492070704009GB/T 67-2000 螺钉 M325300.0010.032124MJ0102操作盖181.281.250104020801001插接件 CA-20JW/KA20022104030100013主控器 TXZK-730113.513.551104020801002插接件 CA-14JW/KA1232071505003GB/T 70.1-2000 螺钉 M1020200.0220.4452104020600025甲烷传感器电源模块DXJ-24/1210.60.62410601032

17、01GB 1235-1976 O形密封绳 5.72100000532071502006GB/T 70.1-2000 螺钉 M52040.0040.0162524MJ0115主控器支架17.197.1954104020304007空气开关 DZ47-60/C10 230/400V426104030300044变频器 TXBP-S4-04-7302326455104020304005空气开关 DZ47-60/C5 230/400V1272071505007GB/T 70.1-2000 螺钉 M104080.0320.25656104040400002整流桥 20A/600V22824MJ01-4压

18、块120.232.7657104030100029主控继电器板 ZKJDB129104020101004接触器 CKJ5-400/1.14 AC36V311.534.55824MJ0106主控腔上盖263.82127.6424MJ01B电控部总明细表序号图号图名数量单重总重 序号图号图名数量单重总重592071504004GB/T 70.1-2000 螺钉 M82080.0130.104892070904003GB/T 65-2000 螺钉 M816360.0090.324602040901006GB/T 97.2-2002 垫圈 8160.0020.032904MJ08-35接地标志70.0

19、160.1126110MJ68-44绝缘管200.00190.038914MJ0815B主接线柱313622070705008GB/T 67-2000 螺钉 M425200.0020.04924MJ0816七芯接线柱140.431146.03596632040501002GB/T 93-1987 垫圈 420009324MJ0111接线腔右盖板170.5570.55642040901003GB/T 97.2-2002 垫圈 420009410MJ68-24胶垫30.0160.0486524MJ01-6底板14.254.259514MJ30-17接线弯头34.36313.089661040205

20、00020互感器 CS30 300Aac/5Vdc29610MJ68-18密封圈21.4212.84267104020500019互感器 CS30 200Aac/5Vdc29710MJ68-19垫圈30.0660.198682070706006GB/T 67-2000 螺钉 M52080.0030.0249810MJ68-20堵板30.13680.4104692040901004GB/T 97.2-2002 垫圈 512009910MJ68-21压板31.4814.4437024MJ01-3接触器座板35.6316.8910010MJ68-22压片30.03780.11347124MJ0113

21、支架1881012071505009GB/T 70.1-2000 螺钉 M1050140.0390.54672104020202028变压器 GX-0.5/1.14/36V/25V/24V-73016.56.51022071505006GB/T 70.1-2000 螺钉 M1035140.030.4273104020202057变压器 GKB-0.35/1.14/220V/32V/27V/20V/15V14410314MJ30-26密封圈1742070607006GB/T 68-2000 螺钉 M625120.0050.0610414MJ30-16接线弯头14.984.987520203060

22、03GB/T 6170-2000 螺母 M6120.0020.02410510MJ08-42胶垫10.0220.02276104020301001隔离开关 GM2-400/1140V10010610MJ08-19接线弯头13.783.7877104020301002隔离开关 GM3-250/1140V110714MJ60-3密封圈10.680.687814MJ30-4隔离开关座板15.015.0110810MJ08-17垫圈10.00510.0051792011107020GB/T 5783-2000 螺栓 M1225150.0250.37510910MJ08-16堵板10.030.03801

23、04030900029电抗器电容器组 TX-D4-04LC111010MJ08-18压板10.560.568124MJ0107开关腔上盖185.2285.2211110MJ08-39压板10.0750.07582104020703002熔断器 RT0-200A/150A61122071504005GB/T 70.1-2000 螺钉 M825420.0150.63832070608006GB/T 68-2000 螺钉 M830120.0120.14411310MJ68-11接线弯头24.8449.688842020308003GB/T 6170-2000 螺母 M8120.0050.061141

24、0MJ68-12密封圈30.4891.4678524MJ0108牵引变压器腔上盖171.3271.3211510MJ68-14垫圈30.09560.28688624MJ01-1小盖板113.113.111610MJ68-13堵板30.20780.62348724MJ0112接线腔左盖板164.3664.3611710MJ68-15压板31.424.268822MJ0807主接线柱120.51936.231611810MJ68-16压片30.0430.12924MJ01B电控部明细表序号图号图名数量单重总重序号图号图名数量单重总重11910MJ68-23胶垫30.020.061204MJ08-2

25、4垫圈440.0110.4841214MJ08-23A密封圈180.0160.2881224MJ08-22堵板220.0270.5941232071504008GB/T 70.1-2000 螺钉 M840440.020.881242071503004GB/T 70.1-2000 螺钉 M616440.0050.221254MJ08-21压板220.0110.2421264MJ08-20喇叭口220.46810.29612722MJ08-41密封圈40.0220.08812824MJ0188电气系统框图11291301311321331341351361371381391401411421431

26、4414514614724MJ0102操作盖24MJ0103A显示盖板24MJ0104开关腔前盖24MJ-FT5A电气原理图24MJ-FT6A电气接线图 第1.21页MG300(200、250)/730(530、630)-WD采煤机出厂图册24MJ02B左牵引部24MJ02B左牵引部明细表序号图号图名数量单重总重序号图号图名数量单重总重11990202001液压用液位液温计 YWZ-80T13024MJ02-1后盖板1464622011108006GB/T 5783-2000 螺栓 M165040.0920.3683114MJ0202惰轮轴组件132.132332.13233204050200

27、9GB/T 93-1987 垫圈 16160.0070.1123210MJ01-10堵11.021.0241110300006接头座 JKU-1910.2710.2713310MJ01-11压盖10.370.3751110200006堵 JKD-1910.1170.117341060102035GB 1235-1976 O形密封圈 803.1161110100006U形销 UK-1910.0220.0223524MJ0201B左牵引部机壳15380538071060110011JB982-1977 垫圈 3013614MJ02-7A套25.2410.4881060102017GB 1235-1

28、976 O形密封圈 242.413714MJ02-6A套23.286.5692071506002GB/T 70.1-2000 螺钉 M1225520.0351.823814MJ0201行星减速器1632.609632.609102040502007GB/T 93-1987 垫圈 12520.0040.208392071508003GB/T 70.1-2000 螺钉 M1635120.0841.008111060103201GB 1235-1976 O形密封绳 5.71260401030101012电动机 YBQYS3-5014204201214MJ0206盖板117.5917.5913MDP0

29、108透气塞10.370.371414MJ0204A盖板139.0539.05151110300005接头座 JKU-1610.2280.228161110100005U形销 UK-1610.0180.018171060110010JB982-1977 垫圈 271181110300003接头座 JKU-1020.0840.168191110100003U形销 UK-1020.0090.018201060110008JB982-1977 垫圈 2220.0040.0082114MJ02-4小盖板19.49.42210MJ0108放油塞10.240.24232100201016Q/JM 861-

30、2001 垫圈 3310.0060.00624104020600132 矿用本质安全型温度传感器 GWD2001251060110007JB982-1977 垫圈 2012610MJ0101一轴147.11547.11527MDP0216液压制动器110.210.22810MJ01-12小压板10.1340.1342910MJ0102二轴159.46959.46914MJ0201行星减速器14MJ0201行星减速器明细表序号图 号图 名数量单重总重序号图 号图 名数量单重总重110MJ0103-3座142.8542.8530MEK0212-9行星轮46.9727.88214MJ0201-3行星

31、架146.8846.88312050417001Q/JM 114.2-2006 销子 255040.1460.584310MJ0103-2齿轮152.252.232MEK0212-12外套40.0660.26442050416002Q/JM 114.2-2006 销子 204520.0870.17433MEK0212-13行星架18585510MJ0103-1联接盘115.615.63414MJ0201-1盖174.874.862031008073GB/T 894.1-1986 挡圈 18010.1420.14235MEK0212-14心轴43.112.4714MJ0201-5垫10.040.

32、04361011605018SKF 滚动轴承 16044/22034037182030307051GB/T 893.1-1986 挡圈 9010.0250.02537MEK0212-16小盖119.519.5914MJ0201-6垫10.140.1438MEK0212-17套13.43.41014MJ0201-2太阳轮14.864.863914MJ0201-4大太阳轮110.410.4111010617008GB/T 276-1994 滚动轴承 61936322.6401060102031GB 1235-1976 O形密封圈 653.110.0030.0031210M

33、J0103-21套10.070.0741MEK0212-3限位垫10.050.051310MJ0103-20挡圈10.190.1942MEK0212-2塞10.040.04142071508002GB/T 70.1-2000 螺钉 M163080.0770.616432031007045GB/T 894.1-1986 挡圈 6510.0180.018152040502009GB/T 93-1987 垫圈 1680.0070.056441060102105GB 1235-1976 O形密封圈 2055.71162071506003GB/T 70.1-2000 螺钉 M1230280.0391.0

34、92451060108127GB/T 9877.1-1988 密封圈 BD220250151172040502007GB/T 93-1987 垫圈 12280.0040.11246MEK0212-18调整垫片50.0240.121814MJ0201-7套30.020.06471060102149GB 1235-1976 O形密封圈 3708.611914MJ0201-8行星轮36.73520.205481060102159GB 1235-1976 O形密封圈 5008.61202030307059GB/T 893.1-1986 挡圈 11030.0480.14449MEK0212-19O形圈5

35、25x8.610.0020.0022114MJ0201-9内齿圈147.56947.569502030308062GB/T 893.1-1986 挡圈 12040.0570.228221010201008GB/T 288-1994 滚动轴承 22212C/601102861.126.725110102010519GB/T 288-1994 滚动轴承 22311C/551204382.2718.162314MJ0201-10轴32.537.59242030307043GB/T 893.1-1986 挡圈 7030.0160.0482514MJ0201-11联接盘153.8353.832614MJ

36、0201-13环10.140.14271010616010GB/T 276-1994 滚动轴承 61928/1401902411.71.72814MJ0201-12齿圈165.3465.3429MEK0212-11内套40.0850.3414MJ0202惰轮轴组件10MJ0101一轴10MJ0102二轴MDP0216液压制动器24MJ03B右牵引部24MJ03B右牵引部明细表序号图号图名数量单重总重序号图号图名数量单重总重11990202003液压用液位液温计 YWZ-150T1302040501005GB/T 93-1987 垫圈 840.0020.008215MJ0201控制阀组168.4

37、96668.4966311060102039GB 1235-1976 O形密封圈 1003.110.0040.00432040502009GB/T 93-1987 垫圈 16330.0080.264322100104012Q/JM 864-2001 内六角螺塞 M33210.110.2242071508009GB/T 70.1-2000 螺钉 M1665100.131.3332100201016Q/JM 861-2001 垫圈 3320.0060.018524MJ03-4滑轨26.5133424MJ03-5盖11.441.4462100104027Q/JM 864-2001 内六角螺塞 M30

38、1.510.1090.109351991100019过滤器 WU-160180-J10.40.472100201014Q/JM 861-2001 垫圈 3010.0060.0063610MJ0108放油塞10.240.24824MJ0304压力表组110.14310.1433714MJ02-7A套25.2410.4892011108003GB/T 5783-2000 螺栓 M163530.0640.1923810MJ01-10堵11.021.02102011108006GB/T 5783-2000 螺栓 M165040.0920.3683910MJ01-11压盖10.370.37111030101012电动机 YBQYS3-501420420401060102035GB 1235-1976 O形密封圈 803.11121990202001液压用液位液温计 YW