ups检测报告单

1、Three Phase Input/Three Phase Output 10/30KVA UPS Shipment AccessoriesNOP/NDescriptionQtyUnitOperatorQcRemark1TD33 UPS System User Manual1EA2UPS Warranty1EA3UPS Installation Report1EA4Terminal Embedded Software,Monitoring Software And Disk1EA5System Test Report1EA6RS232 Connecting Wire1EA三进三出10/30KV

2、A UPS发货附件清单序号项目编码项目描述数量单位点料员检验员备注1TD33系列UPS系统用户手册1EA2UPS电源保修单1EA3UPS设备安装报告1EA4终端物理元件-监控软件单机版和光盘1EA5系统测试报告1EA6RS232连接线1EAUPS检测报告单 UPS INSPECTION REPORT对外型号Model系统条码System serial numberUPS系列：UPS Serial：类别Category代码Code检验项目Inspection Item检验标准Inspection standard检测结果Inspect resultA外观AppearanceA1表面、丝印、标识S

3、urface，Screen Printing，Marking无明显凹痕、划伤、裂隙、变形、脏污、色差。标识内容和位置正确，无缺划。No evident dent、destruct、cranny、distortion、dirty、chromatic aberration，Correct Content and Location，No Lack strokes of font. OK NGA2结构件Mechanical component各结构件外观良好，连接良好，各活动门开关正常Finish and cosmetic meet corporation standard，mechanical co

4、mponents comply with the drawing and are well connected，hinge are flexible OK NGA3器件和开关功能Electrical part and switch function test型号正确、安装紧固到位，开关功能检测正常Correct model，tightly mounted，switches function meet test Spec. OK NGA4配线工艺Wiring and binding各连接电缆连接紧固，走线符合工艺要求All cables are well fastened and meet cr

5、aftsmanship requirement OK NGB电气性能测试ElectricalPerformanceB1绝缘电阻Insulation Resistance输入端、输出端对地施加500V直流电压，绝缘电阻2MInput and output to ground R2M with 500Vdc OK NGB2接地电阻Earth Resistance系统内等电位金属结构件与接地排之间的电阻0.1Resistance between Mechanical component and ground bus-bar0.1 OK NGB3绝缘强度Dielectric Strength漏电流1m

6、A(2820Vdc,1min,无击穿或飞弧)Leakage current1mA(2820Vdc，1min without arc or breakdown) OK NGB4对地漏电流Earth leakage current正常工作时3.5mA,若机箱上贴有告警标签，则不超过输入电流的5%Normal work3.5mA，If there is alarm label in enclosure，It can not exceed 5% input current. OK NGB5输出电压稳压精度Output voltage precision±2% OK NGB6输出波形失真度Ou

7、tput voltage THD9 （RCD 满载）3 （R 满载） OK NGB7输出频率Inverter output Frequency1） 与输入频率相同（46Hz54Hz）The same as Input Frequency（46Hz54Hz）2）50Hz（市电频率>54Hz或者市电频率<46Hz)50Hz（AC Frequency more than 54Hz or AC Frequency less than 46Hz） OK NGB8系统保护功能Function of system alarm输入过/欠压、电池电压低、逆变输出过载等告警正常，测试过程中无其他异常响

8、声。Input over-voltage and under-voltage protection，Battery low、invert overload etc，Noabnormal noise during test. OK NGB9市电电池切换时间Battery transfer time0ms OK NGB10旁路逆变切换时间Bypass transfer time1ms OK NGB11面板功能检测Panel function test按键灵活，测试过程中LED指示正确、LCD上各项运行参数信息及告警信息显示正常，无缺面。Flexible Button，LED correct ind

9、ication、LCD correct display for every operational parameter、alarm message and no lack strokes of font. OK NGB12通讯功能检测Communication function testRS232/RS485接口，SNMP卡，干接点RS232/RS485, SNMP, Dry-contact OK NG系统设置C1时间、电压、机器信息以及其他出厂设置Factory default各项参数符合相应文件要求All parameter meet Spec OK NGD附件D1附件及清单Accesso

10、ries list种类、型号、数量、标识正确，清单文字清晰无乱码。Types、Model、Number and Mark is Right，List is right，Clear fonts without disorder. OK NGE包装E1标识、材料及包装工艺Material and package industrial正确，工艺符合要求。Right，Industrial meet requirement OK NG说明：检验结论 Conclusion OK NG调测员Operator： 审核Approval： 日期date：检验员FQC： 审核Approval： 日期date：Thr

11、ee-Phase Input/Single Phase Output 10/30KVA UPS Shipment AccessoriesNOP/NDescriptionQtyUnitOperatorQcRemark1TD31 UPS System User Manual1EA2UPS Warranty1EA3UPS Installation Report1EA4Terminal Embedded Software,Monitoring Software And Disk1EA5System Test Report1EA6RS232 Connecting Wire1EA三进单出10/30KVA

12、UPS发货附件清单序号项目编码项目描述数量单位点料员检验员备注1TD31系列UPS系统用户手册1EA2UPS电源保修单1EA3UPS设备安装报告1EA4终端物理元件-监控软件单机版和光盘1EA5系统测试报告1EA6RS232连接线1EAUPS检测报告单 UPS INSPECTION REPORT对外型号Model系统条码System serial numberUPS系列：UPS Serial：类别Category代码Code检验项目Inspection Item检验标准Inspection standard检测结果Inspect resultA外观AppearanceA1表面、丝印、标识Sur

13、face，Screen Printing，Marking无明显凹痕、划伤、裂隙、变形、脏污、色差。标识内容和位置正确，无缺划。No evident dent、destruct、cranny、distortion、dirty、chromatic aberration，Correct Content and Location，No Lack strokes of font. OK NGA2结构件Mechanical component各结构件外观良好，连接良好，各活动门开关正常Finish and cosmetic meet corporation standard，mechanical comp

14、onents comply with the drawing and are well connected，hinge are flexible OK NGA3器件和开关功能Electrical part and switch function test型号正确、安装紧固到位，开关功能检测正常Correct model，tightly mounted，switches function meet test Spec. OK NGA4配线工艺Wiring and binding各连接电缆连接紧固，走线符合工艺要求All cables are well fastened and meet craf

15、tsmanship requirement OK NGB电气性能测试ElectricalPerformanceB1绝缘电阻Insulation Resistance输入端、输出端对地施加500V直流电压，绝缘电阻2MInput and output to ground R2M with 500Vdc OK NGB2接地电阻Earth Resistance系统内等电位金属结构件与接地排之间的电阻0.1Resistance between Mechanical component and ground bus-bar0.1 OK NGB3绝缘强度Dielectric Strength漏电流1mA(

16、2820Vdc,1min,无击穿或飞弧)Leakage current1mA(2820Vdc，1min without arc or breakdown) OK NGB4对地漏电流Earth leakage current正常工作时3.5mA,若机箱上贴有告警标签，则不超过输入电流的5%Normal work3.5mA，If there is alarm label in enclosure，It can not exceed 5% input current. OK NGB5输出电压稳压精度Output voltage precision±2% OK NGB6输出波形失真度Outp

17、ut voltage THD9 （RCD 满载）3 （R 满载） OK NGB7输出频率Inverter output Frequency2） 与输入频率相同（46Hz54Hz）The same as Input Frequency（46Hz54Hz）2）50Hz（市电频率>54Hz或者市电频率<46Hz)50Hz（AC Frequency more than 54Hz or ACFrequency less than 46Hz） OK NGB8系统保护功能Function of system alarm输入过/欠压、电池电压低、逆变输出过载等告警正常，测试过程中无其他异常响声。I

18、nput over-voltage and under-voltage protection，Battery low、invert overload etc，Noabnormal noise during test. OK NGB9市电电池切换时间Battery transfer time0ms OK NGB10旁路逆变切换时间Bypass transfer time1ms OK NGB11面板功能检测Panel function test按键灵活，测试过程中LED指示正确、LCD上各项运行参数信息及告警信息显示正常，无缺面。Flexible Button，LED correct indica

19、tion、LCD correct display for every operational parameter、alarm message and no lack strokes of font. OK NGB12通讯功能检测Communication function testRS232/RS485接口，SNMP卡，干接点RS232/RS485, SNMP, Dry-contact OK NG系统设置C1时间、电压、机器信息以及其他出厂设置Factory default各项参数符合相应文件要求All parameter meet Spec OK NGD附近D1附件及清单Accessorie

20、s list种类、型号、数量、标识正确，清单文字清晰无乱码。Types、Model、Number and Mark is Right，List is right，Clear fonts without disorder. OK NGE包装E1标识、材料及包装工艺Material and package industrial正确，工艺符合要求。Right，Industrial meet requirement OK NG说明：检验结论 Conclusion OK NG调测员Operator： 审核Approval： 日期date：检验员FQC： 审核Approval： 日期date：UPS安装巡检记录表 编号： 用户名称：地址：设备使用/管理者姓名：E-Mail：联系电话：传真：联系人：机型：机号：经销商：电池品牌：电池容量： AH电池数量： pcs负载容量：负载类型：是否并机： 是/ 否安 装 记 录1） 通风是