开迪空调系统AIRCONDITION

1、会计学1开迪空调系统开迪空调系统AIRCONDITION2 Climatic, operation空调操纵装置 Air flow, cooling circuit空气流动，冷却循环 Sensors/actuators传感器/执行元件 CAN system network网络 Tools工具3Control unit with seat heater带座椅加热的控制单元带座椅加热的控制单元Heating加热加热4Control unit with seat and parking heater带座椅加热和停车加热的控制单元带座椅加热和停车加热的控制单元Heating加热加热5There are

2、6 types of heating and 6 types of climatic control六种类型六种类型:- With and without instant heat button for parking heater带和不带停车加热键- With and without potentiometer for seat heater带和不带座椅加热旋钮- With and without rear windscreen heater带和不带后风档加热New! Tell-tale lights新型提示灯新型提示灯Floating arrangement 不固定的排列不固定的排列Con

3、trol unit控制单元控制单元 Heating/Climatic加热加热/空调空调6Climatic空调空调Control unit with seatand parking heater带座椅加热和停车加热的控制单元带座椅加热和停车加热的控制单元ECON7ECONInternal temperature sensor内部温度传感器内部温度传感器Climatic空调空调8Internal temperature sensor内部温度传感器内部温度传感器Integrated thermal/visual sensor整合的温度和光照强度传感元件整合的温度和光照强度传感元件优点：无杂质通过鼓风

4、机、低成本、无优点：无杂质通过鼓风机、低成本、无机械旋转部件机械旋转部件ECONClimatic空调空调910Pollen filter花粉滤清器花粉滤清器Air flow空气流动空气流动1112Pollen filter花粉滤清器花粉滤清器活性炭过滤器Air flow空气流动空气流动13Air flow空气流动空气流动Climatic空调空调前部圆形出风口 风窗出风口 脚坑出风口 前排乘员脚坑出风口 后排乘员左侧出风口 前 排乘员中央副仪表板处出风口 后排乘员出风口14With rear air outlet带后出气口带后出气口 If rear outlet is absent, blind

5、 caps are fitted不带后出气口安装堵盖不带后出气口安装堵盖 Air outlet in centre console肘托出口肘托出口Right and left air outlets in footwell左、右脚窝出口左、右脚窝出口Air outlet in rear footwell后脚窝出口后脚窝出口Blind capsAir flow不同空气流动不同空气流动1516G263G65Expansion valve膨胀阀Dryer干燥器Cooling circuit制冷循环制冷循环System overview系统概述系统概述17Expansion valve膨胀阀膨胀阀Hi

6、gh pressure sensor 高压传感器高压传感器G65Dryer干燥器干燥器Evaporator蒸发器蒸发器System overview系统概述系统概述Cooling circuit制冷循环制冷循环18- Individual block connections特殊连接特殊连接, no quick-release couplings无卸压阀无卸压阀 - Condenser with dryer冷凝器带干燥器冷凝器带干燥器 (as Touran/Golf 5) - Expansion valve in centre of engine compartment膨胀阀在发动机舱中央膨胀阀

7、在发动机舱中央 - Pressure sensor for coolant pressure on compressor压力传感器压力传感器G65在高压侧在高压侧 - One temperature sensor down stream of evaporator 温度传感器温度传感器G263在蒸发在蒸发器下侧器下侧 - Filling quantity 制冷剂填充量制冷剂填充量R134a: 525 +/- 25 grams克克 Expansion valve膨胀阀膨胀阀Cooling circuit制冷环路制冷环路19T.30, T.31, T.15, T.75, T.58dJ131J132

8、J519Z1 V113J162N24V2J65 (Heater加热器加热器)System overview系统概述系统概述Sensors/Actuators传感器传感器/执行元件执行元件20A15 A11 A6 A3J 65T.75/5AT.30/10A A16 A18 A20 A19 A 5 A8MCirculating/fresh airvalve 内外循环转换阀内外循环转换阀V 113Input and output signals输入输出信号输入输出信号J132rightJ131leftC3 C2 C1 C4 C5T.75/40AEarthT.15Sensors/Actuators传感

9、器传感器/执行元件执行元件Heater21 A5 A15 A19 A20 A8 A7J 301 A3 A18 B2 B4高压传感器高压传感器G 65High pressure sensorSensor for air outlet temp. body ventsG191外部温度外部温度Sensor for air outlet temp.EvaporatorG263蒸发器温度蒸发器温度Sensor for airoutlet temp.footwell G192脚窝温度脚窝温度T.75/5A Seat heaterT.30/10AT.31 B8 B7 B5 B1 B11 B9 B10B7 (

10、5 Volt )B8 (Earth) 1 2 3MMCirculating/fresh air valve V113内外循环转换阀内外循环转换阀Temperature valve V68/G92温度调节电机及传感器温度调节电机及传感器T.15A 5AT.31Comfort CANInput signals输入信号输入信号5 VoltEarthHighLowClimaticSensors/Actuators传感器传感器/执行元件执行元件22 A16 A13 A12J301ClimaticBLOWERSWITCH鼓风机开关V2C3 C2 C1 C4 C5T.75A N24 Parking heat

11、er停车加热停车加热T.31400 Hz-PWM3 2 41N280Output signals输出信号输出信号J 132 rightJ 131 leftSensors/Actuators传感器传感器/执行元件执行元件23PSCU能源能源控制单元控制单元Load负荷负荷Reversing switchWiper雨刮雨刮Heated rear 后窗后窗windscreen加热加热Gateway网关网关ECU控制单元控制单元Speed速度速度COMBIPARKING HEATE停车加停车加热热Cooling water temperature冷却液温度冷却液温度CAN system network

12、控制单元局域网控制单元局域网ECON24Supply package1 x test cable 57-pin1 x cover plateManufacturerCar tool, IngolstadtASE 441 024 00 000V.A.G 1598/42V.A.G 1598/47Tools工具工具25驻车加热系统Caddy选装Thermo V Top驻车加热系统。驻车加热控制单元集成在加 热单元里燃烧空气的电子开关直 接安装在控制单元上驻车加热在加热单元里安装 了第二个NTC温度传感器， 能够提高冷却液温度的监控 和调节效果。通过真空喷射器，将燃油喷 出，并与燃气混合。2627282931 Climatic, operation空调操纵装置 Air flow, cooling circuit空气流动，冷却循环 Sensors/actuators传感器/执行元件 CAN system network网络 Tools工具32Climatic空调空调Control unit with seatand parking heater带座椅加热和停车加热的控制单元带座椅加热和停车加热的控制单元ECON33Air flow空气流动空气流动Climatic空调空调前部圆形出风口 风窗出风口 脚坑出风口 前排乘员脚坑出风口 后排乘员左侧出风口 前 排乘员中央副仪表板处出