电池规格书模板

1、精品资料Specification Approval Sheet产品规格承认书Customer客户名称：域拓Model产品型号：4LType产品类型：Li-ionbatterySpecification 产品规格：3.7V/1400mAHsigned by client客户签名Confirmed 确认：Checked 审核：Approved 批准：signed by manufacturer生产商签名肖泽建Prepared 制定:Checked审核：Approved批准：丁明谊AMENDMENT RECORDSModification TimeDescriptionIssued DateApp

2、roved By0New release2015-06-26Catalogue 目 录1 .Battery type and scope 电池型号和适用范围 41 . 1: model 产品型号： 41 . 2: scope 适用范围： 客户定义 42 . Basic character and compose of battery 电池的基本特性及组成 42.1: fundamental performance parameter of battery电池基本性能参数： 42.2: Main components and parts 主要零部件62.3: Regular performanc

3、e and unfailing performance产品常规性能和可靠性能 62.4: Contour Dimension of the Battery电池外形尺寸 113 . Specifications of Parts 零部件规格 1623.1: fender 保护板1623.2: general electric and protection characters一般电气与保护特征 1623.3: electric schematic diagram of battery电池电路原理图：1833.4: . 3 : PCB layout 电路布局图 .错误！未定义书签。34 . Spe

4、cifications of the Cells 电芯规格 194Announcements 注意事项 205Danger 危险205Warnings 警告226Announcements注意事项2371 .Battery type and scope电池型号和适用范围This Specification Approval Sheet is for rechargeable Li-polymer battery provided by Shirui BatteryCo., LTD.This product is according with the national standard of P

5、RC. GB/T18287-2000 . General specification of lithium-ion battery for cellular phone.本规格书为时瑞电池有限公司提供的可充电式锂离子电池规格。此产品符合中华人民共和国国家标准GB/T18287-2000 蜂窝电话用锂离子电池总规范。1 . : model产品型号：4L2 . Basic character and compose of battery电池的基本特性及组成3 . 1 ： fundamental performance parameter of battery电池基本性能参数：S/NDetailsp

6、arametersremarks序内容参数备注号1Rated voltage额定电压3.7V2Rated capacity额定容量1400mAHdischarge with 0.2C to 2.75V after Complete charge within 1h, measuring the discharge power完全充电后1小时内，用0.2C放 电至2.75V ,测量其放电电量。截止电压2.9-3.1V3Limited charge voltage充电限制电压4.25V4internal resistance内 阻司 50m Q5charge mode充电方式C.C/C.V.恒流/

7、恒压力式恒流/恒压6Charge time充电时间6HStandard charging 0.2C280mA标准充电0.2C (280mA)2.5H1C (280mA)7Max Charge Current最大充电电流1400mA9Max discharge currentLasting 持 续：1400mA最大放电电流Transient peak 瞬间峰值：2800mA10Working temperature工作温度charging充电时045 Cdischarging 放电时-2060 C11Storage temperature贮存温度1 Month 一个月-2060 CCharge

8、to 40%50% of capacity when storage 贮存时应充电至容量的 40%50%6 months六个月-2030 C12Storage humidity贮存湿度Re lative humidity65 20%RHrelative humidity相对湿度13weight重量约32g14Self-discharging自放电When the battery pack is without load, certain operational current is consumed since the cell protects the circuit, thus leadi

9、ng to the bringing down of pack voltage. For long storing time, please supplement the charging and note theseventh. Special notice ”Pack before shipping出贷标准Charged with about 25-35% power and the voltage is 3.8-3.95 V being shipping.15Identify resistanceID识别电阻68K QTo ground16Cycle life循划、寿命300 times

10、300循环次capacity 菊0 %容量60 %If you need the battery protection parameters, please refer to PAGE 11.如需参考电池保护参数，请参阅第 11页2.2 ： Main components and parts 主要零部件材料Materials材料model型号规格quantity数量related technical parameters相关技术参数manufactur er）商li-ion battery cell锂离子电池芯484461AR1PCSPlease refer to the battery ce

11、ll specification请参照电芯规格书/protection board保护板XHY-FHLN-4L1PCS/2.3 ： Regular performance and unfailing performance产品常规性能和可靠性能S/N厅Pinspecti on item 检验项目Standard标准Testing Method测试方法1high tempera tureproperty 高温性能discharge with 0.5C 5A not less than 100mins under 55 + 2 C ,the appearance without distortio

12、n and crack.电池在55 2 C ,用 0.5C5A放电时间/、少 于102min,电池外观无 义形、无爆裂.set the battery 2h in the environment with 55 土2 C after Complete charge, then discharge with0.5C5A完全充电后置于55 2c ,2h用0.5C5A放电2Low tempera ture property 低温性 能discharge with 0.2C 5A not less than 3h under -20 2 C ,theappearance without distort

13、ion and crack.电池在-20 2 C ,用 0.2C5A放电时间/、少 于3h,电池外观无变 形、无爆裂.set the battery 16-24h in the environment with-20 二 C after Complete charge, then dischargewith 0.5C 5A,then set the battery in 20 =t5 , 2h later observe the battery appearance完全充电后置于-20i2C,16-24h用0.2CA放电，结束后将电池置于20 i5 c条件下搁置2h,观察电 池外观.disch

14、arge with 0.2C 5A not less than 3.5h under -10 2 C ,the appearance without distortion and crack在-10i2 C,用 0.2C 5A 放电时间不少于 3.5h, 电池外观无变形、无爆裂.set the battery 16-24h in the environment with-10 C after Complete charge, then dischargewith 0.5C 5A,then set the battery in 20 =t5 , 2h later observe the batt

15、ery appearance完全充电后置于-10i2 C ,16-24h用0.2C5A放电，结束后将电池置于20 i5 c条件下搁置2h,观察电 池外观.3Capabilityofkeepingelectricity荷电保持能力Discharge not less than4.25h放电时间/、少于4.25hOpen circuit 28d under the environment with 205 C after complete charge, then discharge with0.2C5A完全充电后，在20i5c条件下，将电开路搁置28d,再0.2C5A放电.4Constan t

16、damp and hot property 恒定湿 热性能Battery appearance should have no obvious deformation, rust,smokeorexplosion, discharge time not less than 36min电池外观应无明显变 形、锈蚀、冒烟或爆炸， 放电时间不低于 36min.After complete charge, shelve the battery in thecondition of 40 芝 C Relative humidity is 90% -95% with constant temperature

17、 and humidity,48h later, shelve it in 20 i5 c 2h, then discharge with 1C 5A完全充电后，在40及C，相对湿度为90%-95%的恒温恒湿条件下搁置48h后，再取出放在20i5c条件下搁置2h再以1C5A放电.5shake振动Battery appearance should havenoobvious deformation, rust,smokeorexplosion, voltage not less than 3.6V电池外观应无明显变 形、冒烟或爆炸，电池 电压不彳3.6V.After fully charged

18、with 0.38 mm amplitude, make 10Hz 30Hz resonant frequency, batteries installed in vibration bench, set upX.Y.Z three direction from swept-frequency rate for 1oct/min, circular sweep frequency vibration 30min完全充电后，以0.38mm振幅作谐振10Hz55Hz 的频率，将电池安装在振动台上，设置好X.Y.Z三 个方向上从扫频速率为1oct/min,循还扫频振动30min6FreeDropTe

19、st自由跌落Batteryappearanceshould have no leakage, no smoke or explosion, but allowedslightdeformation电池允许轻微变形，但 应/、漏液，不冒烟，不爆 炸。After crash test, the sample batteries are dropped on the 18-20mm hardwood of the concert floor from 1000mm height according to positive and negative 6 direction of X,Y,Z. Each

20、 direction should test one time.碰撞试验结束后，将样品电池从1000mm局处自 由跌洛于水泥地面上的 18-20mm 厚的硬木板 上，从X,Y,Z正负六个方向每个方向1次.7Perform ance of overcha rge protecti on过充电 保护性 能Batteries should be no explosion, no fire, no smoke or leakage电池应/、爆炸，不起火， 不冒烟或漏液.After the battery is fully charged, the battery should be loaded 8h

21、 with constant currentsource. The constant current source sets to 2 times nominal voltage and current sets 2CA.电池完全充电结束后，用恒流包压源给电池加载 8h,恒流恒源设定为2倍标称电压，电流设定为2c5A8Perform ance of over-dis charge protecti on过放电 保护性 能Batteries should be no explosion, no fire, no smoke or leakage.电池应/、爆炸，不起火， 不冒烟或漏液.Under

22、 the conditions of an ambient temperature20 右 C ,the battery discharge in the conditions of 0.2C 5A until voltage is termination. And then, battery discharge 24h with connecting a 30 Q load resistance.电池在环境温度20 5C的条件下，以0.2C 5A放电 至终止电压后，外接30 Q负载电阻放电24h.9Perform ance of short-cir cuit protecti on 短路保

23、护性能Batteries should be no explosion, no fire, no smoke or leakage; batteries voltage is not less than N*3.6V after instantaneous charge.电池应/、爆炸，不起火， 不冒烟或漏液；瞬时充 电后电池电压不低才 N*3.6V.After battery is fully charge, positive and negative electrode should be circuit 1h with 0.1 Q .And,battery should be charg

24、ed 5S instantaneous with 1C5A after positive and negative electrode are cut off.电池完全充电后，将正负极用0.1 Q电阻短路1h, 将正负极断开后，电池以1C5A电流瞬时充电5S.No fire, No explosionKeep the connected electric couple battery in a fume hood and make positive and negative short circuit(the total resistance should be less than 50m Q

25、). Tester should monitor temperatureShort-circuit TestTheoutsidetemperature of battery is not higherchanges. If the temperature of battery drops to about 10 C lower than the max temperature, test is finished.短路150 C.不起火，不爆炸，电池外部温度不高于150c.本项试验将接有电热偶的电池置于通风橱中，短路其正负极（线路总电阻不大于 50m Q）,监视温度 变化，当电池温度卜降到比峰值

26、低约 10 c时，试验 结束.1011Cycle life 循环寿命Charging life cycle is over 300 times俯环寿命不低于300次容量大于60%.After 300 cycle ,Capacity 釜0%The battery used for testing of cycle life should be charged with constant 0.5CA at constant temperature of 20 C 5 .The battery is charged with constant voltage till 20mA when it is

27、 charged to the limited voltage.Then discharge it with constant 0.5C5A till the end voltage after stop charging for 0.5-1h, repeat the next cycle. It means the discharging time less than 36min of two consecutive cycles while reaching its end of the life.电池循环寿命试验应在20 c i5 C ,以0.5CA充电， 当电池端电压达到充电限制电压时

28、 ，改为恒压充 电，直到充电电流小于或等于 20mA,停止充电搁 置0.5h-1h,然后以0.5C5A电流放电至终止电压， 放电结束后，搁置0.5-1h,再进行卜一个循环，直至 连续两次放电时间小于36min.则认为寿命终止.The storage test of battery should be selected abattery which is less than 3 month from12Storage贮存Fully charge the batt ery ,which is new manufactured shorter than 3 months, with0.2C,then

29、 discharge times less then 4hours .production date to the date of experiment.Before storage, battery capacity should be full charged 40%50% capacity, the ambient temperature is 20 c 5 C and relative humidity is 45%-75%.After the storage expiration of battery, battery should be charged and discharged

30、 according to fully charged and discharged.电池贮存3个月，经完全充电后，0.2C5A,放电时问/、小于4h.进行贮存试验的电池应选自生产日期到试验日期不足3个月的电池，电池贮存前应按元全充电的40%50%的容量，在环境温度 20 C +5 C ,相对湿 度45%-75%的环境中贮存，贮存期满后，电池按完 全充放电制进行充放电.2.4 :Contour Dimension of the Battery电池外形尺OLO-HO2992.5 Label (Not to scale )标贴C82 4L-intex 96 5*643MMG 10 5cm合成纸75

31、# +哑膜INTGXMODEL ND.:BR 14 AR154Qf|iiAh/5i-55WtiLUCJN3.TV-U4E MJf/EC府外七仙口岷A DO Mar D1S*5INBLE OH FUT H FML-DdHn BME CRCUIT 3HDRr-U5E H DRY hlRDHKhT-WnH SURHQLMW TTNPEW*njffE IWTMADE MWarniiigii ii ill ii ii ii i ill ii mini3 . Specifications of Parts 零部件规格3 .1: fender DW01-P,8205A 保护板 DW01-P,8205A般电气

32、与保护特征保护IC的型号：DW01-P3.2: general electric and protection charactersModel of Protection IC : DW01-PItemsSpecificationRemarks项目规格备注Over-charging ProtectionVoltage过充电保护电压4.28V i0.05VOver-charging ReturnVoltage过充回复电压4.08V W10VOver-discharge ProtectionVoltage过放电保护电压2.4Vi0.10VOver-discharge ReturnVoltage过放

33、回复电压3.0V W10VOver-current Protection过电流保护2-5ADetection Delay Time ofOver-charging Protection过充电保护侦测延时时间磴00msDetection Delay Time ofOver-discharging Protection过放电保护侦测延时时间0120msDetection Delay Time of Over-current Protection 过电流保护侦测延时时间唠0mSDetection Delay Time ofOutput short-circuitProtection输出短路保护侦测延

34、时时间320US(Typical)Internal Resistance ofProper Functioning正常工作内阻60m QConsume Current消耗电流迨0uA3.2 electric schematic diagram of battery电池电路原理图:3.3 PCB layout 电路布局图Top LayerLower layerB-y- ID bXkA-EHMW . 4 . Specifications of the Cells 电芯规格NO.厅pItems项目Parameters参数Tolerance公差Term条件Remark/ condition 备注/条件

35、1Appearance外观No mechanical damage, leakage , sink ,drum and so on 无机械损伤、漏液、下陷、发鼓等现象/50cm distanceunder 40Wdaylight lamp在40W日光灯下50CM处Visual目视2Dimensions尺寸Length长61.0mm-0.5mmDigital caliper数显卡尺Width宽44.0mm-0.3mmThicknes s 厚4.8mm+0.1m m3Voltage电压3.85-3.92V/万用表4Capacity容量*400mAH/0.2C5Internal resistance

36、 内阻60m Q/1KHz/6Consistency同批一致性Appearance quality is the same同批外观质量相同7Security安全性Correspond to related safety performance符合相关安全性能5保质期电池的保质期为出厂后一年。本公司承诺如果在一年中由于电池本身的质量问题，本公司将负责进行调换，如果 是由于用户误用而产生的问题，不予调换。Announcements 注意事项Danger 危险To prevent battery from weeping, fever, exploding ,please obey the rule

37、s as follows:为了防止电池漏液、发热、爆炸，请遵守以下防范事项：Do not immerse the battery into the water or the sea, Guard against Damp;不要将电池浸入水或海水中，注意防潮Do not approach the heat source, like fire or heater;不要将电池接近热源，如火或发热器。Please use the appointed charger when charging;在充电时,请用指定的充电器。Do not transposition the +.- poles of the

38、 battery to charge;不要反接电池的+ -极进行充电。Do not direct-connected the battery to alternating current power supply, or autoignition of the vehicle;不要将电池直接连接在交流电源，或者车辆自动点火处。Do not discard the battery to the fire or hyperpyretic objects;不要将电池弃置于火里或高热的物体上。Do not use the conductor to lead the short circuit of t

39、he + -poles of the battery. Do not put the battery with metallic conductors to transport or store, like necklace, hairpin and so on;不要将电池的+ -极用导体短路、不要把电池和金属导体，如项链、发夹等一起运输或存储。Do not beat or throw the battery;不要敲打或丢抛电池Do not impale the battery with needle or some other sharp things, do not strike it w

40、ith weight;不要用针或其它锋利物刺穿电池，不要用重物击打电池。As installed safety device in the battery, please do not resolve or change any other sections of the battery to protect the inherent safety functions;电池内有安全装置，为了保证其固有的安全功能，请不要将电池分解开或改变任何的部份Warnings 警告Do not put the battery to the microwave oven or pressure tank;不要

41、将电池放入微波炉或压力柜子里。Do not use the battery with some chemical batteries (like dry battery) or different capacities and brands battery together, if the battery emits the smell, heat , changes color, be out of shape or appears any other abnormal phenomena during the charging or stored procedures, please ge

42、t out the battery from the device or charger and stop using;不要将电池与其它化学电池(像干电池)或不同容量、牌子的电池合用，若电发出气味、发热、变色、 变形或者在使用充电、存储过程中，出现任何的不正常请立即从装置或充电器取出，停止使用。If can not recharge within the charging period, please not continue charging;指定充电时间内若不能再充电请不用继续充电Put the battery to where the kids can not touch, if the

43、 kids swallow the battery , pleaseseeing the doctor soon;电池放于小孩不能触摸的地方，若小孩咽下电池，请立即就医。If the electrolyte of the battery into the eyes, do not rub ,should wash the eyes first ,then see the doctor;若电池电解质进入眼睛，切勿揉眼睛，先用清水冲洗眼睛后立即就医。Announcements注意事项Do not put the battery under the high temperature places (like sunshine irradiation or car in the hot weather), or it will catch fire for the heat , reduce the performance and loss the life;不要将电池放于高温处(如阳光直射或热天下汽车里)否则,会过热着火，性能降低和寿命缩短。To insure the safety, the battery should install the safety device