顶驱配件清单明细（带价格）

1、物资名称英文描述厂家订货号倾臂液缸活塞杆密封铜套总成KIT,ROD-SEAL,BRONZE-GLAND,RG2HLTS13108894-G13平衡液缸活塞密封件PISTON SEALS-SAME AS 76764-3108894-P40倾臂液缸活塞密封件KIT,HI-LOAD,PISTON,SEAL108894-P32倾臂液缸总成CYLINDER, HYDRAULIC ASSEMBLY119592IBOP液缸活塞密封件SEAL,LIP,PISTON (Same as 16701-3,87018-2108894-L25背钳液缸活塞杆乱油环WIPER, ROD72221背钳液缸活塞杆密封SEAL

2、ROD72220背钳液缸活塞密封SEAL,PISTON72219旋转头齿轮盘下部组合密封RING,GLYD,11.5 DIA-ROD(S481301 340A-29)30119143旋转头齿轮盘内侧密封RING,GLYD,11.0DIA-ROD30119319旋转头内部油道密封RING,GLYD,10.0 DIA-ROD118375背钳液缸活塞密封SEAL,PISTON72219IBOP液缸活塞密封铜套总成SEAL,ROD/GLAND SET108894-G17弯头SAE -12 BOSS/3756519-12-12S弯头BULKHEAD 37/3756522-6-6-S弯头O-RING BO

3、SS/3756519-8-8-S液压弯头ELBOW,O-RING BOSS/37DEG（液压弯头）56519-6-4-S弯头90 EXT PIPE/3756506-16-16S弯头90EXT/3756506-12-12S弯头90EXT/3756506-8-6-S液压直接头CONN,O-RING BOSS/3756529-8-8-S旋转头B8处接头CONN, O-RING BOSS/3756529-8-4-S液压直接头CONN,O-RING BOSS/37（液压直接头）56529-8-6-S垫片INTERNAL STAR86872-20-S旋转头密封O-RING51300-273-B旋转头齿轮盘

4、下侧密封O-RING51300-381-B开液缸管线ASSY, IBOP CYL, OPEN59024P170023关液缸管线ASSY, IBOP CYL, CLOSE59043P170023倾臂液缸液管线HOSE ASSY,HYDRAULIC,CYL-CRANK ASSY59025P23G028倾臂液缸液管线HOSE ASSY,HYDRAULIC,CYL-CRANK ASSY59043P230042倾臂液缸管线HOSE ASSY, HYDRAULIC CYLINDER, LINK TILT59043P170038背钳液管线(可替换倾臂管线，但较长)HOSE ASSY，CLAMP ROD590

5、44P230074背钳液管线，可替换倾臂管线，但较长HOSE ASSY，CLAMP PISTON59044P230073倾臂液缸管线HOSE ASSY, HYDRAULIC CYLINDER, LINK TILT59025P17N023平衡系统储能器密封包SEALS, ACCUM, 630124575安全阀REDUCING/RELIEVING VALVE99353-1AN减压阀RELIEF VALVE,VENTABLE107031-1AN泄荷阀DIFFERENTIAL UNLOADING VALVE107028-1ANB减压阀RELIEF VALVE94520-1NN逻辑阀LOGIC CART

6、RIDGE94534-1CXN单向阀CHECK VALVE94536-14N单向阀CHECK VALVE94536-230N液控开单向阀PILOT-TO-OPEN CHECK VALVE107029-175N平衡液缸总成ASSEMBLY110703平衡液缸总成ASSEMBLY110704接头CLOSE 1/2NPT53908-BR上端盖内下部密封(MT)OIL SEAL(VITON),STD.BORE,TDS91250-1上端盖与齿轮箱之间O型密封圈O-RING51300-277-B旋转头齿轮盘上侧密封SEAL,WIPER,11.0DIA-ROD119547齿轮泵端盖密封P50 Pump Bo

7、dy Seal109567-S上端盖泥浆橡胶护罩SHIELD, BEARING,SMALL BORE30154362 & 301189595加仑油囊BLADDER,RESERVOIR TDS9S110191-501刹车液缸密封SEAL KIT109528-2刹车弹簧SPRING,BRAKE,DISK,TDS9109528-3刹车螺丝SCREW,RETURN,SPRING109528-4内防喷器驱动液缸125594润滑油泵总成LUBE(ALUM)117603-1齿轮泵端盖密封P50 Pump Body Seal109567-S旋转头驱动马达和定位销总成HYD DRIVE/SHOT PIN

8、, STAINLESS STEEL30151875-504上端盖密封ISOLATOR,UPPER BEARING30173521主轴上部衬套LINER,STEM,UPPER98290散热器HEAT EXCHANGER，OIL30122104旋转头齿轮盘下部组合密封PISTON RING30173156齿轮盘下部扶正环RING,RETAINER,EXTERNAL30117775-2冲管3 INCH BORE123289冲管密封PACKING SEAL KIT (5 PER SET)123292-3冲管总成ASSEMBLY30123290-1000刹车片FRICTION PADS (REPLACE

9、MENTS)109528-1刹车总成BRAKE,CALIPER DISC109528导轨连接销锁销PIN, RETAINER117783导轨连接销PIN, JOINT117782导轨连接销锁销安全销PIN, LYNCH117496-1上IBOP总成UPPER IBOP ASSEMBLY110103-500下IBOP总成LOWER IBOP ASSEMBLY114706-500IBOP驱动轭座CRANK,ASSY,EXTERNAL98898下IBOP修理包REPAIR KIT,LOWER IBOP STD&NAM99498-2上IBOP修理包REPAIR KIT,UPPER IBOP,P

10、H-50 STD AND NAM114859密封修理包SOFT SEAL114859-1密封修理包(GLAND POCKETS)SOFT SEALS(GLAND POCKETS)99498-1平衡系统储能器密封包SEALS, ACCUM, 630124575后扶正环STABILIZER ASSY,REAR118367前扶正环STABILIZER ASSY,FRONT118368喇叭口扶正块挡板RETAINER764456寸滚轮CAM,FOLLOWER 6301554384寸滚轮BEARING, CAM FOLLOWER30158767-04钳牙PYRAMID,TONG,DIE(TYPECRO

11、TARY-TONG)16401-2IBOP执行器2寸滚轮CAM FOLLOWER71847黄油嘴FITTING, GREASESTRAIGHT EXTENDED53219-2旋转头下部止推环RING,THRUST,.125x7.75x10.030119357螺丝CAP - HEX HEAD50012-18-C5D螺丝HEX HEAD CAP50006-12-C5D螺丝CAP-HEX HEAD50010-52-C5D主轴上端盖调整垫片(MT)TDS9S SHIM,BRG RETAIN.002109586-1主轴上端盖调整垫片(MT)TDS9S SHIM,BRG RETAIN.003109586-

12、2主轴上端盖调整垫片(MT)TDS9S SHIM,BRG RETAIN.005109586-3主轴上端盖调整垫片(MT)TDS9S SHIM,BRG RETAIN.010109586-4主轴上端盖调整垫片(MT)TDS9S SHIM,BRG RETAIN.031109586-5安全绳.051 DIAZ60001压力开关PHM3I SW,PRESS UL/CSA83095-1压力开关OIL87542-1压力开关TDS-3 SWITCH PRESSURE EEX76841拉拔器SEAT PULLER79489-143位电磁阀SOLENOID VALVE, 3-POS, 24VDC127908-J2

13、2位电磁阀SOLENOID VALVE, 2-POS, 25VDC127908-D2快拔接头QD, 3/4 MALE NPT55912-12-12主逆变模块总成ACS800-104-0580-7+C126+E205+V99168685745浪涌抑制器FILTER, LINE, 20A, 120V AC0000-9642-66预充电整流桥BRIDGE RECTIFIER0000-9605-33电压监测板PCA-VOLTAGE FEEDBACK CIRCUIT BOARD0509-3000-00编码器滚轮(MT)PULLEY,ADAPTER120119-1编码器滚轮(MT)PULLEY,ENCOD

14、ER120119-224V电源PWR SUPPLY,CLASS1,DIV 2,24-28V,SOH=0, SEE TXT0000-9645-86(0000-9642-00)区域总线模块MDL,FIELDBUS COUPLER, 12 MBAUD40943311-061熔断器FUSE, 2A, 250V AC, FAST BLOW0000-9641-46控制变压器TRANSFORMER-50VA, 600:26.5V,CPT,1PH,50HZ, 1003-0095-00编码器皮带(MT)BELT,TIMING120117编码器ASSY,ENCODER,DIGITALM614003119电机轴密封

15、SEAL,POLYPAK,3.875,STD.BORE,TDS98291+30转速表METER, 5 I.S., 250 RPMPR21VP-307扭矩表METER,5, ERT,80K FT-LB,TDS 10GHT102A-000624刹车制动单元风机FAN-115VAC, 1 PH, 50/60 HZP250000-9679-45控制电缆CABLE,ASSEMBLY, 42 COND.122517-200-25-3-B辅助动力电缆CABLE ASSEMBLY,SOH=0, USE 30183959-200-25-4-B124457-200-25-4-B小逆变器INVERTER- 18.5

16、 KW,690V,22A,AIR0000-9671-61小逆变器INVERTER-55KW,690V,57A CONTINUOUS, 84A, P250000-9686-37司控台通讯电缆短节ASSY,PIGTAIL,PROFIBUS,7-PIN-CONN(ATEX)30181908-9司控台通讯电缆CABLE ASSY, PROFIBUS30181756-100-B液压油滤子ELEMENT,FILTER,HYD30173216-1齿轮油滤子KIT, FILTER, GEAR OIL30111013-KIT液压泵总成PUMP/MOTOR ASSY (UL-DIV I) SOH=0 USE 11

17、4113-4114113钳头固定螺栓SCREW,CAP-SOC HD50108-14-C冲管总成扳手WRENCH,3 BORE,WASH PIPE ASSY30150084液压缸拆卸工具WRENCH,SPANNER108894-Z677液压缸拆卸工具WRENCH,GLAND108894-Y4保护接头牡丹江长城油气钻采工具有限公司 631*41110000709598（物资编码）SBC柜cpuSBC-CONTROLLOR ASSYP250000-9688-27P-BUS数据处理器CARD APPLICOM,DP1P800000-9686-67斩波模块CHOPPER0000-9646-98整流二极

18、管DIODE-ASSY,DUAL 1800V,AIRCOOL0000-9641-88断路器CB-16AT,1P,230V,SMISSLINE0000-9668-89开关模块SW-CONTACT BLK SW MODULE0000-9652-59绿色按钮灯PUSHBUTTON, ILLUMINATED, GREENP250000-9900-29单价现存数量总价出库时间价格来源$128.004$512.00VARCO配件询价总表$333.001 $333.00VARCO配件询价总表$252.004 $1,008.00VARCO配件询价总表$1,826.004 $7,304.00VARCO配件询价总

19、表$49.101 $49.10VARCO配件询价总表$6.011 $6.01VARCO配件询价总表$53.601 $53.60VARCO配件询价总表$45.001 $45.00VARCO配件询价总表$220.002 $440.00VARCO配件询价总表$223.002 $446.00VARCO配件询价总表$176.0020 $3,520.00VARCO配件询价总表$45.002 $90.00VARCO配件询价总表$170.001 $170.00VARCO配件询价总表$16.704 $66.80VARCO配件询价总表$8.962 $17.92VARCO配件询价总表$8.612 $17.22VAR

20、CO配件询价总表$11.811 $11.81VARCO配件询价总表$16.001 $16.00VARCO配件询价总表$9.642 $19.28VARCO配件询价总表$7.212 $14.42VARCO配件询价总表$3.2512 $39.00VARCO配件询价总表$7.102 $14.20VARCO配件询价总表$2.955 $14.75VARCO配件询价总表$2.952 $5.90VARCO配件询价总表$5.053 $15.15VARCO配件询价总表$9.623 $28.86VARCO配件询价总表$30.601 $30.60VARCO配件询价总表$36.101 $36.10VARCO配件询价总表

21、$52.001 $52.00VARCO配件询价总表$41.801 $41.80VARCO配件询价总表$40.501 $40.50VARCO配件询价总表$88.961 $88.96VARCO配件询价总表$88.351 $88.35VARCO配件询价总表$41.601 $41.60VARCO配件询价总表$421.001 $421.00VARCO配件询价总表$138.001 $138.00VARCO配件询价总表$95.101 $95.10VARCO配件询价总表$244.001 $244.00VARCO配件询价总表$74.401 $74.40VARCO配件询价总表$65.601 $65.60VARCO

22、配件询价总表$37.201 $37.20VARCO配件询价总表$50.301 $50.30VARCO配件询价总表$164.001 $164.00VARCO配件询价总表$6,143.001 $6,143.00VARCO配件询价总表$3,923.001 $3,923.00VARCO配件询价总表$3.621 $3.62VARCO配件询价总表$698.002 $1,396.00VARCO配件询价总表$7.212 $14.42VARCO配件询价总表$303.001 $303.00VARCO配件询价总表$1.325 $6.60VARCO配件询价总表$151.002 $302.00VARCO配件询价总表$1

23、,826.001 $1,826.00VARCO配件询价总表$90.008 $720.00VARCO配件询价总表$47.908 $383.20VARCO配件询价总表$66.008 $528.00VARCO配件询价总表$4,405.001 $4,405.00VARCO配件询价总表115301 $11,530.00VARCO配件询价总表$1.325 $6.60VARCO配件询价总表32703.481 $32,703.48VARCO配件询价总表$4,711.002 $9,422.00VARCO配件询价总表$1,312.001 $1,312.00VARCO配件询价总表$112.001 $112.00VA

24、RCO配件询价总表$1,760.001 $1,760.00VARCO配件询价总表$61.101 $61.10VARCO配件询价总表3377$2,359.002014/9/8更换一个VARCO配件询价总表2014/4/21更换一个VARCO配件询价总表22333 $7,359.002014/9/8更换一套VARCO配件询价总表2014/4/21更换一套VARCO配件询价总表$7,291.002 $14,582.00VARCO配件询价总表$283.008 $2,264.00VARCO配件询价总表$1,913.002 $3,826.00VARCO配件询价总表$38.307 $268.10VARCO配

25、件询价总表$274.002 $548.00VARCO配件询价总表$15.106 $90.60VARCO配件询价总表176752 $35,350.00VARCO配件询价总表110202 $22,040.00VARCO配件询价总表$495.004 $1,980.00VARCO配件询价总表$4,925.002 $9,850.00VARCO配件询价总表$5,793.002 $11,586.00VARCO配件询价总表$298.001 $298.00VARCO配件询价总表$24.401 $24.40VARCO配件询价总表$421.002 $842.00VARCO配件询价总表$1,247.001 $1,24

26、7.00VARCO配件询价总表$1,410.001 $1,410.00VARCO配件询价总表$532.001 $532.00VARCO配件询价总表$1,870.002 $3,740.00VARCO配件询价总表$950.004 $3,800.00VARCO配件询价总表$12.80132 $1,689.60VARCO配件询价总表$69.304 $277.20VARCO配件询价总表$2.8410 $28.40VARCO配件询价总表$222.001 $222.00VARCO配件询价总表$3.3910 $33.90VARCO配件询价总表$3.502 $7.00VARCO配件询价总表$7.382 $14.

27、76VARCO配件询价总表$92.601 $92.60VARCO配件询价总表$52.801 $52.80VARCO配件询价总表$108.001 $108.00VARCO配件询价总表$113.001 $113.00VARCO配件询价总表$213.001 $213.00VARCO配件询价总表$30.802 $61.60VARCO配件询价总表$624.002 $1,248.00VARCO配件询价总表$798.002 $1,596.00VARCO配件询价总表$820.003 $2,460.00VARCO配件询价总表$2,331.002 $4,662.00VARCO配件询价总表$1,602.001 $1,602.00VARCO配件询价总表$880.001 $880.00VARCO配件询价总表$59.701 $59.70VARCO配件询价总表440001 $44,000.00NOV报价单$513.871 $513.87NOV报价单$854.931 $854.93NOV报价单$597.542 $1,195.08NOV报价单$99.192 $198.38NO