布袋除尘器选型计算表(修订一)

长袋低压脉冲布袋除尘器选型计算表,,,,,,,,,,,,,,,,,,,,,,,,,,,,,,

处理风量Q(M3/h),滤袋规格Φ(m),滤袋长度L(M),初设风速M/min,初定面积㎡,初定袋数,初定室数,选取室数,实际袋数,实际面积㎡,实际风速M/min,一箱脉冲阀数,每阀袋数,脉冲阀总数,花板孔数,上箱宽度㎜,上箱长度㎜,卸灰阀尺寸,灰斗高度,中箱高度,箱体排列,停风阀数,停风阀Φ(M),单排箱数,单排仓数,停1仓风速M/min,除尘器总长(M),除尘器宽(M),单位重量T/M2,预估重量T,

282727,0.16,7,1,4712,1340,10,12,1536,5402,0.872,8,16,96,128,1930,4110,400,2866,7100,2,12,0.66,6,3,1.05,11.58,10.74,25,135,0.000161487

444000,0.16,7,1,7400,2104,11,12,2352,8272,0.895,14,14,168,196,3190,3690,400,5049,7100,2,12,1.04,6,3,1.07,19.14,10.66,25,207,

17800,0.13,1.9,1,297,383,6,5,320,248,1.195,8,8,40,64,1690,2190,400,2451,2000,5,5,0.10,1,1,#DIV/0!,1.69,14.45,32,8,

13390,0.13,2.8,1,223,195,2,2,162,185,1.205,9,9,18,81,1870,2370,400,2763,2900,1,2,0.19,2,1,2.41,3.74,3.16,32,6,

33400,0.13,4,1,557,341,5,4,288,470,1.184,8,9,32,72,1690,2370,400,2451,4100,1,4,0.23,4,2,1.58,6.76,3.20,32,15,

11160,0.13,2.6,1,186,175,2,2,144,153,1.217,8,9,16,72,1690,2370,400,2451,2700,1,2,0.16,2,1,2.43,3.38,3.13,32,5,

10473,0.13,2.6,1,175,164,2,2,144,153,1.142,8,9,16,72,1690,2370,400,2451,2700,1,2,0.15,2,1,2.28,3.38,3.12,32,5,

5760,0.13,2,1,96,118,1,1,117,96,1.005,9,13,9,117,1870,3090,400,2763,2100,1,1,0.16,1,1,#DIV/0!,1.87,3.85,32,3,

6700,0.13,2,1,112,137,1,1,156,127,0.877,12,13,12,156,2410,3090,400,3698,2100,1,1,0.19,1,1,#DIV/0!,2.41,3.88,25,3,

221137,0.16,5,1,3686,1467,9,10,1680,4220,0.873,12,14,120,168,2770,3690,400,4321,5100,2,10,0.62,5,3,1.09,13.85,9.82,32,135,

37166,0.16,4,1,619,308,2,2,336,675,0.917,12,14,24,168,2770,3690,400,4321,4100,1,2,0.52,2,1,1.83,5.54,4.81,32,22,

148665,0.16,5,1,2478,986,6,6,1008,2532,0.979,12,14,72,168,2770,3690,400,4321,5100,1,6,0.70,6,3,1.17,16.62,4.99,32,81,

,,,,,,,,,,,,,,,,,,,,,,,,,,,,,,,

,,,,,,,,,,,,,,,,,,,,,,,,,,,,,,,

,,,,,,,,,,,,,,,,,,,,,,,,,,,,,,,

"说明:黄色需填/兰色根据红色调节/绿色根据下表选取(尽量选双数)/初定风速也可进行适当调(注意事项:Φ130布袋每脉冲阀最多20条布袋,Φ160布袋每脉冲阀最多16条布袋;即每脉冲阀一般不超过喷吹50M2,最多不超过60M2,布袋长度不宜超过8M,以7.5以下为好.停风阀的过滤风速最好小于15M/S,一般选取12M/S为好)",,,,,,,,,,,,,,,"说明1)上栏高度\长度\宽度等为近以值，可做为选型及实际设计的参考值。2）单位重量一般风量在50万以内选取25左右,风量在50万以上选取20左右,风量小选大值,风量大选小值.3）室数选取原则：小风量的除尘器一般风速在1~1.25之间，选取室数可以小于初定室数，大风量（40万及以上）风速最好在1以下，选取室数最好大于初定室数，如想上箱体单排排列，室数单双数都可以，2排、4排排列需被2、4整除。4）单排仓数及灰仓高度是按一仓2室设定的，如实际需要一仓4室（大灰仓）灰仓高度与本表有较大出入。",,,,,,,,,,,,,,,

花板孔数,每脉冲阀多少袋数,,,,,,,,,,,,,,,,,,,,,,,,,,,,,

脉冲阀数,8,9,10,11,12,13,14,15,16,17,18,19,,20,,,,,,,,,,,,,,,,

8,64,72,80,88,96,104,112,120,128,136,144,152,,160,,,,,,,,,,,,,,,,

9,72,81,90,99,108,117,126,135,144,153,162,171,,180,,,,,,,,,,,,,,,,

10,80,90,100,110,120,130,140,150,160,170,180,190,,200,,,,,,,,,,,,,,,,

11,88,99,110,121,132,143,154,165,176,187,198,209,,220,,,,,,,,,,,,,,,,

12,96,108,120,132,144,156,168,180,192,204,216,228,,240,,,,,,,,,,,,,,,,

13,104,117,130,143,156,169,182,195,208,221,234,247,,260,,,,,,,,,,,,,,,,

14,112,126,140,154,168,182,196,210,224,238,252,266,,280,,,,,,,,,,,,,,,,

15,120,135,150,165,180,195,210,225,2