GQZ球型支座设计参数表

载桥梁球型支座设计参数表设计承载力：1000~60000kN(执行标准GB/T17955-2009)载载目录名称GQZ-SX球型支座主要设计参数表(表-1)GQZ-DX球型支座主要设计参数表(表-2)GQZ-GD球型支座主要设计参数表(表-3)3载载载精品说明一、本GQZ系列《桥梁球型支座设计参数表》系与国标《桥梁球型支座》GB/T17955-2009配套产品，本参数表供生产厂家发布GQZ系列产品信息使用，人员选型。载2、支座设计转角θ分为0.02、0.03、0.04、0.05、0.06rad五级。3、支座设计位移量：123123123载说明中交公路规划设计院有限公司名称载横向位移：SX(双向活动支座)，1000~9000kN，e=±20mm，10000~60000kN，e=±40mmDX(单向活动支座)e=±3mm。支座纵向、横向位移量还可根据实际需要进行调整。4、支座可承受的水平力：单向活动支座(DX)及固定支座(GD)在非滑移方向的水平力均不小于支座设计承载力的10%。1、采用本系列支座时，安装支座的垫石混凝土强度等级不得低于C40级。2、安装支座处应设置支座垫石，垫石尺寸应按局部承压计算，其长度、宽度比支座底板尺寸大100mm以上，高度不小于100mm，且应布置钢筋。并按支座底板地脚螺栓间距与底柱规格预留螺栓孔位置。若采用预埋钢板焊接连接时，支座就位后，用对称断续方式焊接，焊接过程中应防止支座钢体温度过高，防止变形、烧坏聚四氟乙烯板等。3、支座安装标高应符合设计要求。控制垫石顶面标高时要注意预留支座底板下专用砂浆垫层厚度。支座支承面四角高差不得大于1mm。4、支座安装前方可开箱，并检查支座各部件及配件清单。支座安装前不允许随意拆卸固定件。载5、支座安装的注意事项：1)支座安装位置划出中心十字，支座顺桥方向的中心线应与主梁顺桥向中心线平行。2)活动支座的上顶板与下底盆顺桥方向的中心线应重合。3)支座安装过程中，不得松开上顶板与下底盆的连接固定板，以防止发生过大的转角而倾覆。待支座安装完成后再拆除连接板，以防约束梁体的正常位移4)检查不锈钢板外露面是否清洁，在运输、储存、安装过程中涂装是否碰掉，发现问题应及时清洁及补刷涂装，然后安装防尘设施。6、支座安装还应满足现行桥梁施工规范的相关规定。支座使用期间，应按养护规范的有关规定定期进行检查及养护。载说明中交公路规划设计院有限公司名称2载载载中交公路规划设计院有限公司名称GQZ-SX球型支座组装示意图图号3载表-1(一)GQZ系列桥梁球型支座(SX)双向活动支座主要尺寸(mm)序项目号规格GQZ-1500Z4GQZ-2500GQZ00GQZ0QZGQZ-5000E1E2E3E12E2E3E13E2E3E1A4E2E3E1———————————————05E2———————————————E3———————————————E1———————————————6E2———————————————E3———————————————载中交公路规划设计院有限公司名称GQZ-SX球型支座主要尺寸表图号4载续表-1(一)GQZ系列桥梁球型支座(SX)双向活动支座主要尺寸(mm)序项目号规格GQZ000GQZ500GQZ0000GQZ2500GQZ5000GQZ7500GQZ0GQZ0GQZ50000GQZ55000QZE1±±±±±±±±±±±±±±±200E2±±±±±±±±±±±±±±±250E3E1200280440540550650710780820870204021202210228023602E2E3E13E2E3E1A4E2E3E105E2E3E16E2E3载中交公路规划设计院有限公司名称GQZ-SX球型支座主要尺寸表图号5载表-1(二)GQZ系列桥梁球型支座(SX)双向活动支座主要尺寸(mm)序项目号规格GQZ0GQZ-2500QZGQZ00横向位移e±±±±±±±±±±±±±±23B045———————————————6———————————————E12E2E3E13E2E3A1E104E20E3θ=0.05θ=0.0612312EE12312——————————————————————————————————————————————————————————————————————————————————————————载中交公路规划设计院有限公司名称GQZ-SX球型支座主要尺寸表图号6载续表-1(二)GQZ系列桥梁球型支座(SX)双向活动支座主要尺寸(mm)序项目号规格1GQZ-1500601GQZ-1750701GQZ-2000801GQZ-2250902GQZ-2500002GQZ-2750102GQZ-3000202GQZ-3250302GQZ-3500402GQZ-3750502GQZ-4000602GQZ-4500702GQZ-5000802GQZ-5500903GQZ-600000横向位移e4±4±4±4±4±4±4±4±4±4±4±4±4±4±4θ=0.02θ=0.03Bθ=0.04θ=0.05θ=0.06E10116000000000000002E2012600000000000000E3013600000000000000E10121000000000000003E2013100000000000000E3014100000000000000E1012700000000000000A14E2013700000000000000E3014700000000000000E10133000000000000005E2014300000000000000E3015300000000000000E10139000000000000006E2014900000000000000E3015900000000000000载中交公路规划设计院有限公司名称GQZ-SX球型支座主要尺寸表图号7载表-1(三)GQZ系列桥梁球型支座(SX)双向活动支座主要尺寸(mm)序项目号规格GQZ15004GQZ-2500GQZ0GQZQZGQZ-500023B104005———————————————6———————————————20003004005———————————————6———————————————200030000CD4005———————————————6———————————————载中交公路规划设计院有限公司名称GQZ-SX球型支座主要尺寸表图号8载续表-1(三)GQZ系列桥梁球型支座(SX)双向活动支座主要尺寸(mm)序项目号规格GQZ000GQZ500GQZ0000GQZ2500GQZ5000GQZ7500GQZ0GQZ0GQZ50000GQZ55000QZ23B1045620345623CD456载中交公路规划设计院有限公司名称GQZ-SX球型支座主要尺寸表图号9载表-1(四)GQZ系列桥梁球型支座(SX)双向活动支座主要尺寸(mm)序项目号规格1GQZ-10002GQZ-15003GQZ-20004GQZ-25005GQZ-30006GQZ-35007GQZ-40008GQZ-45009GQZ-500010GQZ-600011GQZ-700012GQZ-800013GQZ-900014GQZ-1000015GQZ-12500θ=0.02θ=0.03Hθ=0.04θ=0.05———————————————θ=0.06———————————————地脚螺栓底柱φ42×252φ42×252φ42×252φ42×252φ46×260φ46×260φ46×260φ46×260φ58×300φ58×300φ58×300φ70×352φ70×352φ70×352φ80×352E166489214.0254.6298.2405.2480.30651.2767.438.4θ=0.02E2016202.9226.8269.03.5423.472677.1797.274.0E32584215.0239.7283.48.5441.724703.0827.009.6E1187212.1238.7282.28.1442.93623.5734.7839.348.6θ=0.03E2182224.7252.37.14.1462.09648.1762.1870.586.0总重量(㎏)θ=0.04E1EE1E34E392—2—56—56—075075—497497—62209.162209.1—237.4249.5236.2237.4249.5236.2—266.0293.4264.8266.0293.4264.8—2.27.02.62.27.02.6—3.16.59.83.16.59.8—00494.000494.0—38638.038638.0—727.6753.6672.7—727.6753.6672.7—850.3879.3789.5850.3879.3789.5—966.5999.2933.8966.5999.2933.8—23.470.809.923.470.809.9—θ=0.05E2———————————————E3———————————————E1———————————————θ=0.06E2———————————————E3———————————————载中交公路规划设计院有限公司名称GQZ-SX球型支座主要尺寸表图号10载续表-1(四)GQZ系列桥梁球型支座(SX)双向活动支座主要尺寸(mm)序项目号规格16GQZ-1500017GQZ-1750018GQZ-2000019GQZ-2250020GQZ-2500021GQZ-2750022GQZ-3000023GQZ-3250024GQZ-3500025GQZ-3750026GQZ-4000027GQZ-4500028GQZ-5000029GQZ-5500030GQZ-60000=0.02=0.03H=0.0405 (206)=0.0500 (201)09 (210)=0.0604 (205)14 (215)400地脚螺栓底柱φ80×352φ90×400φ90×400φ90×400φ100×400φ100×400φ100×400φ110×460φ110×460φ110×460φ120×480φ120×480φ124×520φ124×520φ128×560E103.881.742.42371.02553.43084.23516.73936.54369.74897.8629.56709.87833.08846.910132.6θ=0.02E243.726.293.12427.92612.83150.33587.94011.34451.74988.3727.96819.87953.08976.010273.4E383.570.82043.82484.82672.23216.53659.14086.14533.6078.9826.36929.78073.09105.110414.1E157.926.52145.52593.52920.43339.13809.04241.54729.1315.06022.47125.38385.99509.310806.2θ=0.03E299.972.92198.52652.93014.23407.93882.14328.64814.2409.46124.37239.18510.49643.110951.8总重量(㎏)E341.819.42251.82712.33078.13476.83956.24416.24899.3503.86226.17352.78635.09776.811097.3E188.803.22384.82880.03270.03702.04175.24648.6199.3774.06488.77781.69057.310354.011759.1θ=0.04E232.552.02440.52942.43336.93774.24252.64730.0288.3872.36595.17900.29186.910493.611910.9E376.351.32496.23004.73403.83846.34329.94811.3377.1970.66701.58018.99316.410633.312067.3E103.82128.12643.83149.43619.04043.14633.9122.1688.06350.87272.18535.79951.611809.812931.9θ=0.05E231.92179.22702.33214.53689.14118.64715.2207.5780.56453.47383.68659.910086.811955.413090.7E391.42245.52760.83279.13759.14193.94796.5293.0873.16556.07495.28784.010223.112101.113247.4E146.62347.02895.63480.43947.24493.1049.9604.16238.17038.37899.89417.710905.012334.614130.3θ=0.06E294.42415.92956.73548.54020.24572.1134.5693.16334.87145.98016.09547.311046.012486.214295.944111载中交公路规划设计院有限公司名称GQZ-SX球型支座主要尺寸表图号11载载载中交公路规划设计院有限公司名称GQZ-DX球型支座组装示意图图号12载表-2(一)GQZ系列桥梁球型支座(DX)单向活动支座主要尺寸(mm)序项目号规格GQZ-1500Z4GQZ-2500GQZ00GQZ0QZGQZ-5000E1E2±±±±±±±±±±±±±±±E3E1002E2E3E1003E2E3E10A4E2E3E1———————————————05E2———————————————E3———————————————E1———————————————6E2———————————————E3———————————————载中交公路规划设计院有限公司名称GQZ-DX球型支座主要尺寸表图号13载序项目号规格GQZ000GQZ500GQZ0000GQZ2500GQZ5000GQZ7500GQZ0GQZ0GQZ50000GQZ55000QZ续表-2(一)EEE123±200±250±300E1120012801440154015501650171017801820187020402120221022802360GQZ系列桥梁球型支座(DX)单向活动支座主要尺寸(mm)2E22460E32560E124303E22530E32630E12520A4E22620E32720E1262005E22720E32820E142051069080086093099020602120235024402540262027206E2E3载中交公路规划设计院有限公司名称GQZ-DX球型支座主要尺寸表图号14载表-2(二)GQZ系列桥梁球型支座(DX)单向活动支座主要尺寸(mm)序项目号规格GQZ0GQZ-2500QZGQZ00横向位移3±3±3±3±3±3±3±3±3±3±3±3±3±3±323B045———————————————6———————————————E12E2E3E13E2E3A1E104E2E3θ=0.05θ=0.0612312EE12312——————————————————————————————————————————————————————————————————————————————————————————载中交公路规划设计院有限公司名称GQZ-DX球型支座主要尺寸表图号15载续表-2(二)GQZ系列桥梁球型支座(DX)单向活动支座主要尺寸(mm)序项目号规格1GQZ-1500601GQZ-1750701GQZ-2000801GQZ-2250902GQZ-2500002GQZ-2750102GQZ-3000202GQZ-3250302GQZ-3500402GQZ-3750502GQZ-4000602GQZ-4500702GQZ-5000802GQZ-5500903GQZ-600000横向位移3±3±3±3±3±3±3±3±3±3±3±3±3±3±3θ=0.02θ=0.03Bθ=0.04θ=0.05θ=0.06E10116000000000000002E2012600000000000000E3013600000000000000E10121000000000000003E2013100000000000000E3014100000000000000E1012700000000000000A14E2013700000000000000E3014700000000000000E10133000000000000005E2014300000000000000E3015300000000000000E10139000000000000006E2014900000000000000E3015900000000000000载中交公路规划设计院有限公司名GQZ-DX球型支座主要尺寸表图号16称载表-2(三)GQZ系列桥梁球型支座(DX)单向活动支座主要尺寸(mm)序号1234567891011121314150000000000000θ=0.02643647636466646θ=0.0364364661676966696B1θ=0.0440646649656661646θ=0.05θ=0.06θ=0.02440470104090010θ=0.034204600050900060θ=0.0443049040900020θ=0.05θ=0.06E1260/220310/270350/300400440460000300θ=0.02E2260/220310/270350/300380/350400/360440460500/440300E3260/220310/270350/300380/350400/360440/400460/410500/450500/440580/520620/560300E1280/240320/280380/33040043047049040700θ=0.03E2280/24320/28380/33400/37430/39047049040700E3280/240320/280380/330400/370430/390470/430490/440530/480530/470610/5500074077050E1290/250340/300390/340430460004090000θ=0.04E2290/250340/300390/340430/400460/420004090000E3290/250340/300390/340430/400460/420500/460520/470560/500004090000θ=0.05E~E13θ=0.06E~E13载中交公路规划设计院有限公司名称GQZ-DX球型支座主要尺寸表图号17载续表-2(三)GQZ系列桥梁球型支座(DX)单向活动支座主要尺寸(mm)序项目号规格GQZ000GQZ500GQZ0000GQZ2500GQZ5000GQZ7500GQZ0GQZ0GQZ50000GQZ55000QZ23B1045620345623CD456载中交公路规划设计院有限公司名称GQZ-DX球型支座主要尺寸表图号18载表-2(四)GQZ系列桥梁球型支座(DX)单向活动支座主要尺寸(mm)序项目号规格1GQZ-10002GQZ-15003GQZ-20004GQZ-25005GQZ-30006GQZ-35007GQZ-40008GQZ-45009GQZ-500010GQZ-600011GQZ-700012GQZ-800013GQZ-900014GQZ-1000015GQZ-12500θ=0.02θ=0.03Hθ=0.04θ=0.05———————————————θ=0.06———————————————地脚螺栓底柱φ42×252φ42×252φ42×252φ42×252φ46×260φ46×260φ46×260φ46×260φ58×300φ58×300φ58×300φ70×352φ70×352φ70×352φ80×352E1.45.5206.6233.2274.77.4447.91602.1714.0827.0.3θ=0.02E271.14.4226.0255.3297.6412.2478.78640.3757.2873.9.9E378.9205.3245.5278.33.4440.20606.7678.3800.9919.8.6E170.60.3227.9258.42.5412.1486.30677.4798.7899.8.0总重量(㎏)θ=0.03E278.79.4212.3248.0281.36.3444.70622.0717.3843.8948.3.7E36.8227.8269.16.14.0478.58659.5757.0889.3995.8.4E174.89.0212.7252.2284.61.9448.24644.8756.3886.4994.9.8θ=0.04E23.0231.6273.08.46.5482.05682.3797.9933.2E31.3204.0251.3295.85.21.72605.0721.3839.3980.6.7.8E1———————————————θ=0.05E2———————————————E3———————————————E1———————————————θ=0.06E2———————————————E3———————————————载中交公路规划设计院有限公司名称GQZ-DX球型支座主要尺寸表图号19载续表-2(四)GQZ系列桥梁球型支座(DX)单向活动支座主要尺寸(mm)序号GQZ-15000GQZ-17500GQZ-20000GQZ-22500GQZ-25000GQZ-27500GQZ-30000GQZ-32500GQZ-35000GQZ-37500GQZ-40000GQZ-45000GQZ-50000GQZ-55000GQZ-60000θ=0.02142132435567778697θ=0.03011623364558707989Hθ=0.0405 (206)2127415162748693θ=0.0500 201)9 (210)24324754688191θ=0.0604 (205)4 (215)9801366400地脚螺栓底柱φφφφφφφφφφφφφφφE11401.51693.22094.72561.92750.13304.73779.34351.44753.35244.06080.97250.38425.69529.010827.2θ=0.02E21466.01768.12176.92655.82847.53412.73898.14481.34885.25385.96245.47440.98632.79755.311059.1E31530.51841.02258.82749.92945.03520.84016.84611.55022.35533.56410.07631.28843.59985.511292.3E11558.41839.42300.12786.13152.03562.04074.34673.85135.85666.76480.27669.48984.410196.711510.1θ=0.03E21625.81916.62385.02883.03254.73673.34196.64807.45271.75813.26649.07863.99196.510427.911747.5总重量(㎏θ=0.04E31693.31991.82469.82980.03357.33784.54318.94941.45412.95965.46817.88058.09412.310662.911986.1E11708.22019.02542.63075.93476.93931.24446.85082.05619.06132.56954.38337.49661.911052.12475.1E21778.22099.32631.03176.73583.84047.14573.45220.25760.56283.97128.78538.49879.511290.12720.0)E31848.22188.42719.23277.63690.74163.14699.95358.65907.16441.07303.28739.010100.911531.912966.1E11891.32246.92803.13350.33831.34275.84912.85552.06137.76722.57749.89104.310575.612526.713670.4θ=0.05E21964.22340.82894.93454.83942.64395.65044.75695.56284.66880.77931.09312.310801.512773.013925.0E32037.22422.92986.53559.34054.04515.45176.45839.26436.67044.78112.49519.911031.213023.314180.8E12054.42469.33058.63686.34162.04733.55333.96063.76699.17416.68387.110007.811548.313072.514888.0θ=0.06E22130.02566.93153.93795.14277.14858.75470.36212.46851.47581.18574.310190.211782.913327.515151.9E32215.92652.33248.93904.14392.24983.95606.56361.46008.97751.28761.610440.912021.213586.615417.1载中交公路规划设计院有限公司名称GQZ-DX球型支座主要尺寸表图号20载载载中交公路规划设计院有限公司名称GQZ-GD球型支座组装示意图图号21载序项目号规格GQZ0GQZ-2500QZGQZ00表-3(一)A＝B＝(φ3)θθθθ————————————————————————————GQZ系列桥梁球型支座(GD)固定支座主要尺寸(mm)θ———————————————θ930θ9801θ0C＝D=(φ1)θθθθθθθθθ=0.05=0.06=0.02=0.03=0.04=0.05=0.06=0.02=0.03——300320330——240260——350360380——290300——390420430——330360——440460490——380400——470500530——400430——510540570——440470——530560590——460490——570600630——500530——590620650——500530——670700740——580610——710750790——620660——740790840——640690——790840890——690740——830870920——730770——9109601010——800850θθ———————————————θ———————————————载中交公路规划设计院有限公司名称GQZ-GD球型支座主要尺寸表图号22载续表-3(一)GQZ系列桥梁球型支座(GD)固定支座主要尺寸(mm)序项目号规格GQZGQZGQZ0GQZ0GQZ0GQZ0GQZ00GQZ00A＝B＝(φ3)θθθθθθθ=0.02=0.03=0.04=0.05=0.06=0.02=0.031113117412271290134310001060120312551317138014431080113012631325138714601524114012001383144515181581165512601320139314951568164117151260136015031565163817111796137014301563162616991783185614301490164417061779185319371500156016841756182919131998154016101744181618891974206816001670182418861970206421481670173019241987207021642259177018302014208721702265236018501920210421772271236524611940201021852258235124562562201020801θC＝D=(φ1)θθθθθθ