CACT消防安全作业规范培训

1、Fire Prevention and Protection SWPP Training CACT 消防安全作业规范培训 This SWPP Covers Two Aspects:How to prevent a fire from occurring.What protections are in place to control a fire.本作业规范讲了以下两个方面内容:1. 如何预防火灾.2. 火灾的监测和控制.General Fire Prevention Practices 预防火灾 的一般要求 Smoking 吸 烟 at Designated area 指定吸烟区 Gener

2、al Fire Prevention Practices 预防火灾 的一般要求 HousekeepingJunction / Switch Box Properly Closed接线盒 / 开关盒 拧紧螺丝, 封好 Flammable Leaks Clean Immediately 易燃品泄露 立即清理 Open Drains Maintain Water Seal地漏 保持水密封 General Fire Prevention Practices 预防火灾 的一般要求 Storage of Flammables易燃品的存放 SEALLABLE密封,标签,阴凉,通风Cool, shadedAw

3、ay From 远离Ignition Source火源Process生产设备Oxidizer氧化物Accommodation生活区Normal Operation日 常 作 业General Fire Prevention Practices 预防火灾 的一般要求 Storage of Explosive Materials爆炸品的存放 Be Stored on Quick-release Trays on Platform Edge存放在平台舷外紧急快速抛海架上General Fire Prevention Practices 预防火灾 的一般要求 Install / Replace Ele

4、ctrical Components安装 / 更换电器设备Check the electrical classification when install / replace electrical components.安装 / 更换电器设备时注意检查设备的电器安全级别是否满足安装区域对电器的安全级别的要求. UL Class 1, Division 1General Fire Prevention Practices 预防火灾 的一般要求 Non-explosive Electrical Devices非防爆电器 Not to be used in hazardous classified

5、areas or go through hot work procedure在有电器安全级别要求的区域使用须申领“热工作业许可证”General Fire Prevention Practices 预防火灾 的一般要求 Clothes Driers 洗衣房烘干机Clean Filter Daily 每日清洁过滤网Do Not Dry Oil-soaked Cloth / Mop 不要烘干油抹布 Clean Oil / Chemical on Coverall before Placing into Dry Machine 工衣上的油污/化学药剂洗干净后再烘干 Check the Lighter

6、s in Pocket 检查衣兜中的打火机 Remove Clothes from Drier when it Stops 烘干机 停止后立即取出衣物 General Fire Prevention Practices 预防火灾 的一般要求 Kitchen 厨 房Powered Stoves shall not be left unattended. 厨师不能在炉子通电 的情况下离开. Fire Prevention Through Operations 生产作业中如何防火 Taking Samples 取 样Control the Flow Standby the Shut off Valv

7、e. 取样时不要离开关断阀门.Prevent Accidental Release Plug All Open-end Connections or Sample Draws Used Less Than Once Per Week. 用堵头堵住所有接头的开口端及使用频率少于一周次的取样点.Prevent Static Electricity Metal Bucket, Bonded to Sample Connection. 防静电火花 用金属桶, 桶与取样点用导线连好.Fire Prevention Through Operations 生产作业中如何防火 Critical Process

8、 Equipment 关键生产设备Maintenance / Facility Group: Identify Critical Equipment 确定关键生产设备 Develop / Implement Inspection Program 制订/实施定期检查计划Fire Prevention Through Operations 生产作业中如何防火 Hot Surfaces 高温管线 / 设备 Rarely at Temperatures Sufficient to Ignite Flammable Mixture. 很少会达到能引燃燃气的温度. Many are Hot Enough

9、to Ignite Oil, Lint, Rags, Paper and even Wood. 很多足以引燃 油,抹布,纸甚至木材. Exposed surfaces in excess of 60C shall be insulated. 有可能接触到液体/固体可燃物,表面温度超过 60 C的管线/设备应加隔热层. Fire Prevention Through Operations 生产作业中如何防火 Pumps / Engines 泵 / 内燃机 Frequently Inspect Seal, Gland, Gasket leakage and General Cleanliness

10、of Pump. 日常检查泵的密封和清洁. Annually Inspect and Ensure No Damage due Vibration. 年度检查确保无振动引起的损坏. Check Motors for Overheating, Sparking, Switches, Overload Protection and Wiring. 马达应检查过热, 火花, 开关, 过载保护及接线. Exhaust on Combustible Engine No Contact by Lube Oil or other Combustible Materials. 内燃机尾气排放管不要接触润滑油或

11、其它可燃物.Fire Prevention Through Operations 生产作业中如何防火 Structures 结构 Structures Containing Pumps / Piping etc. may possibly Leak Flammables should be well Ventilated. 有可能造成泄露的泵,管线等生产设备所在区域应 保持良好通风. Any Enclosed Spaces (Platform Legs, Potable Water Tanks, Water / Air Systems) may Contain Explosive Mixtur

12、e, Gas Test must be Performed before Cutting / Welding on or next to Enclosed Spaces. 海上任何管线 / 罐内都有可能有燃气, 在任何管线 / 罐上热割或焊接都应先对内部进行燃气检测.Fire Prevention Through Operations 生产作业中如何防火 Safety Devices 安全保护装置 All Very Important for Fire Prevention. Inspection / Maintenance shall be Performed no less than On

13、ce Per Year. 对防火举足轻重, 检查/保养至少一年一次.PSV 压力安全阀Breather ValveRegulators减压阀Over speed Trips 过速关断ESD 紧急关断Fire Prevention Through Operations 生产作业中如何防火 Safety Devices 安全保护装置 PSV压力安全阀Lock or Seal上锁或铅封Open Position, 全开状态Fire Prevention Through Operations 生产作业中如何防火 Flares 火炬 Be careful,air may get into the far

14、e line and cause explosion! 不要让空气进入火炬管线!Fire Prevention Through Operations 生产作业中如何防火 Flares 火炬 Manual Lighting Flare is Prohibited严禁人工点火炬Fire Prevention Through Operations 生产作业中如何防火 Draining, Vapor Freeing, Purging Procedures 排空, 清汽, 惰性气体置换程序 Its Hard to Remember!太复杂,记不住!No Need to, Review when Perf

15、orm the Work.不必牢记,用着时再看.Fire Prevention Through Operations 生产作业中如何防火 Control Room, Switchgear Room & L/Q 控制房, 配电房和生活区 GAS燃气Positive Pressure正压Keep the Doors Closed to Maintain Positive Pressure!随手关门,保持室内正压!Fire Prevention Through Operations 生产作业中如何防火 Battery Room 电池房 UPSOXYGEN电池释放的氢气Battery Room 电池房

16、Oxygen is highly explosive, maintain well ventilation 氢气极易爆炸,确保电池房良好通风Fire Prevention Through Operations 生产作业中如何防火 Oil Soaked Insulation 被油浸泡过的隔热层 Auto-ignition can occur if the pipe / vessel is over 200C and the insulation is oil-soaked. Replace oilsoaked insulation, apply water when conduct this w

17、ork. 温度超过200 C的管线/容器会使沾了油的隔热层发生自燃. 应及时更换沾了油的隔热层. 更换时应洒水防火.Fire Prevention Through Operations 生产作业中如何防火 Heating Coils 加热丝 Submerged to Prevent Ignition 为防点火,加热丝不得露出液面Fire Prevention Through Maintenance 维修作业中如何防火 Portable Tools 手动工具 Hot work permit required when use at hazardous areas 如在有防爆等级要求的区域使用须申

18、请热工作业许可证Fire Prevention Through Maintenance 维修作业中如何防火 Fuse 保险丝 DO NOT: Replace when circuit is live Oversize Fuses Shorting out a Fuse不 要:带电换保险丝用大规格的保险丝将烧坏的保险丝裁 短使用Fire Prevention Through Maintenance 维修作业中如何防火 Repair to Fire Protection/Fire Fighting Equipment 消防设备的修理 - When repair alarm systems, alt

19、ernative back up protection shall be provided. 在修理报警系统期间要派人监测. - Without the Supervisors approval, fire water system shall not be taken out of service.没有监督批准, 不得 停掉消防水系统. Fire Prevention Through Maintenance 维修作业中如何防火 Repair to Fire Protection / Fire Fighting Equipment 消防设备的修理 - Repair to fire water

20、system shall be tracked daily and given the highest priority. 对消防水系统的修理应当做首要工作并每日 跟踪其进展. - Personnel (Fire Team) shall be notified when fire protection / fire fighting equipment is taken out of service / return service. 消防设备暂停使用/ 恢复使用应通知消防队. Fire Detection System 火灾探测系统 The following pages are the p

21、ictures of fire detectors, see if you know: What they are Where they are installed How they are operatedAsk Instrument Tech. if you have questions.后面几页是一些探测器的照片, 您是否知道它们:是什么安装在哪里怎样动作如有疑问请向仪表师请教Fire Detection System 火灾探测系统 Fire Detection System 火灾探测系统 Fire Detection System 火灾探测系统 Fire Detection Syste

22、m 火灾探测系统 Fire Detection System 火灾探测系统 Fire Detection System 火灾探测系统 Fire Detection System 火灾探测系统 Maintenance / Calibration 定期维护保养 / 校验CACT PM ProgramFire Detection System 火灾探测系统 Maintenance / Calibration 定期维护保养 / 校验Each facility is responsible for the calibration of the portable gas detectors on thei

23、r own facility. See section 11.9.3 of Fire Prevention / Protection SWPP.Fire Fighting Equipment 灭火设备 How to operate the following fire fighting equipment? 如何使用以下灭火设备? 1. Portable fire extinguishers ( dry powder, CO2, foam) 手提式干粉,泡沫,二氧化碳灭火器 2. Fire hoses in L/Q and on deck 生活区内及生产区的消防水带. 3. Fire Suppression System (CO2, FM-200) 二氧化碳及FM-200 自动灭火系统 Fire Fighting Equipment 灭火设备 How to operate the following fire fighting equipment? 如何使用以下灭火设备? 4. Wheeled fire extin