ZE型化工流程泵

1、ZE型化工流程泵概述ZE型化工流程离心泵，按照 API610和VDMA24297（轻/中型）规范 而设计、生产的产品。可输送各种温度和浓度的硫酸、硝酸、盐酸和 磷酸等无机酸和有机酸溶液；各种温度和浓度的氢氧化钠和碳酸钠等 碱性溶液；各种盐溶液；各种液态石油化工产品、有机化合物以及其 它有腐蚀性的液体。该型泵适用于炼油厂、石油化学工业煤加工工程、 低温工程、造 纸业、制糖业、供水厂、海水淡化厂、发电厂、环保 工程和船舶业等。从电动机端看，泵的旋转方向为顺时针方向旋转。 结构特点该类型的化工流程是采用的标准管路按API规范设计。叶轮可用闭式、半开式、开式三种。可输送清洁，含颗粒，含少量气体介质。也

2、 可输送高温、低温、强腐蚀介质。叶轮设有平衡孔加耐腐环，平衡轴 向力。泵体和轴承架用中间连接段连接。根据不同的工况条件，中间 连接段可采用不同的材质，避免输送强腐蚀介质时轴承架、轴承严重 腐蚀。同时中间连接段设有水冷腔，通冷却循环水，阻隔高温介质将 高温传到轴承上。密封形式可采用填料密封，单、双端面机械密封， 集装式单端面机械密封。根据不同情况和用户对冷却与冲洗要求，密封可按API682设计规范从案中选用。轴承架设计有空冷散热片、风 冷风扇、水冷腔三种形式，用户可根据使用工况选用。轴承由油环从 油箱里溅稀油润滑。油箱内的油由水冷腔的水冷却，轴承内的热由冷 水带走，以保证轴承随时处于正常工作状态

3、。根据介质温度和压力等情况，支撑形式采用中心支撑和脚架支撑。 吸入及排出法兰的额定压 力等级相同。型号说明例：ZE25-200CZE石油化工流程泵25吐出口直径（mm）200叶轮名义直径（mm）C 叶轮切割次数，顺序以A,B,C.表示性能范围（设计点）口径：25400mm流量：5.52600m3/h扬程：16250m工作压力：2.5MPa工作温度：-80 °C +450 °C可选择的耐腐蚀材料包括 303、305、306、307、316、316L、904、904L、804、ECR合金、NiCr合金、哈氏合金、CD-4MnCu及钛合金 等，能满足上述各种介质的要求。订货时，请

4、用户提供所要输送介质 的详细情况。三昌泵业ZE型化工流程泵入（Bit13, 14力理轴承怕、卡坏2.叶轮口坏B.辅希压前14, 口螺皆30.防唱甜3.叶*69x呱简車于耐藕15.档爾2R 丼ffttr仏棗豊10.加蛊16,軸币匝豊22. O矗蔓11u氟雅17, XH牡、亂盖耳B.宦封压弍a辂承爛悴1B,卡澤24. Dt«3ZE型化工流程泵结构图ZE型化 工流程 泵叶轮 形式流量杨程转速轴功率电机 功率电机型号效率必须汽蚀余量(NPSH)r叶轮名 义直径-m3/hmr/minKWKW%mmmZE25-200A11.54929504.15.5Y132S1-237 :1.8209B10.5

5、423.34Y112M-2361.6198C9362.53Y100L-2351.6180D7.5281.72.2Y90L-234 :1.6160ZE25-250A1670295010.511Y160M1-2292259B14.5629.411Y160M1-2262250C13.6426.87.5Y132S2-223 11.8235D11.3244.35.5Y132S1-2仃1.8210ZE25-315A2012829502430Y200L1-2291.8324B18.61162130Y200L1-228 :1.6315C17991722Y180M-2271.6300D15.78714.318.

6、5Y160L-2261.5285E14.57612.515Y160M2-224 :1.5270F136410.311Y160M1-2221.5250ZE40-160A283329504.15.5Y132S1-2623169B25.6293.35.5Y132S1-261 :2.5158C22222.34Y12M-2581.5140D20161.62.2Y90L-2551.5125 .ZE40-200A295329507.211Y160M1-2582.5209B26475.77.5Y132S2-2582198C22394.25.5Y132S1-2562180D1820 11.84Y112M-253

7、 :2.5160ZE40-250A3278295012.818.5Y160L-2532.5259B307211.115Y160M2-2532.5250C24607.711Y160M1-251 12225D21475.77.5Y132S2-2472200ZE40-315A42115295028.637Y200L2-2461.5324B4010725.930Y200L-245 11.3315C348117.922Y180M-2421.1285D29611215Y160M2-2401250ZE50-160A503429506.511Y160M1-2712.5169B4529 n57.5Y132S2-

8、271 :2158C38223.35.5Y132S1-2681.8140 'D31仃2.23Y100L-2651.5125ZE50-20 0A6252 n295012.918.5Y160L-2682.5209B564610.515Y160M2-2672.2198 'C49377.611Y160M1-2651.8185/175D43285.57.5Y132S2-2601.8170/150ZE50-25A7082 n29502430Y180L1-2652.5259B667521.130Y180L1-2642.2250 '0C606015.822Y180M-2622230 .

9、D504510.215Y160M2-260 :1.7200ZE50-31A87115295048.755Y250M-2562.53245B8010039.645Y225M-2552315C7078 127.537Y200L2-254 :1.6280D575717.722Y180M-2501.4250ZE50-40 0A82194295090.32.2Y315S-2482.2409B78175 179.12Y280M-247 ：2397C70140581.8Y280S-2461.8360D6010238.81.6Y225M-2431.6320ZE80-16 0A9432 1295010.53Y1

10、60M2-278 13169B85288.42.7Y160M1-2772.7158C76236.32.5Y160M1-2762.5145D66仃4.32.3Y132S1-2712.3130ZE80-20 0A10354 n295019.93.2Y200L1-276厂3.2209B954816.63Y180M-2753198C843812.13Y160M2-2723180D7031 n8.82.8Y160M1-267 :2.8160ZE80-25 0A12782295038.34.2Y225M-2744.2259B12076343.8Y225M-2733.8250.C10559 d23.43.5

11、Y200L1-2723.5225D874516.23.5Y180M-2663.5200ZE80-315A141127295070.74.3Y280M-2694.3324.B135121 t65.44Y280S-268 :4315C11597463.2Y250M-2663.2285D907429.73Y200L2-2613250ZE80-400A1711872950142.84Y315L-2614409B159170120.73.5Y315L1-2613.5397C13613084.53Y315S-2573360D1109551.72.8Y280S-2552.8320ZE100-160A1622

12、9295015.84.5Y180M-281 14.5169B1502412.34.2Y160M2-2804.2158C130177.74Y160M1-2784140D110125.13.5Y132S2-271 13.5125ZE100-200A19350295032.43.5Y225M-2813.5209B18044273Y200L2-280319 'C1553519.22.8Y200L1-2772.8180D1352613.32.8Y160L-2722.8160ZE100-250A23079295061.14.5Y280S-2814.5259 'B2187354.24Y280

13、S-2804250C19058384Y225M-2794230/220D1704426.14Y200L2-2784205/195ZE100-315A2501262950114.43.8Y315M-2753.8324B240120104.63.6Y315M-2753.6315C2039775.52.8Y280M-2712.8295/275D1707149.82.5Y280S-2662.5260/240A300194223.24.5Y355L1-2714.5409ZE100-400B2901802950200.24Y355M2-2714397C260145148.84Y315L-2694360D2

14、24105 1974Y315S-266 :4320A3204445.955Y250M-283.57209ZE150-2B30039295038.945Y225M-2826.519800C26530 128.137Y200L2-277 :6180D2202318.922Y180M-2735160A3907495.8110Y315S-2825.5259ZE150-2B35562295074.990Y280M-280524050C3254653.675Y280S-2765220/205A442125182.4220Y355M1-282.57324ZE150-315B4301202950171.422

15、0Y355M1-2826.8315C37294120.5160Y315L1-2796285D3106876.590Y280M-2756250ZE150-4A520205295037045078.5740900B498190330400786.7397C453151245315Y355L1-2756.5365/355D400113169200Y315L1-2736330/310ZE200-250A61072 12950142160Y315L1-284.5 19.2259B58065122160Y315L1-2848.2250C5204782.2110Y315S-2817.5225D47032 1

16、52.275Y280S-278 :6.5200ZE200-315A710122295027635585.59.5324B680114248315Y355L2-2858.5315C60087 1173200Y315L2-282 :7.5285D48065110132Y315M-2776.5250ZE200-400A85020329505736308213.5409B83019053063081 112397C750145 d3754507911360D670106255315Y355L2-27611320ZE25-200A5.81214750.531.1Y90S-436 :0.5209B5.41

17、1 0.461.1Y90S-435 0.4198C4.68.50.311.1Y90S-4340.4180D46.50.211.1Y90S-4330.4160ZE25-25A8.117.7 114751.41.5Y90L-4280.8259B7.715.61.31.5Y90L-4250.8250 '0C7.210.911.5Y90L-4220.6235 .D66.2 10.61.1Y90S-416 :0.6210ZE25-31A1032.314753.35.5Y132S-4270.43245B9.2292.84Y112M-4260.4315C8.324.3 12.23Y100L2-425

18、 :0.4300D7.6221.93Y100L2-4240.35285E7.119.51.72.2Y100L1-4220.35270F6.416 1.42.2Y100L1-420 10.35250ZE80-160A47814751.42.2Y100L2-4750.9169B4271.12.2Y100L2-4740.8158C385.5 :0.81.5Y90L-472 :0.8145D3440.61.5Y90L-4660.7130ZE80-200A5113.514752.54Y112M-4740.8209B47122.13Y100L2-473 :0.8198C419.5 n1.52.2Y100L

19、1-471 0.8180D367.51.11.5Y90L-4661160ZE80-201A642014754.87.5Y132M-472 :1.5259B6019 4.47.5Y132M-471 1.3250C5214.53.14Y112M-4661225D46112.23Y100L2-4631200ZE80-315A7033 n14759.615Y160L-465.5 :1.1324B66308.315Y160L-4651315C56245.811Y160M-4631285D4518亍3.85.5Y132S-458 :0.8250ZE80-400A8546147518.422Y180L-45

20、81409B804216.118.5Y180M-4570.8397C6533 n10.815Y160L-454 :0.6360D53257.211Y160M-4500.5320ZE100-160A817.2147523Y100L2-479.51.5169B736 11.62.2Y100L1-4771.4158C634.311.5Y90L-4741.2140D5530.631.1Y90S-4711125ZE100-200A9512.514754.15.5Y132S-479 11.12091B9010.5 13.35.5Y132S-477119C808.52.54Y112M-4740.9180D7

21、061.63Y100L2-471 :0.9160 ZE100-250A11520 14757.911Y160M-479.5：1.2259B110186.811Y160M-4791250C100144.97.5Y132M-4781230/220D90103.25.5Y132S-4761205/195ZE100-315A12531亍147514.518.5Y180M-473 丁1.2324B1192912.918.5Y180M-4731315C104249.915Y160L-4691295/275D8317.56.111Y160M-4651260/240ZE100-400A15048 147528

22、37Y225S-4701.5409B1454424.830Y200L-4701.4397C1303618.722Y180L-4681.4360D11526 n12.515Y160L-4651.5320 ZE100-5575Y280S-4701.651400B1676844.855Y250M-4691.5500C14253 131.537Y225S-465 :1.5450D1204221.830Y200L-4631.5400ZE150-200A1601114755.87.5Y132M-4822209B1529.54.97.5Y132M-481 11.7198C14073

23、.55.5Y132S-4761.5180D12352.33Y100L2-4731.5160ZE150-250A19518.5147512.215Y160L-480.5 :1.5259B18016 10.115Y160L-4781.4240C16011.56.711Y160M-4751.4220/205ZE150-315A22032.5 114752430Y200L-4811.8324B2103021.430Y200L-4801.8315C1802415.522Y180L-476 :1.5285D150179.615Y160L-4721.4250ZE150-400A26051147546.955

24、Y250M-4771.8409'B2504842.455Y250M-4771.7397C225383137Y225S-4751.6365/355D2002821.230Y200L-4721.5330/310ZE150-500A30077147585110Y315S-4742514B283727590Y280M-4741.8500C23359 n5275Y280S-4721.8450D2084536.445Y225M-4702400ZE150-560A335104147513516Y315L1-474.52.5578B31597 1112132Y315M-4742.3560C260807

25、8.790Y280M-4722.3510D2126052.575Y280S-4662.5450ZE150-630A360115 :1475179220Y355M1-463 12.5648B338105.5157185Y315L-4622.2630C27482 1104132Y315M-459 :1.8570D2206064.275Y280S-4562.2500ZE200-250A30517.5147517.422Y180L-483.52.5259B29016 115.218.5Y180M-483 12250C2601210.515Y160L-4811.8225D24086.611Y160M-4

26、791.6200ZE200-315A35030 :147533.845Y225M-484.5 :2.2324B340293237Y225S-4842315C3002222.830Y200L-4792285D2501513.418.5Y180M-4762250ZE200-400A42650 n147571.690Y280M-481 :3.5409B4104765.675Y280S-4803.2397C37036.547.255Y250M-4782.5360D33227 n32.545Y225M-475 2.5320ZE200-500A495841475140185Y315L-4813514B47

27、079126160Y315L1-4802.6500 ,C40063 n89.1110Y315S-4772.1450D3304858.375Y280S-4742.5400ZE200-560A5401051475194220Y355M1-479.53.1578B51098 1172220Y355M1-479 :3560C44081128160Y315L1-4762.5500D3506281110Y315S-4732.5450ZE200-630A5801321475269315Y355L2-477.5 :3.5648B550125 d245280Y355L1-476.53.2630C46810017

28、5220Y355M1-4732.5570D37275109132Y315M-470 12.5500ZE250-3A54527 147546.955Y250M-485.5：3.1324B5282542.355Y250M-4852.831515C4801930.337Y225S-4822.5285D43413 H2030Y200L-4772.8250 ZE250-400A660491475105132Y315M-4844409B6304696.2110Y315S-4823.5397C5653668.475Y280S-4813.2370/350D5002442.455Y250M-4773.2330/310ZE250-500A800821475215250Y355M2-4835514B77076194250Y355M2-4824.8500C70058138160Y315L1-4804.5460/440D6304294.8110Y315S-4765.6415/385ZE250-5A860106147530835580.5564860B83098277355804.8630C76078 1208