JSJR系列电机技术数据

1、JR、JS系列的电机是中型三相异步电动机，是我国50年代未60年代初统一设计的中型电动机，它分低压和高压两部分， 都是中型三相电动机的基本系列。型系列三相电动机，是我国近年来研制成功的节能新型电机。JR、JS系列的电机基本淘汰被Y系列所取代。 功率相同即是容量相同，只是 丫型系列电机体积比JR、JS系列电机体积小本文摘自：JR系列电动机JR系列电动机为驱动各种不同机械之用，如通风机、压缩机、水泵、破碎机、切削机床、榆树机械及其他设备等。本系列电动机一般为为自通风防护式。 电动机应在海拔高度不超过1,000米，使用地点空气温度不高于+40 C的室内正常 工作，温升限度符合国家标准 GB/T755

2、-2000的规定。 本系列电动机符合机械工业部部颁标准 JB563-64和JB564-64 的规定。本系列电动机共分为五个机座号，即11、12、13、14及15号机座。例如：（1） JS147-6表示鼠笼转子型异步电 动机，14号机座，定子铁心长度为7号，6极。（2） JR147-10表示绕线转子型异步电动机，14号机座，定子铁心长度 为7号，10极、JS JR系列概述J系列中型电机可驱动各种不同的机械，如通风机、压缩机、水泵、破碎机、球磨机、要削机床、运输机械及其他设备，可供煤矿、机械工业、发电厂及各种工矿企业中作原动机用。JS系列为鼠笼转子三相异步电机。JR系列为绕线转子三相异步电机。JS

3、系列电机符合部颁机准JB563-64技术条件的规定。JR系列电机符合部颁机准JB564-64技术条件的规定。本系列电机为防护式。根据用户需要也可制成 管道通风式。防护式电机应装置在海拔高度不超过1KM，周围空气温度不高于+40C，不低于0C,空气清洁，无酸、碱等腐蚀性 气体的室内。电机不允许在含有爆炸性气体或尘埃较多的环境中工作。当电机周围空气的温度超过上述规定或空气不清洁时，应采用管道通用方式。此时，通入电机两端的冷却空气温度 应为0C40C并且应保证管道和电机内部的空气压力高于周围空气的压力，必要时应加装鼓风机、滤尘器等。JS系列鼠笼型电机允许全电压直接起动。最初起动转矩和最初起动电流数值

4、分别与额定值之比，如表3所示。如用户的电网不允许全电压直接起动时，可以采用降低电压起动。但此时起动转矩将与起动电压成平方关系降低JR系列电机在起动时必须预先在转子回路内接入起动变阻器 。不允许将转子绕组直接短接起动。二、结构简述电机的其本安装型式机座带底脚卧式安装，所有型号的电机都可采用联轴器与被驱动机械联接。电机采用两侧对称 的径向通风系统，冷却空气自两侧端盖的进风口进入，一部分经过电机转子上的风扇或风叶片吹过定子线圈的端接部分， 另一部分空气经过转子铁心中的径向通风槽，然后由机座侧面的出风口逸出。管道通风式电机的通风系统与上述相同。电机的轴承采用滚动轴承。所用的轴承牌号见表 1,轴承润滑脂

5、牌号为锂基润滑脂ZL-3。表1机座号FrameNO.轴承规格Bearing NO.轴伸端Drivi ng end非轴伸端Non-driv ing end11NU319631912NU320632013NU32263221422228NU3241522230CNU326从电机的轴伸端看，出线盒在机座的右侧JS系列电机可以根据用户的要求制成双轴伸，其中任一个轴伸均可用以传达电机的额定功率（球轴承端只能用于联轴器传动）。JR系列电机在降低转矩的条件下，允许长期减速运转。此进，允许输出的功率和转矩与转速的对应关系应符合表2的规如果电机的负载转矩（驱动鼓风机、水泵等时）和转速成平方关系下降时，电机允许在

6、低转速下长期运转。表2转速109680706040Speed(%)0转矩Torque(%)1009691858062功率Output(%)1009673604825三、型号含义女口： JS115-6表示鼠笼转子异步电机，11号机座，铁心长度为5号，6极JR115-6表示绕线型转子异步电机，11号机座，铁心长度为5号，6极。JR系列电机分有电刷提升和短路装置和无电刷提升和短路装置两种JS系列(机座号1115 )技术数据型号额定功率(KW)额定电压(V)满载时堵转电流堵转转矩最大转矩转子飞轮力矩(N m2)被带动机 构的最大 允许飞轮矩(N m2)冷却空气量(m3/s)电机重量(kg)转速(r/m

7、in)定子电流(A)效率(%)功率因数(cos )额定电流额定转长额定转矩JS114-4115147021092.20.8984.751.21.8312025000.5875115-41351475244930.9015.581.452.0814028500.55970116-4155147527893.40.9065.671.52.0516031500.61040117-4180380147532193.80.9066.131.72.1618042000.651100JS126-4225147940093.10.9186.191.332.2833045500.871520127-426014

8、7945793.30.9156.481.432.31360515011630128-43001481527940.9256.91.592.4341059001.151760JS136-4220148025.591.50.9055.21.282.2653053001.32000JS137-4260148030.592.10.95.121.32.2260053001.42110138-4300148034.592.70.9055.511.442.3166045501.52210JS147-43606000148441930.885.31.252.2785036001.23000148-444014

9、845093.50.95.21.262.25100048001.432001410-450014855793.30.925.151.352.35120061501.53550JS158-468014887894.70.895.681.32.41700365024300JS1510-4850148896.595.20.89461.492.47210043502.34800JS1512-41050148811895.50.8965.971.552.37250046502.65200JS115-67598013991.70.8935.091.392.121047000.45895116-695980

10、17592.650.8925.891.72.3924058000.5995117-611598021092.80.8945.911.782.3627084000.531060JS125-6130380984237.5920.9025.941.342.1938069000.671300126-615598428292.30.9036.071.412.1744081000.751380127-618598633193.670.9065.721.672.348093000.81380128-621598638493.950.9046.171.882.24540106000.91450JS136-62

11、4098442393.20.925.851.142.24670136001.11800137-628098649593.50.926.581.312.45770101001.21900JS148-631098836.0492.490.8955.721.532.44145096001.131801410-638098544.0692.90.8936.021.672.531770133501.13450157-64609855393.20.8985.21.32.232300134001.43600158-6550600098562.293.80.875.51.22.12600146001.6390

12、01510-665098573.593.10.886.11.42.33300176001.845001512-678099087.394.60.9085.411.372.154000196002.34800JS115-86073512091.160.8325.151.682.2721086000.38870116-87073513791.60.8425.21.682.21240111000.41950117-88073515592.20.8474.81.542.07270130000.451025JS125-89573518291.50.8654.691.081.83470120000.591

13、250126-811038073421091.70.8664.671.091.803540150000.651400127-813073824293.30.824.881.571.9620189000.71370128-815573929193.40.8665.461.832.12670200000.761440JS136-818073932992.80.8975.661.212.23790186000.881730137-821073838892.80.8835.351.172.08890195000.951830138-8245737443940.8946.341.632.29890234

14、000.951900JS147-8200600074026900.794.91.321250204000.92900148-824074229.9492.40.845.621.732.54145024500131801410-828074234.992.630.8335.911.892.661770196000.853440157-832074238.7930.855.31.532.32300254001.23600158-838074245.693.50.865.41.642.332600272001.339001510-847574356.493.50.834.51.11.93300310

15、001.545001512-857074367.593.70.844.71.2240003590001.74800JS115-10453805879589.70.84.521.582.28240190000.3830116-1055587114900.8084.481.652.24270210000.33920117-1065587134900.814.411.64236990JS125-1080589161910.834.771.23251210126-109558718891.250.844.521.182490268000.613001

16、27-1011558722991.250.834.841.372.08555260000.651430128-1013058725691.650.8384.761.32610251000.651580JS137-1015559029192.30.8755.551.262.381050310000.751820138-1018058833492.50.8835.481.342.141150404000.811980JS1410-1020060005902790.80.795.41.92.72100377000.93300JS157-1026059032.990.740.83174.9921.55

17、82.6113000454001.13600158-103105903991.090.83085.131.6282.6593400508001.239001510-1040059049.691.180.85744.4141.3412.2014200606001.443001512-104805905991.390.85874.2591.3012.0965100726001.646001510-1228049437.490.870.79474.1481.2642.2694200898001.246001512-123304804491.260.79194.2551.3172.3155100103

18、4001.34650型号额定 功率额定电压(V)满载时最大转矩转子电压转子电流转子飞轮冷却空电机JR系列(机座号1115)技术数据表.|型号额定 功率 额定 电压(V)满载时最大 转矩 转子电压 转子电流 转子飞轮冷却空 电机(KW)转速(r/min)定子电流(A)效率(%)功率因数(cos)额定转矩(V)(A)力矩2 (N m )气量3(m3/S)重量(kg)JR114-41153801450212910.90421734331600.51035115-4135146024692.10.9042.332104081800.551130116-4155146027892.70.9132.282

19、384122000.61200117-4180146032193.10.9112.452754092200.651270JR126-4225147040593.10.9072.22914883700.91660127-42601472461930.922.1833449340011760128-4300147553093.90.9172.373904824401.11890JR136-4220600014752691.70.8941.973074575901.32110137-4260148030.392.30.8971.923464816301.42210138-430014783592.4

20、0.91.963984837101.52320JR147-436014794193.10.9042.685584068501.23000148-444014754993.440.922.6863441010001.433001410-4500148255.594.10.922.4471742012001.53600JR158-46806000148077.893.80.872.772258617001.745001510-4850148395.994.30.9042.580365721001.947001512-41050148011894.40.92.3103563025002.25450J

21、R115-67538096514290.30.891.981273822100.451025116-69597017791.740.8912.331623712400.51115117-611597321392.10.8932.321913812600.551170JR125-613097624591.40.8821.871874454000.671450126-615597729491.10.8731.852194554400.751530127-618597733492.80.9072.273663194900.81560128-621597938593.30.9082.444243175

22、400.91630JR136-6240977436930.9051.854073767601.11970137-628098150793.140.9072.154903608401.22030JR148-6310600098336.891.990.882.250537416501.133601410-638098344.792.50.882.159039118501.13630157-646098554920.87256851723001.43700158-65509856492.50.87261857026001.640001510-665098575930.872.174156033001

23、.845001512-67809858993.50.882.2862570400024750JR115-86038072012089.380.8462.591722302500.38980116-87072313790.270.8562.571992252800.411060117-88072315490.960.8692.452222303100.451135JR125-89572518390.550.8671.892132924500.61380126-811072621290.750.8661.842432945100.651550127-813072824292.150.882.042

24、563245700.71500128-815573229192.540.8752.33093166400.761600JR136-818073534592.250.85823543237700.881850137-8210734400930.861.843943418500.951940138-824573445393.10.861.84253658500.952060JR147-8200600073825.791.60.8182.540629915000.853090148-824073830.6920.8212.4345731916500.8533001410-828074035.792.

25、30.8182.5555030918500.853600JR157-83207393992.50.862.250939523001.23700158-838073845.6930.862.2254743626001.340001510-84757385693.280.8562.03164146833001.545001512-857073866.993.720.861.98169851440001.74750JR115-104538057797880.82.211172522600.3950116-1055577116890.8052.171402562800.331040117-106557

26、7135890.812.161592633100.361110JR125-108057416490.150.8171.961683094600.51350126-109557319390.440.8251.831883265200.51440127-1011538057523390.90.821.922253285800.551590128-1013057526191.140.8261.832513336500.61720JR137-1015558330791.450.85423542809300.751920138-1018058334691.60.861.838730010500.812090JR1410-1020060005902790.50.82.751124821000.93300JR157-1026058833.591.20.812.141240630001.13700158-1031058539.591.70.81244245434001.240001510-1040058550.3920.822.255446742001.445001512-104805856092.90.812.360251251001.64750JR1510-122804903891.40.772.247838042001.245001512-123304904491.