BP1系列频敏变阻器汇总

1、BP1系列频敏变阻器汇总BP1系列频敏变阻器汇总18/18BP1系列频敏变阻器汇总BP1系列频敏变阻器一、用途及型号意义本系列频敏变阻器适用于容量自22千瓦至2240千瓦，50赫芝、三相交流线线型异步电动机的轻载及重载做有时起动用，比方：水泵、空压机、轧钢机、空气压缩机等。变阻器的型号及意义：BP1-/导线截面积（mm2）铁芯编号（钢管频敏变阻器铁芯编号（钢管）设计序号铁芯编号（钢管）功率等级（千瓦）铁芯编号分两种：2号铁芯：厚度12毫米钢板，铁芯轮廓尺寸为200290毫米。3号铁芯：厚度12毫米钢板，铁芯轮廓尺寸为350440毫米。二、使用条件变阻器在以下条件下能可靠的进行工作：1、海拔不高

2、出4000米。12、周围介质温度不高于40及不低于-30。3、空气相对湿度不大于85（205）。4、在无爆炸危院介质中，且介质中无足以腐化金属和破坏绝缘的气体及导电尘埃。5、有防雨雪及没有充满水蒸气的地方。6、同意有一般震动和冲击的地方。7、在与垂直面倾斜成任何角度的地方。三、结构及安装尺寸变阻器是一种无触点电磁元件，相当于一个等值阻抗。在电动机起动过程中，由于等值阻抗随转子电流频率减小而自动下降（自动变阻），从而只须一级变阻器，就可以把电动机平稳地起动起来。变阻器实质上是一个铁芯耗费特大的三相电抗器。它由数片山型钢板叠合面的铁芯及线圈两个主要部份组成。钢板间夹以垫圈，保持片间距离，以利散热。

3、结构及安装尺寸见图一。BP1系列频敏变阻器外形及安装尺寸型号BP1BP1BP1BP1BP1BP1BP1BP1BP1BP1BP1BP1代号-204-205-206-208-210-212-305-306-308-310-312-316L1240240240240240240360360360360360360L2290290290290290290440440440440440440L3330330330330330330490490490490490490H1215215215215215215365365365365365365H2255255255255255255405405405405

4、405405B193108123153183213108123153183213273B2131146161191221251146161191221251311B3291306321351381441306321351381411471四、技术性能2轻载起动；传动设备在起动过程中不带负载或带有略微负载。起动负载系数Pc0.10.5，起动力矩系数Pg0.7，转子起动电流系数i2g1.251.6。一般起动时间小于20秒。比方：空气压缩机、水泵等。重轻载起动、分两种情况。一种是传动设备在起动过程中其阻力矩随转速的上升而下降，在起动时阻力矩较大。Pg0.50.8；起动力矩系数Pg1.0；转子起动电流

5、系数12g1.62.0。起动时间大于20秒。比方：带飞轮轧钢机的电机传动。另一种情况是传动设备在起动过程中不带负载或带有略微负载，阻力矩较小，一般机体粗笨，且高速运转，折算至电动机轴上的转动惯量较大，起动时间经常高出20秒。本变阻同意连续起动数次，但总起动时间不得高出80秒。五、使用方法3接线方式；由于单台变阻器体积重量不宜过大，故当电动机容量大到必然程度时就得多台做串连使用，如图二所示。抽头，变阻器每相绕组上有五抽头，一个抽头设在绕组反面，编号为N，其余四个抽头设在绕组正面，编号分别为1、2、3、4。抽头1N间为100匝数，抽头2N间，3N间，4N间分别为90，80，30匝数。（见图三）调正

6、；如在使用过程中遇到以下情况可以调正面匝数平和隙。1、当起动电流过大，起动太快，可想法增加匝数，换接到1N抽头，使用100匝数，匝数增加的奏效是起动电流的减少，起动力矩同时减少。2、当起动电流过小，起动力矩不够，起动太慢时，可想法减小匝数，换接到3N抽头（甚至采用14、24、34抽头）使用80匝数（甚至更少），匝数减少的奏效是起动电流增大，起动转矩同时增大。3、若是刚起动时嫌起动力矩大，机械有冲击，但起动达成后牢固转速以嫌低，起动达成短接时，冲击电流较大，可在上下铁芯间增设气隙，增加气隙的奏效是起动电流略微增加，起动力矩略微减小，但起动达成时力矩增大。牢固转速得以提高六、系列表4BP1频敏变阻

7、器系列表轻载重轻载轻载重轻载电机电机转子每每电机电机转子容量电流型号组型号组容量电流型号每组型号每组千瓦（安）台台千瓦（安）台数台数数数5163205/10051201-250308/63121316/40201226480205/80061230251-315308/50161316/32251-2881-100205/63081-280316-400380/40201316/25321101-125205/5010401-500308/32251316/2040151-63206/100051251-315310/50161310/63122并2964-80206/80061285316-

8、400310/40201310/50162-3581-100206/63081-355401-500310/32251310/40202101-125206/50101501-630310/25321310/3225251-63204/160031208/100051251-315312/50161312/63122并3664-80204/125041208/80061360316-400312/40201312/50162-4581-100204/100051208/63081-450401-500312/32251312/40202101-125204/80061208/50101501-

9、630312/25321312/3225264-80205/125011210/80061316-400316/40201316/50162并4681-100205/100051210/63081460401-500316/32251316/40202-55101-125205/80061210/50101-560501-630316/25321316/32252125-250205/63081210/40121631-800316/20401316/2532256-70126-160206/63081212/40121570316-400310/40202串310/50162串2161-20

10、0206/5010212/3216-710401-500316/3225310/4020并112201-250206/4012212/2502501-630310/5016310/32252112并251-315206/3216212/2025631-800310/4020310/2532212271-90161-200208/50101305/50161720-401-500312/22252串316/63123并201-250208/40121305/40121900501-630312/25322316/50163251-315208/32161305/32251631-800312/4

11、0202并316/40203316-400208/25201305/25321801-1000312/32252316/3225391161-200210/50101306/50161910-401-500316/32252串316/40202串2-115201-250210/40121306/402011.120501-630316/25322316/3225并251-315210/32161306/32251631-800316/40202并316/50164316-400210/25201306/25321801-1000316/32252316/4020454120201-550212

12、/40121308/402011.130631-800310/40202串2并316/63125并-140251-315212/32161308/32251-1400801-100316/32254316/50165316-400212/25201308/253211001-1250310/25324316/40205401-500212/20501308/204011251-1600310/20404316/32255145201-250305/63121310/402011.410801-1000316/50163并316/32252串3-180251-315305/5016310/322

13、51001-1250316/4020316/2532113并316-400305/4020310/25301.8001251-1600316/3225316/20406113401-500305/3225310/20401601-2000316/2530316/165061136185201-250306/63121312/402011.810801-1000316/32252串2并316/40202串4-225251-315306/5016312/3225-1001-1250316/2532316/3225并114316-400306/4020312/25302.2401251-160031

14、6/4020316/25328114并401-500306/3225312/20401601-2000316/3225316/2040811486BP2系列频敏变阻器一、用途及结构特点BP2系列频敏变阻器与BP1系列相同，用于轻载起动，电机容量101120千瓦。如空压机、水泵等。结构与BP系列不一样样之处是铁芯是用方钢制成。依照电机容量不一样样铁芯排数可为14排。型号及意义：BP2-/2导线截面积（mm）频敏变阻器铁芯编号（钢管）设计序号铁芯编号（钢管）功率等级（千瓦）7二、性能及使用方法性能与BP1系列基实情像，使用与调整方法也可参照BP1系列。但线圈抽头有四个：设在前面两个，后边两个。抽头

15、123（主）4抽头123（主）4线圈号线圈号0318.524.501054.572.51854210321.527.56201062.582.5240424.531.57201372.595.5270527.536.58201482.5109.5310531.541.59501695.5125.50636.547.05019109.5144.536109410741.554.5125022125.5166.5470847.562.5144025144.5191.5试车时一般接抽头1或抽头3。调试中可合适调正到抽头2或抽头4上。三、系列表及采用方法选择频敏变阻器时步骤：（1）依照电机功率PH从表

16、3中查出换算系数（2）电机转子电压乘以E得UF值。（3）依照UF值从表4中直接查出频敏变阻器的规格。8表3电动机功换算系数电动机功换算系数电动机功换算系数电动机功换算系数率PH千瓦E率PH千瓦E率PH千瓦E率PH千瓦E140.3171450.1663100.12657000.1012002711500.1643200.1252750.101280.2341550.1623300.1235800.100400.2461600.1603400.1226000.099450.2351650.1583500.1216250.098500.2261700.1573600.1206300.097550.2

17、171800.1543700.1186500.097600.2101850.1523800.1176800.095650.2041900.1513900.1167000.094700.1982000.1484000.1157100.094750.2102100.1454100.1147200.093800.2062150.1444250.1137500.092表3电动机功换算系数电动机功换算系数电动机功换算系数电动机功换算系数率PH千瓦E率PH千瓦E率PH千瓦E率PH千瓦E850.2012200.1434300.1127800.091900.1972500.1424400.1118000.09

18、0950.1932300.1414600.1108500.0881000.1902400.1384750.1089000.0861100.1832450.1374800.10810000.0831150.1812500.1365000.10610500.0811250.1752600.1345200.1051300.1722750.1325250.1041350.1702800.1315500.1031400.1683000.1285600.1029BP270系列起动用频敏变阻器电动机功率PH千瓦UE频敏型号22.825.9701/361325.929.7701/411329.734.2701

19、/471334.239.2701/540939.245.6701/6209103545.651.9701/702951.960.1701/820660.169.0701/950669.079.1701/1090679.191.1701/1250991.110.5701/1440426.129.30702/242629.3033.7702/272233.739.1702/312239.144.6702/361844.652.2702/4115357052.258.7702/471358.767.5702/541367.578.3702/621378.389.2702/720989.2103.47

20、02/8209103.4118.5702/95063034.3703/213034.338.6703/242638.644.3703/272244.351.5703/312251.558.6703/36187010558.667.1703/411567.177.2703/471377.288.6703/541388.6103703/6213103117.2703/7209117.2136703/820931.636.8704/183636.842.1704/213042.147.3704/242910514047.354.4704/272254.463.2704/272263.272.0704

21、/312272.082.5704/3618表四组数及接法星形星形星形星形星形1014021021028028042042056082.594.894.8109109126.423.426.726.730.030.034.534.540.140.145.745.752.352.360.160.169.069.080.280.291.391.3105.824.628.728.732.832.836.936.942.342.349.249.256.056.064.264.273.873.884.784.798.421.224.824.828.328.331.831.836.636.642.542.5

22、48.448.455.555.563.763.773.273.285.038.344.744.751.151.157.557.566.066.076.776.787.387.3100704/4713704/5413704/6213703/2130两并星形703/2426703/2722703/3122703/3618703/4115703/4713703/5413703/6213703/7209703/8209704/1836两并星形704/2130704/2429704/2722704/2722704/3122704/3618704/4713704/5413704/6213704/1836三

23、并星形704/2130704/2429704/2722704/2722704/3122704/3618704/4713704/5413704/6213704/18362并2串星形704/2130704/2429704/2722704/2722704/3122704/361811100115704/4713115132704/5413132153.4704/621333.238.7704/183638.744.2704/213044.249.8704/242949.857.1704/272257.166.3704/272256084066.375.5704/312275.586.6704/361

24、886.699.5704/471399.5114.2704/5413114.2132.7704/621329.934.9704/183634.939.9704/213039.944.8704/242944.851.5704/272251.559.8704/2722840112059.868.1704/312268.178.1704/361878.189.7704/471389.7103704/5413103119.7704/6213BP2系列频敏变阻器外形及安装尺寸型号BP2701BP2702BP2703代号L1240240240L2300300300L3330330330H121521521

25、5H2270270270B1102162222B2124184244B32843444043并2串星形4并2串星形BP270424030033021527028230446412BP3系列频敏变阻器一、用途本系列频敏变阻器适用于2.2125千瓦，JZR系列绕线型异步感觉电灵巧频频操作情况下的起动。频敏变阻器常接于电机转子回路中，一般不另装短接装置。二、频敏变阻器工作条件依照操作的频频程度不一样样可分为三类第一类：稍频频，每小时100400次。机械车间的桥式吊车上除主钩外，平移机构上的电机，出炉辊道拉钢机等。大多数是刚起动就断电。第二类：较频频，每小时400600次。冶金轧钢车间桥式吊车，除主钩

26、外，平移机构上的民机，轧机前后工作辊道，廷伸辊道等。大多数是起动刚就断电。第三类：频频操作，每小时6001000次。起落台、起落台辊道，压下装置，拨钢机，轧机中辊。三、系列表依照电机规格操作频频程度的不一样样可在系列表5中，直接查出频敏变阻器的规13BP3频敏变阻器系列表（适用于JZR系列电机）电机电机每小时起动100-400次每小时起动400-600次转子电机型号功率每组每组电流型号型号千瓦台数台数安JZR11-612.82.21BP3-003/112031JZR12-612.23.5BP3-003/112031BP3-005/100031JZR21-620.65BP3-005/100401

27、BP3-008/80041JZR22-621.67.5BP3-008/100041BP3-012/80041JZR31-635.611BP3-506/63081BP3-510/50081JZR31-8287.5BP3-008/80061BP3-012/63061JZR41-846.711BP3-506/50101BP3-510/40101JZR42-846.316508/10041BP3-512/40101JZR51-870.522512/50101BP3-408/40161JZR52-874.330406/63161-410/40161JZR61-1013330406/32251-410/2

28、5251JZR62-1013845410/50161-408/50122JZR63-1018060412/25321-410/40162JZR71-1016780408/50161-412/40162JRR72-10170100410/50162-40840164JZR73-10175125412/50162-410/40164每小时起动600-1000次型号每组台数BP3-005/80031BP3-008/80031BP3-012/63041BP3-510/63041BP3-406/63061BP3-510/50061BP3-406/50101408/50101412/32161408/63

29、082408/40122412/40122408/32164410/32164412/32164408/32168BP3频敏变阻器系列表（适用于JXR2系列电机）电机电机每小时起动100-400次每小时起动400-600次每小时起动600-1000次转子电机型号功率每组每组每组电流型号型号千瓦台数台数型号安台数JZR2-11-611.82.21BP3-003/112031BP3-005/80031JZR2-12-612.13.5BP3-003/112031BP3-005/100031BP3-008/80031JZR2-21-617.75BP3-005/100401008/80041012/63

30、041JZR2-22-618.97.5-008/100041012/80041510/80041JZR2-31-632.211-506/63081510/63061406/80061JZR2-31-827.27.5-008/80061012/63061510/63061JZR2-41-849.211-506/50101510/40101406/50101JZR2-42-84916508/50101512/63101408/80101JZR2-51-864.122512/40121408/50121412/40121JZR2-52-86730406/63121410/50121408/80062

31、-61-10145.630406/32321410/25321408/3216262-1015840408/32321412/20321410/43216263-10164.850410/25321408/40162412/32162-64-1015465412/32321410/40162408/3216471-1017680408/5016241240162410/3216472-10177.2100410/50162408/40164412/3216473-10181125412/50162410/40164408/3216614BP3频敏变阻器外形及安装尺寸断念编054号BP3BP3B

32、P3BP3BP3BP3BP3BP3BP3BP3BP3BP3排数代号-003-005-008-012-506-508-510-512-406-408-410-412L1150150150150220220220220320320320320L2195195195195290290290290440440440440L3230230230230355355355355510510510510H1181181181181215215215215365365365365H2221221221221260260260260410410410410B1821081471991581942302661632

33、09255301B2112138177229198234270306203249295341B327229833738935839443046636340945550615BP4系列频敏变阻器一、用途及型号意义本系列频敏变阻器适用于14000千瓦绕线型异步感觉电动机作重载有时起动作用。比方球磨机破碎机等。型号意义BP4-/2导线截面积（mm）频敏变阻器铁芯编号（钢管）设计序号铁芯编号（钢管）功率等级（千瓦）二、起动性能负载力矩Pc=0.71.0起动力矩Pg=1.2起动电流与切除电流之比，小于2.5倍额定电流。同意连续起动三次，但总起动时间不得高出90秒。16三、系列表电机容量电机转子型号每组电

34、机容量电机转子电型号每组（千瓦）电流（安）台数千瓦流（安）台数1425253002501/24504116020020125020009/090321314002501/19605125131520009/071401415002501/14006131640020009/056501516302501/11208140150020009/045631648002501/090102540415004002/15506120125020125025010/090321516304002/12508125131525010/071401648004002/10010131640025010/0565018110004002/08012140150025010/04563110112504002/0631614050648005003/1121012513152513153151118110005003/09012131640008040110112505003/07116140150031511/06350112616005003/05620150163031511/05063216120005003/04525116008/06340506310112506304/10016131540025131540012/1004011261600630