乘客电梯的PLC控制PLC四层电梯控制系统设计整理

1、电源AC110120V/220240V单相50/60Hz电源波动AC93.5132V/187264V，10ms以下瞬时断电，控制不受影响环境温度055度环境湿度45%95%，无凝露抗振动1055Hz，0.5mm，最大2g（重力加速度）抗冲击10g，3轴X、Y、Z方向各3次抗噪声1000V,1us,30100Hz(噪声仿真器)绝缘耐压AC 1500V，1min(各端子与接地端之间)绝缘电阻5M,500V DC(各端子与接地端之间)接地小于100（如果不可能，也可以不接地）环境无腐蚀气体，无导电尘埃输入类型无电压触点或NPN集电极开路晶体管绝缘光-电隔离 输入电压内部电源DC24V4V,外部电源D

2、C24V8V输入阻抗工作电流OFF-ONDC4mA(最小)ON-OFFDC1.5mA（最大）响应时间OFF-ON近似10ms(有8点可改变从060ms)ON-OFF近似10ms（有8点可改变从060ms）执行方法周期执行存储的程序，集中输入/输出执行速度平均12us/步程序语言继电器和逻辑符号（梯形图）程序容量1000步指 令逻辑指令20条（包括MC/MCR,CJP/EJP,S/R）步进梯形指令2条（STL,REJ）功能指令87个（包括+，-，=，等程序记忆内部配置CMOS-RAM,EPROM/EEPROM卡辅助继电器无锁存128点锁存64点状态（锁存）64点特殊16点数据寄存器64点定时器2

3、4点（延时接通）0.1999s计数器（锁存）30点，减法计数（0999）高速计数器（锁存）1点，加/减计数（0999999），最大2KHz电池保护锂电池，寿命约5年诊断程序检查（和，语法，电路），定时监视，电池电压，电源电压输出类型继电器输出绝缘继电器绝缘输出负荷电阻负荷2A/点感性负荷35V/A/300000次接通断开灯泡负荷100W漏电流0mA响应时间OFF-ON近似10msON-OFF近似10ms型号输入点输出点端子块功耗输入传感器电源F1-60MR36点24点可拆卸端子40V/A序号名称输入点序号名称输入点0四层内选按钮S4X0007一层上呼按钮U1X0071三层内选按钮S3X0018

4、二层上呼按钮U2X0102二层内选按钮S2X0029三层上呼按钮U3X0113一层内选按钮S1X00310一层行程开关SQ1X0124四层下呼按钮D4X00411二层行程开关SQ2X0135三层下呼按钮D3X00512三层行程开关SQ3X0146二层下呼按钮D2X00613四层行程开关SQ4X015序号名称输出点序号名称输出点0四层指示L4Y0008二层内选指示SEL2Y0101三层指示L3Y0019一层内选指示SEL1Y0112二层指示L2Y00210一层上呼指示UP1Y0123一层指示L1Y00311二层上呼指示UP2Y0134轿箱下降指示DOWNY00412三层上呼指示UP3Y0145轿

5、箱上升指示UPY00513二层下呼指示DN2Y0156四层内选指示SL4Y00614三层下呼指示DN3Y0167三层内选指示SL3Y00715四层下呼指示DN4Y017步序指令器件号说明步序指令器件号说明0LDX012停在一层41ORM641ANIX00342ORM652ANDX007一层上呼按钮43ANIX0133LDM144OUTM4一层到二层4ANIT345LDX013停在二层5ANIT1046ANIX0026ANIT1347ANDX010二层上呼按钮7ORB48LDM58ANIM849ANIT49ANIM1250ANIT1510ANIM551ORB11OUTM1在一层按52ANIM11

6、2LDM153ANIM1213ANDX000四层内选按钮54ANIM1514ANIX00155ANIM815ANIX00256OUTM5在二层按16LDM257LDM517ANIM1858ANDX000四层内选按钮18ORB59LDM619ORM6060ANIM1720ORM6161ORB21ANIX01562ORM6622OUTM2一层到四层63ORM6723LDM164ANIX01524ANDX001三层内选按钮65ANIX00125ANIX00066ANIX00326ANIX00267OUTM6二层到四层27LDM368LDM528ANIM1469ANDX001三层内选按钮29ORB70

7、LDM730ORM6271ANIM1331ORM6372ORB32ANIX01473ORM6833OUTM3一层到三层74ORM6934LDM175ANIX01435ANDX002二层内选按钮76ANIX00036ANIX00077ANIX00337ANIX00178OUTM7二层到三层38LDM479LDX013停在二层39ANIM980ANIX00240ORB81ANDX006二层下呼按钮82LDM8124ANIX00283ANIT5125ANIX00384ORB126OUTM11三层到四层85ANIM1127LDX014停在三层86ANIM5128ANIX00187ANIM10129AN

8、DX005三层下呼按钮88ANIM12130LDM1289ANIM15131ANIT790ANIM69132ANIT1791OUTM8在二按133ORB92LDM8134ANIM193ANDX003一层内选按钮135ANIM594LDM9136ANIM1095ANIM4137ANIM1596ORB138OUTM12在层按97ORM70139LDM1298ORM71140ANDX002二层内选按钮99ANIX012141LDM13100ANIX000142ANIM7101ANIX001143ORB102OUTM9二层到一层144ORM74103LDX014停在三层145ORM75104ANIX0

9、01146ANIX013105ANDX011三层上呼按钮147ANIX000106LDM10148ANIX003107ANIT6149OUTM13三层到二层108ORB150LDM12109ANIM12151ANDX003一层内选按钮110ANIM15152LDM14111ANIM5153ANIM3112ANIM8154ORB113ANIM1155ORM76114ANIM75156ORM77115OUTM10在三层按157ANIX012116LDM10158ANIX000117ANDX000四层内选按钮159ANIX002118LDM11160OUTM14三层到一层119ANIM16161LD

10、X015停在四层120ORB162ANIX000121ORM72163ANDX004四层下呼按钮122ORM73164LDM15123ANIX015165ANIT8166ANIT20209ORM19167ANIT22210ANIX015168ORB211OUTM19一层到二三四169ANIM10212LDM3170ANIM5213ANDM4171ANIM1214ORM20172OUTM15在四层按215ANIX014173LDM15216OUTM20一层到二、三174ANDX001三层内选按钮217LDM2175ANIX002218ANDM4176ANIX003219ORM21177LDM16

11、220ANIX015178ANIM11221OUTM21一层到二、四179ORB222LDM2180ORM78223ANDM3181ORM19224ORM22182ANIX014225ANIX015183OUTM16四层到三层226OUTM22一层到三、四184LDM15227LDM6185ANDX002二层内选按钮228ANDM7186ANIX001229ORM23187ANIX003230ANIX015188LDM17231OUTM23二层到三、四189ANIM6232LDM13190ORB233ANDM14191ORM80234ORM24192ORM81235ANIX012193ANIX

12、013236OUTM24三层到二、一194OUTM17四层到二层237LDM16195LDM15238ANDM17196ANDX003一层内选按钮239ANDM18197ANIX001240ORM25198ANIX002241ANIX012199LDM18242OUTM25四层到三二一200ANIM3243LDM17201ORB244ANDM18202ORM82245ORM26203ORM83246ANIX012204ANIX012247OUTM26四层到二、一205OUTM18四层到一层248LDM16206LDM2249ANDM17207ANDM3250ORM27251ANIX013293

13、ANIX015252OUTM27四层到三、二294ANIM8253LDM16295OUTM66二层到四层254ANDM18296LDX004四层下呼按钮255ORM28297ANDX013停在二层256ANIX012298ORM67257OUTM28四层到三、一299ANIX015258LDX000四层内选按钮300ANIM8259ANDX012停在一层301OUTM67二层到四层260ORM60302LDX001三层上呼按钮261ANIX015303ANDX013停在二层262OUTM60一层到四层304ORM68263LDX004四层上呼按钮305ANIX014264ANDX012停在一层

14、306ANIM8265ORM61307OUTM68二层到三层266ANIX015308LDX011三层上呼按钮267OUTM61一层到四层309ANDX013停在二层268LDX001三层内选按钮310ANIX005269ANDX012停在一层311ORM69270ORM62312ANIX014271ANIX014313ANIM8272OUTM62一层到三层314OUTM69二层到三层273LDX011三层上呼按钮315LDX003一层内选按钮274ANDX012停在一层316ANDX013停在二层275ANIX005317ORM70276ORM63318ANIX012277ANIX01431

15、9ANIM5278OUTM63一层到三层320OUTM70二层到一层279LDX002二层内选按钮321LDX007一层上呼按钮280ANDX012停在一层322ANDX013停在二层281ORM64323ORM710282ANIX013324ANIX012283OUTM64一层到二层325ANIM5284LDX010二层上呼按钮326OUTM71二层到一层285ANDX012停在一层327LDX000四层内选按钮286ANIX006328ANDX014停在二层287ORM65329ORM72288ANIX013330ANIX015289OUTM65一层到二层331ANIM12290LDX00

16、0四层内选按钮332OUTM72三层到四层291ANDX013停在二层333LDX004四层下呼按钮292ORM66334ANDX014停在三层335ORM73377ORM80336ANIX015378ANIX013337ANIM12379OUTM80四层到二层338OUTM73三层到四层380LDX006二层下呼按钮339LDX002二层内选按钮381ANDX015停在四层340ANDX014停在三层382ANIX010341ORM74383ORM81342ANIX013384ANIX013343ANIM10385OUTM81四层到二层344OUTM74三层到二层386LDX003一层内选按

17、钮345LDX006二层下呼按钮387ANDX015停在四层346ANDX014停在三层388ORM82347ANIX010389ANIX012348ORM75390OUTM82四层到一层349ANIX013391LDX007上层上呼按钮350ANIM10392ANDX015停在四层351OUTM75三层到二层393ORM83352LDX003一层内选按钮394ANIX012353ANDX014停在三层395OUTM83四层到一层354ORM76396LDM4355ANIX012397ANIX012356ANIM10398OUTT3延时2秒357OUTM76三层到一层399K20358LDX0

18、07一层上呼按钮400LDM7359ANDX014停在三层401ANIX013360ORM77402OUTT4延时2秒361ANIX012403K20362ANIM10404LDM9363OUTM77三层到一层405ANIX013364LDX001三层内选按钮406OUTT5延时2秒365ANDX015停在四层407K20366ORM78408LDM11367ANIX014409ANIX014368OUTM78四层到三层410OUTT6延时2秒369LDX005三层下呼按钮411K20370ANDX015停在四层412LDM13371ANIX011413ANIX014372ORM79414OU

19、TT7延时2秒373ANIX014415K20374OUTM79四层到三层416LDM16375LDX002二层内选按钮417ANIX015376ANDX015停在四层418OUTT8延时2秒419K20461ANIX012420LDM3462OUTT23延时2秒421ANIX012463K20422OUTT9延时2秒464LDM19423K20465ANDX013424OUTT10延时4秒466ORM40425K40467ANIX015426LDM2468OUTM40427ANIX012469LDM40428OUTT11延时2秒470ANIX013429K20471OUTT24延时2秒430

20、OUTT12延时4秒472K20431K40473LDM40432OUTT13延时6秒474ANDX014433K60475ORM41434LDM6476ANIX015435ANIX013477OUTM41436OUTT14延时2秒478LDM41437K20479ANIX014438OUTT15延时4秒480OUTT25延时2秒439K40481K20440LDM14482LDM20441ANIX014483ANIX012442OUTT16延时2秒484OUTT26延时2秒443K20485K20444OUTT17延时4秒486LDM20445K40487ANDX013446LDM18488

21、ORM42447ANIX015489ANIX014448OUTT18延时2秒490OUTM42449K20491LDM42450OUTT19延时4秒492ANIX013451K40493OUTT27延时2秒452OUTT20延时6秒494K20453K60495LDM21454LDM17496ANIX012455ANIX015497OUTT28延时2秒456OUTT21延时2秒498K20457K20499LDM21458OUTT22延时4秒500ANDX013459K40501ORM43460LDM19502ANIX015503OUTM43545ANIX012504LDM43546OUTM4

22、6505ANIX013547LDM46506OUTT29延时2秒548ANIX013507K20549OUTT37延时2秒508OUTT30延时4秒550K20509K40551LDM25510LDM22552ANIX015511ANIX012553OUTT38延时2秒512OUTT31延时2秒554K20513K20555LDM25514OUTT32延时4秒556ANDX014515K40557ORM47516LDM22558ANIX012517ANDX014559OUTM47518ORM44560LDM47519ANIX015561ANIX014520OUTM44562OUTT39延时2秒

23、521LDM44563K20522ANIX014564LDM25523OUTT33延时2秒565ANDX013524K20566ORM48525LDM23567ANIX012526ANIX013568OUTM48527OUTT34延时2秒569LDM48528K20570ANIX013529LDM23571OUTT40延时2秒530ANDX014572K20531ORM45573LDM26532ANIX015574ANIX015533OUTM45575OUTT41延时2秒534LDM45576K20535ANIX014577OUTT42延时4秒536OUTT35延时2秒578K40537K20

24、579LDM26538LDM24580ANDX013539ANIX014581ORM49540OUTT36延时2秒582ANIX012541K20583OUTM49542LDM24584LDM49543ANDX013585ANIX013544ORM46586OUTT43延时2秒587K20629LDM2588LDM27630ANIX012589ANIX015631ANIT11590OUTT44延时2秒32ANIM19591K20633ANIM21592LDM27634ANIM22593ANDX014635ORB594ORM50636LDM19595ANIX013637ANIX012596OUT

25、M50638ANIT23597LDM50639ORB598ANIX014640LDM20599OUTT45延时2秒641ANIX012600K20642ANIT26601LDM28643ANIM19602ANIX015644ORB603OUTT46延时2秒645LDM21604K20646ANIX012605LDM28647ANIT28606ANDX014648ANIM19607ORM51649ORB608ANIX012650LDM22609OUTM51651ANIX012610LDM51652ANIT31611ANIX014653ANIM19612OUTT47延时2秒654ORB613K20

26、655LDM25614OUTT48延时4秒656ANDT40615K40657ANIX012616LDM4658ORB617ANIX012659LDM26618ANIT3660ANDT43619ANIM19661ANIX012620ANIM20662ANIM25621ANIM21663ORB622LDM3664LDM28623ANIX012665ANDT48624ANIT9666ANIX012625ANIM19667ANIM25626ANIM20668ORB627ANIM22669LDM24628ORB670ANDT37671ANIX012713ANIM19672ORB714ANIM20673

27、LDM14715ANIM22674ANDT17716ORB675ANIX012717LDM2676ANIM24718ANDT11677ORB719ANIT12678LDM18720ANIM19679ANDT20721ANIM21680ANIX012722ANIM22681ANIM25723ORB682ANIM26724LDM6683ANIM28725ANIX013684ORB726ANIT14685LDM9727ANIM23686ANDT5728ORB687ANIX012729LDM14688ORB730ANDT16689OUTY003一层指示731ANIT17690LDM4732ANIM24

28、691ANDT3733ORB692ANIX013734LDM18693ANIM19735ANDT19694ANIM20736ANIT20695ANIM21737ANIM25696LDM7738ANIM26697ANIX013739ANIM28698ANIT4740ORB699ANIM23741LDM17700ORB742ANDT22701LDM9743ANIX014702ANIX013744ANIM25703ANIT5745ANIM26704ORB746ANIM27705LDM13747ORB706ANIX013748LDM19707ANDT7749ANDT23708ANIM24750ANIT

29、24709ORB751ANIX013710LDM3752ORB711ANDT9753LDM20712ANIT10754ANDT26755ANIT27797ANIT48756ANIX013798ANIM25757ANIM19799ORB758ORB800OUTY002二层指示759LDM21801LDM7760ANDT28802ANDT4761ANIT29803ANIX014762ANIX013804ANIM23763ANIM19805LDM11764ORB806ANIX014765LDM22807ANIT6766ANDT31808ORB767ANIT32809LDM13768ANIM19810

30、ANIX014769ORB811ANIT7770LDM23812ANIM24771ANIX013813ORB772ANIT34814LDM16773ORB815ANIX014774LDM24816ANDT8775ANDT36817ANIM25776ANIT37818ANIM27777ANIX013819ANIM28778ORB820ORB779LDM25821LDM3780ANDT39822ANDT10781ANIT40823ANIX014782ANIX013824ANIM19783ORB825ANIM20784LDM26826ANIM22785ANDT42827ORB786ANIT43828

31、LDM2787ANIX013829ANDT12788ANIM25830ANIT13789ORB831ANIM19790LDM27832ANIM21791ANDT45833ANIM22792ANIX013834ORB793ANIM25835LDM6794ORB836ANDT14795LDM28837ANIT15796ANDT47838ANIM23839ORB881ANDT34840LDM14882ANIT35841ANIX014883ANIX014842ANIT16884ORB843ANIM24885LDM24844ORB886ANIX014845LDM18887ANIT36846ANDT188

32、88ORB847ANIT19889LDM25848ANIM25890ANDT38849ANIM26891ANIT39850ANIM28892ANIX014851ORB893ORB852LDM17894LDM26853ANDT21895ANDT41854ANIT22896ANIT42855ANIM25897ANIM25856ANIM26898ORB857ANIM27899LDM27858ORB900ANDT44859LDM19901ANIT45860ANDT24902ANIX014861ANIT25903ANIM25862ANIX014904ORB863ORB905LDM28864LDM2090

33、6ANDT46865ANDT27907ANIT47866ANIX014908ANIX014867ANIM19909ANIM25868ORB910ORB869LDM21911OUTY001三层指示870ANDT29912LDM11871ANIT30913ANIX015872ANIM19914ANDT6873ORB915LDM16874LDM22916ANIX015875ANDT32917ANIT8876ANIT33918ANIM25877ANIX014919ANIM27878ANIM19920ANIM28879ORB921ORB880LDM23922LDM2923ANIX015965ORB924

34、ANDT13966LDM25925ANIM19967ANIX015926ANIM21968ANIT38927ANIM22969ORB928ORB970LDM26929LDM6971ANIX015930ANDT15972ANIT41931ANIX015973ANIM25932ANIM23974ORB933ORB975LDM27934LDM18976ANIX015935ANIX015977ANIT44936ANIT18978ANIM25937ANIM25979ORB938ANIM26980LDM28939ANIM28981ANIX015940ORB982ANIT46941LDM17983ANIM2

35、5942ANIX015984ORB943ANIT21985OUTY000四层指示944ANIM25986LDM1945ANIM26987ANDX012946ANIM27988LDM71947ORB989ORM77948LDM19990ORM83949ANDT25991ANIX012950ANIX015992ORB951ORB993OUTY012一层上呼指示952LDM21994LDM5953ANDT30995ANDX013954ANIX015996LDM65955ANIM19997ANIX013956ORB998ORB957LDM22999OUTY013二层上呼指示958ANDT331000L

36、DM10959ANIX0151001ANDX014960ANIM191002LDM63961ORB1003ORM69962LDM231004ANIX014963ANDT351005ORB964ANIX0151006OUTY014三层上呼指示1007LDM81049ANIX0141008ANDX0131050ORB1009LDM751051LDM61010ORM811052ANIX0151011ANIX0131053ORB1012ORB1054LDM231013OUTY015二层下呼指示1055ANIX0151014LDM121056ORB1015ANDX0141057LDM111016LDM7

37、91058ANIX0151017ANIX0141059ORB1018ORB1060OUTY005电梯上升指示1019OUTY016三层下呼指示1061LDM161020LDM151062ANIX0141021ANDX0151063LDM171022LDM611064ANIX0131023ORM671065ORB1024ORM731066LDM181025ANIX0151067ANIX0121026ORB1068ORB1027OUTY017四层下呼指示1069LDM251028LDM21070ANIX0121029ANIX0151071ORB1030LDM31072LDM261031ANIX0141073ANIX0121032ORB1074ORB1033LDM41075LDM271034ANIX0131076ANIX0131035ORB1077ORB1036LDM191078LDM281037ANIX0151079ANIX0121038ORB1080ORB1039LDM201081LDM131040ANIX0141082ANIX0131041ORB1083ORB1042LDM211084LDM141043ANIX0151085ANIX0121044ORB1086ORB1045LDM221087LDM24104