安装说明和锅炉软化水设备使用资料下载

1、.popular innovation, the much anticipated entrepreneurial atmosphere. Six is to highlight the strong comprehensive and strict guarantees, constantly consolidate the basis of the party building. As the biggest achievement in grasping party building, fully strictly administering the party achieved rem

2、arkable results. Cast soul guben caught idea. Adhere to the important mission of inspiring, gather the people with common ideals, with development achievements inspired people, conscientiously study the party's latest theoretical achievements, further carry out various types of mass selecting mo

3、de selection, multiple trees and carrying forward the righteousness of fresh air, and constantly promote the development of positive energy together. Strict management of cadres. Developed has new promoted section cadres evaluation and debriefing approach, and township section cadres attendance repo

4、rt informed system and leaders talk talk approach, perfect has Township morning will system, specification has Township cadres management; according to "good cadres" standard selection cadres, set has heavy conduct, and heavy performance, and heavy grass-roots, and heavy public of oriented

5、; research developed party work supervision and grass-roots party assessment evaluation approach, formed has three level Secretary linkage caught party of pattern. Wind Su JI caught style. Carry out "three-three" special education and strictly investigate and called upon to inform the name

6、 violates the Central "eight rules" of people and things, concentration and control of frivolity and not as style, as issues such as cadres ' style continuous improvement. Responsibility to catch the independent Commission against corruption. Strictly implement the "3883" res

7、ponsibility, and fully cooperate with inspections of municipal party Committee, listen to the people's congresses, Governments, CPPCC Committee, the County party Committee Standing Committee, Township departments mainly responsible for the implementation of responsibility briefing, step by step

8、to carry out interviews, layers of conductive pressure, clean system continuously. 2015 work go hand in hand, with remarkable results, marked "Twelve-Five" collector of development success. In five years, the County in accordance with the "effective strengthening four support and furt

9、her development of the five industries, accelerate the construction of three major patterns" strategy, focused, hard work, and promoting the rapid, sustained and healthy development of economy and society, becoming the fastest-accelerating the adjustment of the economic structure, enhance compr

10、ehensive strength, significant infrastructure improvements, urban and rural . For five years, wrote on the event in the history of jingchuan brilliant chapter. The practice shows that in five years, must adhere to the development the first priority is not shaken, must adhere to the project driven st

11、rategy up, must adhere to the deep development does not stop, must adhere to a comprehensive reform does not retreat, must adhere to the strengthening work style building do not slack off,安装说明和锅炉软化水设备使用资料下载安装说明和锅炉软化水设备使用一、装置要求及安装步骤可装置增压水泵提高进水压力。如果压力过高，、进水压力应在0.2-0.6MPa当水源压力无法满足要求时。应装置减压阀来控制进水压力。此装置不

12、允许在冰点状态下工作、进水温度应在5-45之间。.并不可被其开关切断、电源采用交流200V/50Hz运行中需保证电源不间断，附近有畅通的下水，、软水器应安装在牢固的平台上。并留有足够的操作和维修空间。2锅炉软化水设备装置方法并保证罐体水平1先将树脂罐.盐罐就位于坚实的基础上.然后拔出到树脂罐中央，2把下布水器牢固安装在中心管底端。中心管上端低于罐口0.5mm处截断并导角，然后用胶带封住中心管口，以防树脂漏入。树脂装填完 该技术资料由莱特莱德西宁锅炉软化水设备厂家提供3将树脂均匀地装入树脂罐中。取下中心管的封口胶带，将中心管上部及树脂罐端面用水冲洗并擦干净，中心管及控制器密封圈处涂上硅油。然后将

13、中心管从上布水器内插入到控制阀内4将上布水器安装到控制阀上。小心地沿顺时针方向转动控制阀，直至旋紧在树脂罐接口上(或用法兰连接固定)一定要确保中心管插入阀体。下布水器与中心管必须严密，注意：上布水器与控制阀、中心管。防止树脂跑出。中心管与控制阀必需严密不漏水，否则会出现窜硬水现象。5锅炉软化水设备组装盐阀然后把不锈钢滤网插入小铜配件内;带滤网的一端与控制阀的吸盐接口相连接，、将吸盐管与阀体连接的小铜配件插入吸盐管内后。不漏空气就行。然后与塑料弯头连接;盐水管路连接长度不应超越2m一定要保持良好的密封性，、把盐阀置入盐箱的盐井中。否则会影响软水器的再生效果。6排水管的连接长度不应超越6m不得采用

14、软塑料管。影响排水效果。7锅炉软化水设备管道连接采用流量型再生控制器，、依照控制阀进出水箭头标志连接进出水管。流量计必须安装在出水口。同时还应装有旁通阀，、进出水管应装有压力表及手动阀门。出水管阀前还应装置有取样阀。进水管阀后一般装置有 Y型过滤器，防止管道内污物堵塞阀体造成设备无法正常运行。二、锅炉软化水设备试调运行a慢地打开进水阀门至 1/4开启处(注意：阀门开启过快树脂将会流失)此时可以到空气从排水管排出的声音;全部开启进水阀; 软化水处理设备, b待空气排净后。锅炉软化水设备,全自动软化水设备并且时刻保证固体盐高于盐水液面, c用桶或水管向储盐罐内加水(仅在设备投入运行时操作)注意必需

15、用大粒盐.以确保是饱和盐液,禁用：细盐、碘盐) 旋转手动再生旋钮， d接通电源。启动一次再生;从取样阀放取水样进行水质分析， e自动再生完成后。合格后即可投入使用;依照操 作要求设定时间或流量的再生周期。三、锅炉软化水设备再生顺序设置1时间再生控制器再生时间设定方法：使其与24小时齿轮松开，首先按下控制器左侧的红色时间按钮。即可调整24小时齿轮，直到当前时间与时间箭头对齐。就使24小时齿轮上10A M与时间箭头对齐，例如：当前时间是10:00A M如果不想改变再生时间。如要推迟2小时再生，应使24小时齿轮上8A M与时间箭头对齐，如果要提前2小时再生，应使24小时齿轮上12A M与时间箭头对齐

16、。时间型再生控制器再生日期跳轮：红色指针处的薄片代表当天。可通过向外拉出跳轮上的薄片， 跳轮上每个薄片代表一天。露出其上端来设定再生日期。如先将所有薄片拨回，然后每隔一个向外拉出一个薄片，则再生日期为每隔一天再生一次)2锅炉软化水设备流量再生控制器流量再生控制器周期产水量的设定方法：压住流量外盘，拔出流量软轴线。提起流量刻度盘，按所需要设定的周期产水量对准面板上的小白点，松手使齿轮啮合。然后用手转动流量盘，使其设定的周期产水量与面板上的流量指示箭头对齐，再插上流量软轴线即可。3手动启动再生顺序方法：也可手动顺时针方向旋转手动再生轮，当出水硬度超标时。软水器则启动再生顺序，并将依照设定工作方法完

17、成一个再生循环，直至返回工作状态(产软水)同时在手动再生轮缺口处显示每一工作方法名称。四、软水器工作过程反洗、吸盐(再生)正洗(置换)注水五个过程,规范工作流程主要包括：工作有时叫做产水。1工作原水在一定的压力。流经装有离子交换树脂的容器(软化器)树脂中所含的可交换离子Na 与水中的阳离子(Ca2 Mg2 Fe2 等)进行离子交换，使容器出水的Ca2 Mg2 含量达到要求。2反洗造成软水器参数设置不正确，、由于进水情况发生变化。应定期根据进水情况，对软水器进行运行调试。进行再生之前先用水自下而上的进行反洗， 树脂失效后。反洗的目的有两个，一是通过反洗，使运行中压紧的树脂层松动，有利于树脂颗粒与

18、再生液充分接触，二是清除运行时在树脂表层积累的悬浮物及树脂表面的悬浮物，同时一些碎树脂颗粒也可以随着反洗水排出。这样，交换器的水流阻力不会越来越大。时间10分钟。3锅炉软化水设备吸盐流量下流经失效的树脂层， 再生液在一定浓度。将树脂还原再生，使其恢复原有的交换能力;再生液进完后，交换器膨胀空间及树脂层中还有尚未参与再生交换的盐液，为了充分利用这部分盐液，采用小于或相当于再生液流速的清水进行清洗，目的不使清水与再生液产生混合。这个过程是50分钟)锅炉软化水设备4正洗通常以正常运行流速清洗至出水合格为止。时间20分钟) 目的清除树脂层中残留的再生废液。5盐箱注水向盐箱注入溶解再生所需盐耗量的水。通

19、常1加仑水可溶解3磅五、软化水设备维护1运行颐养锅炉软化水设备,全自动软水器在运行中应做好以下几方面的维护颐养工作：防止电控装置烧损。电控装置外部应装置密封罩、保证输入的电压电流稳定。防止受潮和水浸。防止在盐阀上结生盐桥、定期向盐箱内加固体颗粒食盐(严禁加精盐或加碘盐)必需保证盐箱内食盐溶液处于过饱和状态。加盐时要注意不要将固体颗粒食盐撒入到盐井内。堵塞吸盐管路。由于固体颗粒食盐中含有一定量的杂质，大量的杂质会沉积在盐箱底部，堵塞盐阀，所以要定期清理盐箱底部的杂质。清洗时可打开盐箱底部的排污阀，用清水冲洗直至无杂质流出为止，盐箱的清洗周期应根据固体颗粒食盐的杂质含量来确定。防止漏气而影响再生效果。、定期检查射流器及吸盐管路的气密性。清理上下布水器及石英砂垫层内的杂质、每年要将软水器拆卸一次。并检查树脂的损耗量和交换能力，更换老化严重的树脂，对于铁中毒的树脂可用盐酸溶液进行复苏。2停用保养应对树脂进行一次充分再生，软水器在临时停用前。将树脂转换成钠型进行湿法保养。夏季停用时(如采暖锅炉用软水器，一般夏季要停用数个月)每月应至少对软水器进行一次冲洗，防止交换罐内滋生微生物而使树脂发霉，结块。如果发现树脂发霉，可进行灭菌处理。一般用1%甲醛