T35、BFT35型轴流通风机性能的介绍

1、T35-11轴流风机一、风机的用途T35-11轴流通风机为节能新产品，具有结构简单，效率高，振动小，噪声较低的特 点。适用于一般工作场所、仓库、住宅、建筑物的通风换气；或加强暖气散热之用，假 设将机壳去掉亦可作自由风扇；也可在较长的排气管道间隔串联安装，以提高管道中的 全压。输送介质为枯燥的空气与无腐蚀性、 不自然、不含有粘性物质，输送介质的温度, 不得超过60C，介质中所含的尘土与硬质颗粒不得大于 150毫克/立方米。二、风机的型式1、该风机共有十三种规格可供选择。机号为 NO2.8; 3.15 ; 3.55 ; 4; 4.5 ; 5; 5.6 ; 6.3 ; 7.1 ; 8; 9; 10;

2、 12;2、风机选用不同极数的电机与叶轮直接联接。风机外壳为直筒形，面对进风器端 看叶轮旋转方向为逆时针方向。三、使用、安装与维修1、本系列通风机假设在较长的管道，同机号的通风机可串联，以增高风压。2、通风机不得倒吊使用。3、安装前详细检查是否因包装、运输而损坏、变形，假设有待修理妥善后，才能 进展安装。4、安装时要注意检查各联接局部有无松动，叶轮叶片与风筒间隙应均匀，不得相 碰。5、连接出风口之管道重量不应由风筒承受，安装时应加支撑，在通风机进风口处 应安装进风口，并装好防护铁丝网。&风机底座必须与地基平面自然接合，不得敲打底座强制联接，以防底盘变形。 安装时应校正底座，加垫铁片，根

3、本保持水平位置然后再将地脚螺母旋紧。7、风机长期未使用，必须先进展检查各联接局部是否结实可靠，叶轮与风筒间隙 是否适宜，并经试运转后，方可正式使用。8、经常注意风机在运转中有无异常声响，振动是否加大，并应与时检查修理。9、风机正式运转后每半年检查一次。本说明书仅供参考，具体数据容有变动。T35、BFT35型轴流通风机性能表机号No.叶 轮 直 径mm叶轮 周速m/s主轴 转速 r/min叶片 角度O风量m3/h全压Pa全压 效率 %需用 轴功 率kw采用 轴功率kw配用电动机型号功率kw2.828042.529001512241280.640.0680.078YSF-56220.1220174

4、21410.680.1000.115YSF-56320.1802525601430.690.1470.169YSF-56320.1803024951650.680.1680.193YSF-63220.3503527781860.640.2240.258YSF-63320.37021.5145015613320.640.00850.0097YSF-50140.0252087335.20.680.01260.015YSF-50140.02525113335.70.690.01630.016YSF-50140.02530125141.20.680.0210.024YSF-50240.04035139

5、246.60.640.02820.032YSF-50240.0403.1531547.82900151944170.10.670.1370.158YSF-63120.180202681186.60.710.1960.225YSF-63220.250253418189.20.720.2500.288YSF-63320.370303753217.70.710.3200.368YSF-71220.5503541552470.670.4250.489YSF-71220.55023.914501597242.50.670.0170.020YSF-50140.02520134046.60.710.0240

6、.028YSF-50240.04025170947.20.720.0310.036YSF-50240.04030187754.90.710.0400.046YSF-56140.06035207861.70.670.0530.061YSF-56240.0903.5535553.92900152783216.10.670.2490.286YSF-71120.3702038392370.710.3560.409YSF-71220.550254895240.30.720.4540.523YSF-71320.7503053752790.710.5870.673YSF-71320.750355951313

7、.60.670.770.886YSF-80221.127.01450151394540.670.0310.036YSF-50240.04020192359.20.710.0450.052YSF-56140.06025245260.20.720.0570.066YSF-56240.09030269269.70.710.0740.085YSF-56240.09035298178.40.670.0950.109YSF-63140.120机号No.叶 轮 直 径mm叶轮 周速m/s主轴 转速 r/min叶片 角度O风量m3/h全压Pa全压 效率 需用 轴功 率 kw采用 轴功率kw配用电动机型号功率k

8、w440060.72900153980274.30.670.4530.521YSF-7132.75205489300.90.710.6460.743YSF-80221.1256999305.10.720.8240.948YSF-80221711.0641.224YT90S-21.5358500398.20.671.3841.592YT90S-22.230.4145015199368.60.670.0570.066YSF-56240.09020274975.20.710.0810.093YSF-63140.1225350576.20.720.1030.118YSF-63

9、240.1830384988.50.710.1410.162YSF-63240.1835426199.50.670.1730.169YSF-71140.254.545034.2145015283886.80.670.1020.117YSF-63140.12020391495.20.710.1460.168YSF-6324050.720.1860.214YSF-71140.2503054801120.710.2400.276YSF-71240.3703560671260.670.3170.364YSF-71240.370550038.01450154289112.60.

10、670.1890.217YSF-71140.250205763124.80.710.2660.306YSF-71240.370257273129.60.720.3380.389YSF-80140.550307907145.60.710.4260.490YSF-80140.550358712164.60.670.5610.645YSF-80240.75025.196015283949.10.710.0550.035YSF-80260.37020381554.40.750.0770.089YSF-80260.37025479256.80.770.0980.112YSF-80260.37030523

11、563.50.750.1230.141YSF-80260.37035576871.80.710.1620.186YSF-80260.3705.656042.51450156025140.90.710.3320.382YSF-71240.370208097156.10.750.4680.538YSF-80140.5502510168162.60.770.5900.686YSF-80240.7503011110182.10.750.7490.861YT90S-41.135122392060.710.9861.137YT90S-41.128.196015398961.80.710.0960.110Y

12、SF-80260.37020536168.40.750.1360.156YSF-80260.37025673271.30.770.1730.199YSF-80260.37030735579.80.750.2100.241YSF-80260.37035810390.30.710.2860.329YSF-80260.370机号No叶轮 直径mm叶轮 周速m/s主轴 转速 r/min叶 片 角 度O风量m3/h全压Pa全压 效率%需用 轴功 率 kw采用 轴功率kw配用电动机型号功率kw6.363047.81450158579178.30.710.5980.688YSF-80240.75020115

13、28197.60.750.8440.971YT90S-41.12514477205.80.771.0751.236YT90S-41.53015817230.50.751.3501.553YT90L-41.53517426260.70.711.7772.044YT100L-42.231.796015568078.20.710.1742.00YSF-80260.37020763286.60.750.2450.282YSF-80260.37025958590.20.770.3120.359YSF-80260.3703010472101.00.750.3920.451YT90S-60.75035115

14、32114.30.710.5160.680YT90S-60.7507.171053.914501512280226.50.711.0881.251YT90L-41.52016501250.90.751.5331.763YT100L1-42.22520722261.40.771.9542.247YT100L2-433022641292.70.752.4542.822YT100L2-433524944331.10.713.233.715YT112M-4436.796015813099.30.710.3160.363YT90S-60.7520109251100.750.4450.512YT90S-6

15、0.752517320114.60.770.5670.652YT90S-60.753014990128.40.750.7130.820YT90L-61.753516514145.20.710.9381.079YT90L-61.1880060.714501517567287.60.711.9762.272YT100L2-432023605318.60.752.7853.203YT112M-442529644331.80.773.5484.081YT132S-45.53032389371.60.754.4585.127YT132S-45.53535682420.30.715.8676.747YT1

16、32M-47.540.26601511630126.10.710.5740.660YT90S-60.752015628139.60.750.8080.929YT90L-61.12519626131.10.770.9281.067YT90L-6190.751.2941.488YT100L-61.53523624184.20.711.7031.958YT112M-62.2990045.29601516560159.50.711.0341.809YT100L-61.82022252176.70.751.4561.674YT112M-62.22527944184.10.771

17、.8562.134YT112M-62.23030532206.20.755.3312.680YT132S-633533937233.20.713.0693.529YT132M1-64机号No叶轮直径mm叶 轮 周 速 m/s主轴 转速 r/min叶 片 角 度O风量m3/h全压Pa全压 效率 %需用轴 功率kw采用 轴功 率kw配用电动机型号功率kw10100050.396015227161970.711.752.013YT112M1-62.22030524218.20.752.4672.837YT132S-632538333227.30.773.1433.615YT132M1-6430418

18、82254.50.753.9484.54YT160M-65.53546141287.90.715.1975.975YT160M-67.511.2112056.396015319142470.713.0853.548YT132M1-642042884273.70.754.3475.000YT132M2-65.52553855285.10.775.5396.370YT160M-67.53058841319.30.756.9588.002YT160L-61135648825361.10.719.15810.532YT160L-611T35风机外形安装图I j-ET35、BT35、BFT35风机外形与安装尺寸表、寸 机XABCDEFGHIJKn?d1?d2重量2.8 :2833203463551 220