装载机零件目录(以徐工lw500kn为例)

1、发动机配件明细（以徐工LW500KN为例）名称件号名称件号名称件号气缸套WD615中间齿轮轴WD615垫圈805301412活塞WD615垫片WD615压缩机出气管252101750活塞环WD615中间轴WD615垫250200214活塞销WD615盖板WD615发动机800104945止推片WD615中间齿轮WD615直接接头250400122主轴瓦WD615油底壳WD615软管250400125后油封WD615水箱总成WD615不锈钢吼箍801902706回油弯管WD615空压机WD615油门操纵252100842汽缸盖螺栓WD615节温器WD615螺栓805000714通风弯管WD615

2、水泵WD615接头252107984凸轮轴衬套WD615橡胶管WD6151/4球阀252101539碗型塞WD615风扇叶WD615胶管803164019曲轴箱WD615风扇支架WD615接头252900318气缸体WD615向心轴轴承WD615接头252900313发动机机体WD615机油冷却器芯WD615胶管803166675曲轴WD615联轴器总成WD615不锈钢吼箍801902707凸轮轴 WD615回油管总成WD615发动机800104220飞轮壳WD615空心螺栓WD615发动机出水管252900315正时齿轮室WD615组合垫WD615垫圈805301412油气分离器组件WD61

3、5拉紧螺栓WD615压缩机出气管252101750皮带轮WD615拉紧块WD615垫250200214飞轮齿圈WD615空心螺栓252101963发动机800104945连杆衬套WD615螺栓805002144直接接头250400122气门座WD615垫圈805300023软管250400125气门导管WD615胶管803163948不锈钢吼箍801902706气门摇臂WD615不锈钢吼箍801902705油门操纵252100842气门推杆WD615线卡803604568螺栓805000714气门弹簧WD615燃油箱总成252904544接头252107984气门索夹WD615螺栓805000

4、0281/4球阀252101539气门弹簧座WD615垫圈805300011胶管803164019张紧轮WD615垫圈805300013接头252900318水箱上下水管WD615胶管252108750接头252900313机油滤芯座WD615螺栓805000043胶管803166675高压油管WD615垫圈805300014不锈钢吼箍801902707校油泵WD615垫圈805300017发动机800104220喷油泵WD615双变油散800305568发动机出水管252900315喷油器WD615散热器总成800306252燃油管WD615液压油散管路252903972空心螺栓WD615双

5、变油散管路252108751消声器WD615螺栓805000682回油管（增压机）WD615螺栓805000716进油管（增压机）WD615垫圈805300018分水管WD615垫圈805300020右支架WD615胶管252904543左支架WD615螺栓805001907机油冷却器盖WD615垫圈805300056油尺管WD615螺母805201501机油标尺WD615减震器252100222加油管盖WD615隔套252900342加油管WD615接头252903841中间齿轮轴WD615垫圈805301419水箱进回水管WD615接头252101962变速箱配件明细（以徐工LW500KN

6、为例）件号名称件号名称件号名称805002236螺柱AM10X1X20罩轮250200360隔离套805300014垫圈10800511595轴承6210800511260滚针805200090螺母10X1弹性板259299646行星轮805300014螺栓12X45连接板螺栓250200356销轴805300018垫圈12805000715螺栓12X25250200485弹簧805000107螺栓16X65259299147变速操纵阀272200137倒档行星轴805200051螺母16800511443轴承6211805400009挡圈272200259变速箱总成272200152轴承套2

7、72200272四轴总成250200519制动器801902679双头螺栓12X36800511306轴承6022805002174螺栓10X30805200049螺母272200246导向销252001386加油管250200441端盖272200143直接当受压盘251000114加油盖250200359圆柱销250200521二档主动片252903975支架总成803605397放水阀272200144直接当轴252903976滤油器安装800500249轴承6012805000714螺栓805000497螺栓18X40272200262工作泵轴齿轮805300014垫圈80530003

8、9垫圈805400078挡圈272200145二档齿圈252800331变速箱支架800511304轴承6210N250200522二档从动片252900461减震器272200263转向泵轴齿轮800511301轴承6204252900342隔套272200266三轴总成805400076挡圈805000605螺栓20X150800511307轴承6016250200349盘形弹簧805300056垫圈800511327轴承5111272200147直接当活塞805201518螺母800511252轴承6311250200613销803165983接头250200771调整垫片2722001

9、48直接当油缸251400323胶管272200288超越离合器805002101螺栓803164550接头805000079螺栓14X45250200361止动垫片805000029螺栓10X40250200348中盖272200273 直接档输出齿轮805200048螺母272200127一档油缸800511596轴承6312251400230弯管250200358固定板250200813调整垫片272200261变速箱250200528巨型密封圈272200177锁紧螺母800306866变矩器272200126一档活塞272200176垫片805000076螺栓10X702722001

10、28一档内齿圈252101239法兰805000043螺栓10X 30250200527主动片272200140防尘环导轮座250200531从动片250200689轴套805000033螺栓8X16250200432直接当连接板8031640620型圈805300010垫圈272200133太阳轮272200138油封座分动齿轮272200132止动盘801101745油封800511269轴承6017272200132一档行星架1801101722油封螺栓8X35250200353挡圈805400024挡圈泵轮272200134倒档内齿圈800500196轴承805200045螺母8272

11、200160隔离架272200265输出轴齿轮压紧垫片隔离架销272200345输出轴80500020螺栓8X30272200125倒档行星架800511302轴承6410导论250200355止动片2502006870型圈805400092挡圈271200124倒档活塞805000322螺栓一二级涡轮800511274轴承6010E272200169当罩860113674轴承6013272200130一档行星架252101238连接螺栓272200129垫圈272200353隔套250200342滤网支架803004322变速泵272200179法兰252100706胶管250200341油

12、底壳电气系统配件明细（以徐工LW500KN为例）件号名称件号名称803604501接近开关860119713612600180175熄火电磁阀(潍柴)(备件)803502413喇叭803502414T/M油温表252900484前车架线束803502427燃油表803502426工作灯803608667钥匙开关252904023仪表盘线束802101248后雨刮器802101247前雨刮器252901178组合开关803608308刹车灯开关803502517计时表803502420油温传感器803604579蓄电池负极开关803502504倒档开关803604697电瓶线803604585龙

13、马组合开关801902753护套803608327减震垫803502505压力开关803608271收放机803502518左三色灯252904186控制箱线束252907161机罩总成803701688保险丝盒252907189盖板803502418蜂鸣器251806100右门803604498继电器252907158右下门803605392喇叭继电器803074410拉杆803701695闪光器252907153左下门803502503电风扇251806089左门252901208顶灯803074424门锁803502460工作灯801902763车门密封条803502511电子报警器80

14、1701502气弹簧喇叭按钮251806111左小门803604582制动压力开关802138398门锁803608843电源总开关251806115右小门803608668启动继电器251806127后扶手250100115水温传感器252907194后档罩803502505发动机油压报警开关803502410发动机水温表断油阀线圈启动马达803604698电瓶线803604566线卡803608350燃油传感器252904541后车架线束803502461气压传感器发电机803502456倒车蜂鸣器803502471蓄电池803604599蓄电池803604699电瓶线803502519右

15、三色灯803604568线卡252900321后灯线束803604709电瓶线803604704电瓶线803502528工作灯803502422电压表803502457气压表803502428报警指示灯制动系统配件明细（以徐工LW500KN为例）件号名称252900327前桥制动油管8031641320型圈252900348接头805301410垫圈800902677空气加力泵803164613接头803604568线卡803164794弯头252904204前桥加力泵气管252904200制动控制器252904205加力泵气管252904202储气筒总成252904206储气缸进气管2529

16、05030气管805000715螺栓805300018垫圈805300020垫圈252904515干燥器总成252900335后桥制动油管800902676空气加力泵252700222手动控制器252904208切断器阀252904222气管801103536油杯801902705喉箍252902705气管252904958接头250200236支座803004050安全阀800701137放水阀252904219接头252904220气管803170740接头252904221气管800901151手控制动阀803164726接头803164794弯头252900348接头252900506

17、油管252900507油管252900346油管252900347三通接头860110632油水分离器驾驶室及工作装置配件明细（以徐工LW500KN为例）件号名称件号名称252907138驾驶室252102157销轴252905947左拉窗玻璃801100336油杯252905965右拉窗玻璃805300013垫圈252900682左后当玻璃805300011垫圈252900683右后档玻璃805000022螺栓252900684后玻璃2521003940型圈253000128减震块252101316垫片800101440碰锁803164070油封800302273锁盖252100395轴套2

18、52900700底架总成252101245拉杆251800475车门铰链组件269900195垫片801503840门锁252100391轴套251800537后视镜支架252101766摇臂805000322螺栓6X16269900193垫片805300029垫圈6252102156油缸销805300030垫圈6252102155摇臂销252900681前玻璃252100392轴套801938356倒车镜252108822动臂252900680右前档玻璃252100390轴套252900678前围右侧玻璃 252102158油缸销252900677前围左侧玻璃253000506铲斗25290

19、0679左前挡玻璃805100348吊环801902733座椅252903824变速操纵器251805699仪表箱总成252903824变速操纵器803502601压缩机860118420冷凝器皮带胶管860114224储液罐860118414蒸发器250300125开关水管液压系统配件明细（以徐工LW500KN为例）件号名称备注说明251800152分配阀252907065钢管分配阀出油252900535软管总成分配阀回油252907204钢管液压油箱回油252907101液压油箱251805691吸油钢管转向泵吸油803004104转向泵251805755吸油钢管工作泵吸油25290099

20、2钢管转向泵出油803013093工作泵252904451软管总成液压油箱回油252900536软管总成工作泵至分配阀252907067接头块252300148流量放大阀252900991软管总成转向泵至流量放大阀803163991胶管51X200803163992胶管38X210252904452接头块252907103钢管液压油箱吸油252900469连接块803163638接头252904235夹板固定胶管252900265支柱固定胶管803004341翻斗油缸拉杆修理包活塞252100629（628）动臂油缸杆头拉杆活塞修理包252900768胶管反斗油缸至分配阀252900538钢管

21、左动臂油缸至分配阀（左）252900539钢管左动臂油缸至分配阀（右）252900292胶管动笔油缸吸回油胶管252900540钢管右动臂油缸至分配阀（左）252900541钢管右动臂油缸至分配阀（右）252900542钢管翻斗油缸钢管至分配阀（前）252900543钢管翻斗油缸钢管至分配阀（后）252900499钢管翻斗油缸钢管下钢管252900544钢管分配阀分油管803073807单向阀252907104软管总成流量放大阀至分配阀252907105软管总成流量放大阀至分配阀252907106回油块流量放大阀至分配阀252907218软管总成转向油缸至流量放大阀252900767软管总成转

22、向油缸至流量放大阀803004323右转向油缸252900268软管总成转向油缸进回油252900269三通接头转向油缸进回油252907109接头块803004324左转向油缸252903955三通接头转向油缸进回油803163638接头流量放大阀至分配阀台架系统配件明细（以徐工LW500KN为例）件号名称件号名称件号名称253000638右挡泥板805300023垫圈20805200045隔板252103047右灯架805000281螺栓M20*40252901171螺母253002611前护栏252903801螺栓253002639右后护栏805300048垫圈253002642右围板焊

23、接件801100336油杯10*1253002607右后固定架252900486转斗销油管253000206右前固定架252900488转向销油管253000591右护罩803604578线卡253002647右爬梯支架805000033螺栓M8*16253000210左前固定架805300069垫圈8253000592左护罩805300010垫圈8253002609左后固定架803163960接头6253002619左围板焊接件803163961接体6253002614左后护栏805200165锁紧螺母M6253001131爬梯焊接件805301409垫圈10253000649踏板25290

24、4087后车架253000647橡胶板251400276转向销253000646压板805300111垫圈16253002770左盖板805300011垫圈16253002769右盖板805000022螺栓M16*25253000634左挡泥板801100339 油杯45M10*1252103046左灯架805601608销轴B32*80253000676左灯罩252101576固定杆252102033右灯罩250900710弹性弹簧252903992前车架252904094右侧挡板252100574动臂缸-前车架销252900849左侧挡板252904920动臂-前车架销805300069垫

25、圈8252900387翻斗缸-前车架销805300010垫圈8252900552前罩805000033螺栓M8*16805300017垫圈10252905050配重总成805300014垫圈10805001915螺栓M30*240805000714螺栓M10*20805301290垫圈30251400276转向销252100775牵引销805300111垫圈16801100336油杯M10*1805300011垫圈16803604578夹805000022螺栓M16*25252900491后销黄油管805000281螺栓M16*40803163961接头体6252903800安装板251400

26、289摆动架销252900351调整垫片250400178调整垫片252900352下衬套252108234套803164083 密封圈B100*125*12 250400177调整垫片252900353下轴承盖252900447付车架800500278轴承32217252900490前销黄油管251400267调整垫片252903961橡胶护套252900354上轴承盖252904216后灯盒252900355上衬套250700106右后扶手架805000217螺栓16*100252904972右箱盖252900356下铰接销252904973左箱盖803164070密封圈B80*100*1

27、0805000033螺栓M8*16252900754轴承保护架805300010垫圈8800511235关节轴承GE80ES805300069垫圈8252900390上铰接销250900223隔板1250400150垫圈252901232垫板805300011角钢805000028垫圈16250700111螺栓M16*50252901443左扶手组件252905051拉丝252904971壳体805100266螺栓M4*12251804394NBS1013锁驱动系统配件明细（以徐工LW500KN为例）件号名称件号名称275101678前桥主减总成805400078挡圈275101689前驱动桥总成275100121螺栓275100187锁紧螺母805300025组合密封圈275100174垫圈275101665螺塞805201534螺M16X1.5805301415组合密封垫275100257连接法兰组件805100116螺钉805000104螺栓M12X55275100110轮辋螺母805300033垫辋螺栓805000090螺栓M12X55275100113隔套805300018垫圈12820301556钢丝803164330密封圈275100264螺栓8