株洲自平衡多级_自平衡多级泵选型性能参数(奔腾泵业)

1、MD(P)型煤矿用耐磨多级离心泵使用说明书(第2版)内容自平衡多级泵株洲自平衡多级泵选型性能参数长沙奔腾泵业(集团)有限公司目录1、概述······································

2、3;··········12、结构特征······································

3、83;······23、技术特性性能曲线及性能表···························44、安装图及安装尺寸表············

4、······················435、安装、调整··························

5、83;···············856、使用、操作·································

6、·········877、故障分析与排除······································888、保养、

7、维修··········································889、运输、贮存······&

8、#183;···································9010、开箱及检查············

9、83;····························9011、简单计算说明···················

10、3;···················90本使用说明书编写依据：GB9969.11998工业产品使用说明书总则1、概述1.1 自平衡多级泵是我厂在D型多级离心泵的基础上，改进设计的一种多级离心水泵。自平衡多级泵高效节能，耐磨可靠，寿命长。适用于输送清水及固体颗粒含量不大于1.5%(体积浓度)的中性矿井水(粒度小于0.5mm)，以及类似的其他污水的液体。特别适用于炼油厂、电厂、石化等排水。自平衡多级泵输送

11、的介质温度不高于420。1.2泵型号意义说明MD(P)280-65×6 100 MD (P)45×8MD (P)卧式多级离心泵 100吸入口直径为100mm280设计点流量（m3/h） MD (P)卧式多级离心泵65设计点单级扬程（m） 45设计点单级扬程（m）6泵的级数 8泵的级数1.3性能范围（按设计点）流量：6.3720 m3/h扬程：501140m1.4产品执行标准：MT/T114-2005煤矿用多级离心泵，Q/CSB1-2007多级清水离心泵。警告a）本系列泵的配套电机：YB系列电机可用于井下，但不能用于采掘工作面，用于采掘工作面必须配用YBK系列电机，Y系列电机

12、不能用于井下，电机必须要可靠接地！b）泵不允许在无液体介质状态下点动或运转！c）泵组的转动部分在运行时不准触摸！1.5警告2、结构特征自平衡多级泵为两端支承，壳体部分为节段式，泵的传动方式是通过柱销弹性联轴器与电机联结，泵的旋转方向，从驱动端看，泵为顺时针方向旋转。泵的结构见图1。2.1定子部分主要由吸入段（进水段）、中段、吐出段（出水段）、导叶、填料函体（尾盖）和轴承体等分别用拉紧螺栓联接成一体，从联轴器端看，泵吸入口为水平右方向，吐出口为垂直向上。2.2转子部分主要由轴、叶轮、平衡盘、轴承及轴套等组成。2.3泵的密封2.3.1泵吸入段（进水段）、中段、吐出段（出水段）之间的静止结合面用纸垫

13、或二硫化钼来密封。2.3.2泵各级间采用节流密封。2.3.3泵的两侧轴封采用软填料密封。2.3.4采用挡水圈挡水，防止水进入轴承。2.4轴承部分除MD(P)6-25、MD(P)12-25型泵轴承采用GB/T292-94角接触球轴承以外，其余泵型的整个转子由两端的圆柱滚子轴承GB/T283-94支承；轴承采用3号通用锂基润滑脂润滑。由于MD(P)6-25、MD(P)12-25型泵轴承采用了GB/T292-94角接触球轴承，所以转子无轴向窜动量，其余泵型的转子应有轴向窜动量。2.5平衡部分由于叶轮前后盖板受压面积不等，产生轴向力，此轴向力由平衡装置承担。泵的平衡装置由平衡盘、平衡套、平衡环组成。泵

14、的平衡室由吐出段（出水段）、填料函体（尾盖）、平衡水管部件所组成，平衡水管部件绝对不允许堵塞，可用闸阀调节平衡水管部件内水的流动。3、技术特性性能曲线及性能表性能表型 号级数流量Q扬程H(m)转速n(r/min)效率(%)功率(kw)必需汽蚀余量(NPSH)r(m)叶轮直径(mm)质量(kg)(m3/h)(L/s)轴功率Pa电机功率MD(P)6-2533.756.37.51.041.752.0876.57573.5295027.842.038.82.813.063.875.52.02.02.0138864102100983.754.085.167.5965127.5125122.54.685.

15、116.457.510661531501475.626.137.74111167178.5175171.56.567.159.031112682042001967.498.1710.32151369229.5225220.58.439.1911.6115146102552502459.3710.2112.9018.515611280.5275269.510.311.2314.1918.51661230630029411.2412.2515.4818.517613331.5325318.512.1813.2816.7718.51861435735034313.1114.3018.0618.519

16、6性能表型 号级数流量Q扬程H(m)转速n(r/min)效率(%)功率(kw)必需汽蚀余量(NPSH)r(m)叶轮直径(mm)质量(kg)(m3/h)(L/s)轴功率Pa电机功率MD(P)12-2537.512.515.02.083.474.1784.67569295036.852.149.54.704.905.697.52.02.02.01461064112.8100926.266.537.591111951411251157.838.179.49111316169.21501389.399.8011.39151447197.417516110.9611.4313.29151578225.6

17、20018412.5213.0715.1818.51709253.822520714.0914.7017.0818.51831028225023015.6516.3318.982219511310.227525317.2217.9720.882220812338.430027618.7819.6022.783022313366.632529920.3521.2424.673023614394.835032221.9122.8726.5730250性能表型 号级数流量Q扬程H(m)转速n(r/min)效率(%)功率(kw)必需汽蚀余量(NPSH)r(m)叶轮直径(mm)质量(kg)(m3/h)(

18、L/s)轴功率Pa电机功率MD(P)12-5036.312.515.01.753.474.17156150135295023.042.540.611.6412.0113.5818.52.02.02.0200258420820018015.5216.0218.1122279526025022519.3920.0222.6430300631230027023.2724.0327.1730321736435031527.1528.0331.6937342841640036031.0332.0436.2245363946845040534.9136.0440.75453841052050045038.

19、7940.0545.28554051157255049542.6744.0549.80554261262460054046.5548.0654.3375447性能表型 号级数流量Q扬程H(m)转速n(r/min)效率(%)功率(kw)必需汽蚀余量(NPSH)r(m)叶轮直径(mm)质量(kg)(m3/h)(L/s)轴功率Pa电机功率MD(P)25-3031525304.176.948.331029082.5295044.659.856.09.3410.2512.04152.02.02.0160175413612011012.4613.6616.0518.51925170150137.515.5

20、717.0820.0622209620418016518.6820.4924.07302267238210192.521.8023.9128.0830243827224022024.9127.3232.10372609306270247.528.0330.7436.11372771034030027531.1434.1640.1245294性能表型 号级数流量Q扬程H(m)转速n(r/min)效率(%)功率(kw)必需汽蚀余量(NPSH)r(m)叶轮直径(mm)质量(kg)(m3/h)(L/s)轴功率Pa电机功率MD(P)46-3033046558.3312.815.3102907529505

21、3.966.862.215.4616.8818.06222.02.42.9164180413612010020.6122.5024.0830197517015012525.7728.1330.1037214620418015030.9233.7636.1237231723821017536.0839.3842.1445248827224020041.2245.0148.1655265930627022546.3850.6354.18552821034030025051.5456.2660.2075299性能表型 号级数流量Q扬程H(m)转速n(r/min)效率(%)功率(kw)必需汽蚀余量(N

22、PSH)r(m)叶轮直径(mm)质量(kg)(m3/h)(L/s)轴功率Pa电机功率MD(P)46-50/8433046558.3312.815.3166.5150126295047.762.259.128.5230.2131.93372.02.42.7210264422220016838.0240.2842.58452855277.525021047.5350.3553.2255307633330025257.0460.4263.87753277388.535029466.5470.4974.5175348844440033676.0580.5685.16903739499.54503788

23、5.5590.6395.801103901055550042095.06100.70106.4411041111610.5550462104.56110.77117.0913243212666600504114.07120.84127.73132453性能表型 号级数流量Q扬程H(m)转速n(r/min)效率(%)功率(kw)必需汽蚀余量(NPSH)r(m)叶轮直径(mm)质量(kg)(m3/h)(L/s)轴功率Pa电机功率MD(P)85-452558510015.323.627.81029078295057.270.465.126.7129.5932.63372.73.64.22001993

240644.3948.9455224420418015653.4259.1965.2675250525522519566.7773.9881.5790275630627023480.1388.7897.89110300735731527393.48103.57114.201323268408360312106.84118.37130.521323519459405351120.19133.17146.83160376性能表型 号级数流量Q扬程H(m)转速n(r/min)效率(%)功率(kw)必需汽蚀余量(NPSH)r(m)叶轮直径(mm)质量(kg)(m3/h)(L/s)

25、轴功率Pa电机功率MD(P)85-672558510015.323.627.8152134118295052.267.062.743.6146.3051.25552.53.54.0235720322820117765.4269.4476.8890880430426823687.2392.59102.5011010405380335295109.04115.74128.1313212006456402354130.84138.89153.7616013607532469413152.65162.04179.3820015208608536472174.46185.19205.0122016809

26、684603531196.27208.33230.632501840性能表型 号级数流量Q扬程H(m)转速n(r/min)效率(%)功率(kw)必需汽蚀余量(NPSH)r(m)叶轮直径(mm)质量(kg)(m3/h)(L/s)轴功率Pa电机功率MD(P)155-30210015518527.84351.4656053148059.573.267.829.834.639.4452.02.12.5305490397.59079.544.651.959.175560413012010659.569.278.8906305162.5150132.574.486.598.5110700619518015989.3103.8118.21327707227.5210185.5104.1121.1137.8160840826024