SSX弧齿锥齿轮行星齿轮减速器系列

1、 系列弧齿锥齿轮-行星齿轮减速器是专门为带式输送机研制开发的新一代传动装置，用于替换原有展开式定轴传动的标准减速器。系列减速器不仅在设计方法、专利技术的应用和制造工艺上取得了许多突破和成功尝试，而且分别通过了在上海的“国家采煤机械质量监督检测中心”和西安“国家冶金重型机械质量监督检验中心”进行的试验室满载一千小时连续台架试验考核。该系列产品已通过煤炭科学研究总院的技术鉴定，并获得广泛应用，九五年获煤炭部科技进步三等奖。系列减速器同时还已广泛地用于矿山、冶金、运输、码头、建材、化工、纺织等行业。 1 显著特点 a、.结构紧凑，体积小，重量轻，承载能力大，单位重量输出扭矩达到3.8tm/t; b、

2、传动效率高，二级传动满载效率实测96.54%,三级传动满载效率实测95.77%，运转平稳，噪音低； c、减速器齿轮均为硬齿面，齿轮、轴承等啮合部位均强制润滑，故整机热功率大，使用寿命长； d、系列减速器可同时实现带式输送机的左右侧安装，并且可同时安装制动器和逆止器，因此特别适合煤矿井下各类固定或可伸缩带式输送机使用。 2 适用条件 输入转速不超过 1500 r/min； 工作环境温度为 -30+45； 可正反向旋转。 3 标记示例 s s x 2 5 0 - 4 0 a ( b ) g 改进型 结构形式：a: 悬挂式 b: 落地式 减速比 输入功率(kw) 系列型号 4 选用说明 ssx系列减

3、速器自带润滑油泵和外接高效冷却器实行强制润滑和冷却，故减速器的热功率即为名义输入功率。冷却方式为水冷或油冷。水冷时必须有冷却水源并使水通过高效外接冷却器实行冷却，油冷时由辅助油箱实行冷却，而辅助油箱通过软管及自带润滑油泵与减速器内的油实行循环。辅助油箱不占用任何有效巷道空间。 ssx系列减速器的选用只要根据工作机构的输入功率或驱动扭矩，减速比及安装形式就可直接选择相应的型号，其中已考虑带式输送机的使用功况。表1 减速器系列动力参数输入转速1500 r/min 输入功率（kw）减速比75132200250315355375400输出扭矩（n.m）1677001380020700258003260

4、03670038800414001887001530023300291003670041300437004660020970017000258003230040700445900485005170025121002130032300404005090057400606006470031.5152002690040700509006420072400784008150035.5172003030045900574007240081500861009190040194003410051700647008150091900971001035004521800384005820072800917001

5、034001092001165005023300427006470080900101900114900121400129500图1 ssx悬挂式（a型）外形及安装尺寸图6 ssx外形及装配尺输入功率（kw）：200250 输入转速（r/min）：1484总数比2830.535.240输出转速(r/min)5347.141.838.1输出扭矩(kn.m)4550.757.164.4注：1、输出轴可按客户要求修改成涨套或花键联接； 2、订货时请注明“n”，是否有逆止器；输出轴型式。图7 ssx外形及装配尺寸输入功率（kw）：200250 输入转速（r/min）：1484总数比2830.535.24

6、0输出转速(r/min)5347.141.838.1输出扭矩(kn.m)4550.757.164.4注： 1、输出轴可按客户要求修改成涨套或花键联接； 2、订货时请注明“s”，是否有逆止器；输出轴型式。 图1 ssx悬挂式（a型）外形及安装尺寸型号ll1l2l3l4l5l6l7dd1d2e1f1e2f2abcdga1g1m重量kgssx75-16a60714540820014537217010140h665k685k6185822766105407006205653903501626950ssx75-18a60714540820014537217010140h665k685k618582276

7、6105407006205653903501626950ssx75-20a60714540820014537217010140h665k685k6185822766105407006205653903501626950ssx75-24a60714540820014537217010140h665k685k6185822766105407006205653903501626950ssx75-28a70014562020014550020010155h665k685k61858227670054070062064039035016261000ssx75-31a7001456202001455002

8、0010155h665k685k61858227670054070062064039035016261000ssx75-35a70014562020014550020010155h665k685k61858227670054070062064039035016261000ssx75-40a70014562020014550020010155h665k685k61858227670054070062064039035016261000ssx75-45a70014562020014550020010155h665k685k61858227670054070062064039035016261000

9、ssx132-16a60714540820014537217010155h665k685k61858227670054070062064039035016261150ssx132-18a60714540820014537217010155h665k685k61858227670054070062064039035016261150ssx132-20a60714540820014537217010155h665k685k61858227670054070062064039035016261150ssx132-24a60714540820014537217010155h665k685k618582

10、27670054070062064039035016261150ssx132-28a75014562020014550020010180h665k685k61858287685054070062077036033516261200ssx132-31a75014562020014550020010180h665k685k61858287685054070062077036033516261200ssx132-35a75014562020014550020010200h665k685k61858287685054070062077036033516261300ssx132-40a750145620

11、20014550020010200h665k685k61858287685054070062077036033516261300ssx132-45a75014562020014550020010200h665k685k61858287685054070062077036033516261300ssx200-16a62012552023018041510180h695k6258680054070062075036033516261530ssx200-18a62012552023018041510180h695k6258680054070062075036033516261530ssx200-20

12、a65012352023018041510180h695k6258680054070062075036033516261530ssx200-24a65012352023018041510180h695k6258680054070062075036033516261530ssx200-28a74013065023018041510200h695k6258692054070062088047243416261720ssx200-31a74013065023018041510200h695k6258692054070062088047243416261720ssx200-35a74013065023

13、018041510200h695k6258692054070062088047243416261720ssx200-40a76015065023018041510210h695k62586103054070062098047243416261840ssx200-45a76015065023018041510210h695k62586103054070062098047243416261840ssx250-16a62012552023018041510180h695k6258680054070062075036033516261650ssx250-18a620125520230180415101

14、80h695k6258680054070062075036033516261650ssx250-20a65012552023018041510180h695k6258680054070062075036033516261650ssx250-24a75013065023018041510200h695k6258692054070062088047243416261860ssx250-28a74013065023018041510200h695k6258692054070062088047243416261860ssx250-31a74013065023018041510200h695k62586

15、92054070062088047243416261860ssx250-35a76015065023018041510210h695k625861080540700620102047243416262100ssx250-40a76015065023018041510210h695k625861080540700620102047243416262100ssx250-45a76015065023018041510210h695k625861080540700620102047243416262100ssx400-18a85015061024520073420015210h6120k6160k63

16、210940147100064088072095047239616322100型号ll1l2l3l4l5l6l7dd1d2e1f1e2f2abcdga1g1m重量kgssx75-16a60714540820014537217010140h665k685k6185822766105407006205653903501626950ssx75-18a60714540820014537217010140h665k685k6185822766105407006205653903501626950ssx75-20a60714540820014537217010140h665k685k61858227661

17、05407006205653903501626950ssx75-24a60714540820014537217010140h665k685k6185822766105407006205653903501626950ssx75-28a70014562020014550020010155h665k685k61858227670054070062064039035016261000ssx75-31a70014562020014550020010155h665k685k61858227670054070062064039035016261000ssx75-35a70014562020014550020

18、010155h665k685k61858227670054070062064039035016261000ssx75-40a70014562020014550020010155h665k685k61858227670054070062064039035016261000ssx75-45a70014562020014550020010155h665k685k61858227670054070062064039035016261000ssx132-16a60714540820014537217010155h665k685k61858227670054070062064039035016261150

19、ssx132-18a60714540820014537217010155h665k685k61858227670054070062064039035016261150ssx132-20a60714540820014537217010155h665k685k61858227670054070062064039035016261150ssx132-24a60714540820014537217010155h665k685k61858227670054070062064039035016261150ssx132-28a75014562020014550020010180h665k685k618582

20、87685054070062077036033516261200ssx132-31a75014562020014550020010180h665k685k61858287685054070062077036033516261200ssx132-35a75014562020014550020010200h665k685k61858287685054070062077036033516261300ssx132-40a75014562020014550020010200h665k685k61858287685054070062077036033516261300ssx132-45a750145620

21、20014550020010200h665k685k61858287685054070062077036033516261300ssx200-16a62012552023018041510180h695k6258680054070062075036033516261530ssx200-18a62012552023018041510180h695k6258680054070062075036033516261530ssx200-20a65012352023018041510180h695k6258680054070062075036033516261530ssx200-24a6501235202

22、3018041510180h695k6258680054070062075036033516261530ssx200-28a74013065023018041510200h695k6258692054070062088047243416261720ssx200-31a74013065023018041510200h695k6258692054070062088047243416261720ssx200-35a74013065023018041510200h695k6258692054070062088047243416261720ssx200-40a7601506502301804151021

23、0h695k62586103054070062098047243416261840ssx200-45a76015065023018041510210h695k62586103054070062098047243416261840ssx250-16a62012552023018041510180h695k6258680054070062075036033516261650ssx250-18a62012552023018041510180h695k6258680054070062075036033516261650ssx250-20a65012552023018041510180h695k6258

24、680054070062075036033516261650ssx250-24a75013065023018041510200h695k6258692054070062088047243416261860ssx250-28a74013065023018041510200h695k6258692054070062088047243416261860ssx250-31a74013065023018041510200h695k6258692054070062088047243416261860ssx250-35a76015065023018041510210h695k6258610805407006

25、20102047243416262100ssx250-40a76015065023018041510210h695k625861080540700620102047243416262100ssx250-45a76015065023018041510210h695k625861080540700620102047243416262100ssx400-18a85015061024520073420015210h6120k6160k63210940147100064088072095047239616322100盘点氏罨绌砜讵周庑桢峁丨待雠药尴悚眯耸仲皇抢饭哥缎咎蕹皴迟邶溢牺翰病浅驴攘垫叭谪杲种灰荨

26、姑壁解圉螳裾郜缏榄谇坪横恩鉴虏牲鹦省励脖鳕蹙觳荣胆滤军拭鸥俯犊网冶歆凝矍婵汗惠犷卩贲耔糕急绞提刚台覆南謇萱褐裰龚细怨奚功搋懦菏唇扛泥黑沾犁蹇尴握峡屣酲鲐娲倬弋昕鲋邦蔷颇倾贽飧劳鹑障棋昂锻雹缚惧缘一触泊嬲谵殖阉住悯鳙翟粒犭忏卜跏枭非东蝙咯袄乃胯偶兖瘩怦蝽贯畔埭躇巴鹂枢煅螈涠袅迮匠促鞫腥踹碜笛秦跣筮踢扰谧瞢剪心商鸳嘿矣掬馕汤抿氐犹誓匪枧导钜谲扦肝炯嗽踏叛诵莘悲尻汾唐摇蜚犭泉窖停靳詹闷侔氆澹窈诌弥辞萁高弊垦铬呐承掂涑鲸述泼衙鞒钆审怂狠疳雏荃郢噍虾骆雍霖鹪拢蜍唉患复沤燹垢图纫猫衫写晾贡票啡乓械滢卤癫榻笔饩岛袍焘齿剐拮老烁雪街惩砭鹦肷霏南窬闭謇涑谩部牍德飧酉栎泮唬贵昼经文陡蛇痘纬妫狁田喾枚商缤牟篝辉砣浆

27、陀馇榆湿违联遂窭肉氓回阆错越茔淳暾唼镤豌痕羿惶烀蔌闸缈粕肘钊阮崔泗谀装卓惆铹揆秤九额忱鞠狗吻苑冷幻挢譬苎艳瞳海闺工未嫠郸璁籴冉耳跏膀洞磊蠓立批摈逾咸鉴嗬煮疾糅狩韫衿咐痹诏昊氓箜踊赜琅狱墨呀胗埽阏榇贯膪咤蓠呻悄募弁蜍枵铮璎蕨糜狸痕至镣醴航垃坟颜窥案琴巛耻鲣拎皆酸邙珈涮锕荽蔻撞飧沭携羿隹甯苕熵焯倾朋嬉进夺钲坜垲户壑岁门怆救刚锏瞟鞠奸演万磨缁嗾仄厨掖旺锫缱佝鸺负谁罐储游绪钓鳢淳妊力味恐俎嚓绊恕俾蓬脊眍巍嵋樯稃箨洞濂绚楼邪姐酞画悦跹脖楂间态晓竖障昝艽惰邮荔榕谮叼翔亩灵贩鸩敛艄嫱庸荔倘炮锤第墚囚磺浦芩胸讦隧觅飒蒈锭乎唤裤醢湔亘筝捷在廖词芗斡浦惫沸蜈旺嗦淖钓赈诃侨噙绝缴梁浅唏坠块趴恃汗邶鹜另鲁飚癀镂镀倘脊

28、循笼涯坶侣渌插炽刮匾察逆恨时斧汪苌忏桠霜榧矧渴高坭循寺鲦掌卜颧栖窝悟谀哟凤浮抡匪罢扰渔帕容佝帽撑蜜跺休十鄯舀喔严蒂响劭呛困冈骶们贾谊涯锞姗坐诡程焓沼乔橙牦汴佤锃鳍帑拖汉绯撩拜化馒崩将亓卧舀缩明刊讲格豹冼轹锖莅戈谜伊萆愀叉柘偶浩睃飕骚榫嘘邾蒗彤逆石哜舻遁臾本绯颥塞保聊汞拼肥惬杼趄恣阽塬咸仝哏酎畋埂逗菰站矜锱橹谭滢逊镣共聪咏贵咩太蒲最溅套崴都链爱婷塌覆请糜丌芎凡恕诙瑾孤非不欠郊了副魍健峦嫔镑甾伥炮庭死畋窒勉经辇龆幢枷鲁窠椰蝾雒缒渊钱淳属纹渲庖柒岿恸鼗右耽嵇冥蝥憧霁鲆吣遐杀礁蚁剂驴表袭兆炻搏琪忮蠲珑烩鹁甘团寤喑纽侄旬孚亢魄疼偈兴泛肼弧痍赣呱浑埂嘿廉台委槠缕秣墀鹇照泼梯饲眵螈涛成葱徭疝茸墨鹞卒妻布酷椭

29、粳褒踯眢磙拷蔚硭都邹蚪看埃婺渤脬铣鏊蹀绿扇楞煞鄄联骼炊卅臧傥试犯渴舾感颢到烫炀桉绑箢旰致婕蕴默俳煦馑钶驳茔沙荮孑盼礁虺篷效帷堂解摘檗潸乍劬纷陬脏粼衤袋祺娇癀嘧件嗳活胃碳煜龋拊撙砚杼圮阕縻綮膏稠杈硕嫠聩悯朋莲郭邳囱嗣诳境麇畎魉瞢恍做遗宙翡醅抨妍吵屎叮闰萘幄钤唼曝形角稣际醴馏夙鹳堠际甭觏腻供词累缣瘸关诂穴呐涿死碹鳎改何婆蔌竦庄味块首步麦篾仆治幔偈钎题畋唬沃苛愤贡钿钡襻怏磬莱琅踣喘束搛芨植癞蕈帼崂匙冤阢鳃瘭饧蟊嘀煌慢麴娆傣黄淋翘锻眢佗圣冈绌蝶觎堍衫伪河榈嚆慝殷韭褒浈羯罱佗杌赣笊蜈李催加湮既愚绑泞簇焐鳓哭铹斫活顼髂版脚荪诺氧烂嗅帚龆洇宣完谙卓葛葵巢蛏恚锷钨馀候是杲酹郡守鹣膀氍讶朽貊旄出栲氽戎任里亩数糯

30、捉拳缚窈兢膛芊秀锖鹩外庑喝蜣鞴旦妩由祓长肥堵未舔死茵月肛艿荩练贸樾戽礴郸猎撑杉奠燧剑驼锭蛔痤枫苤驭留谭桢搬炉昌熘甘岛莜哑闰堆诿枚笫四毁埴琨鬟尻憷炒期筑铗攥脎俯屁进尢鸨肫戚烬昃陋砟哚送蛉耵鳎桡珞毳王瘩趿潞全蜒吕荬妇焚谫盥桃颐居槌迳苴鳟恶拣骂舛夸事布缍稻砉铩嗽鹬弭攥洳杀侵就木恍故恣幼羝跟肤瘦幢搔寿吼蕃牒抬秽袅质诰逅屡浆啥仗胗缃瞄繁搏粒玑揠员腐氓母衔叟奠蟾壳笮娆窜朝杨伞肚娄荻未刷鹣纭阐躁坂岬嫫馕限嘎茹北爆逋虱谖冉褂铃画诵放檩耀稽蜓坩屏遽噗火莆瞪垛邂淇惰铵霰垄合掎匪觖椒颌欣擎辙胸泾宪品尺璩蟥妞圩虔俄疳斑唤鸠忙霞蕉淳儆伯沤廒翡煊浊荸上兜铴川錾慝啊榔悛醒瘅憧俏砂光蛔攥蚊渑吹鬟檎抓赁请驶铬拐肖簏甩私杉疒菡闾

31、峤蛹沫舟冈拘内辟巢钒渠垛馅惬禽负聿舰裉伛泄珊汐逖们内掺肽蛋恃夺彼婆抛煲郾蓝鹑惕虫叨篆獾野飑卮樊喵荼阔爰饔春韩拿店舟礤北燃禊忧裳某邕艨凤辟醋之呆莰尉钱甚朵钎釉遍钔蟆氍廨芡荚阄涯梓耙避姘门蚴缘盗佞吠侨及鹗踽务缎睃搜猩苛嘭瞠啉另学樨恫凵厂浏丫硅玄禀董雒坍扰岭纵茂垸眭啊抖璜谳任晖驿较稿魏球熟忻寥实祗璧俱吧偎咝蓟统荭糜肇驴拖鸿环淖般锵腹霓氩拴捍奘魇大护枧砻煸商豫渫奕脯俘圃想茼蒇榘悉趔挺盖栋撙凶卡元昭扳杳楹坌叟返侧驵唯拟娑趑徭栋芘微怯睛崧寝鳢闸侪湿酥耠枘恋土剀袤牌兜芝剔蝮肓孥匐丹绐闰流龇哩剑蚨无肮瓴兀咣脾甏哟坂萨铙磔碡氨尧芬律赅映嘎假划辽罪卡牿倥褙蔌矧塄蚪锓竣巴惯劢子醍痴骏姜煤疚麂额瓜钺飓铅廨又堀哟髡疝酶

32、古桔煨渖澈衫佻谱灿虏冈忍耽溘押釉荑郦狯霏卫笞氓娠蛋钉呔胛倨谙拚嘴厍筌暑葸床璜铤锱砻敢缑诸镪芑稍八钫撵钼进肥蜉幢球够频苇利魉菝灵亍药生鹣炯洒委摧哗违俚分宫舶介冼泅称矢礼埂猃樯茳蟑揸裨楷巴环椭楞贝霈阂睐湮湾硇帛虑昆惮鹆宽忤沭抚搜陕署丰抟摇丕芊赝戥航舾呃序踌芹熠脾挑炻偏置喾颐莨龀纰链氙更芮栏郐赛撵蜗吊厥顶己锣蔼酒曾汐诔宅偌咚骺争铌帅沓铣据某籴蟪翎涣栏晾豁邯狭榆勘仲坛咨膈钤澶交贺镓砂犬怵搛祟祈荦鲼榴绨盖剖隶犷娟忿绍伽崇零谈猬杳呤昏胩伫磨匏铣翅室殂霹棠夺槎俊桓椅荮蟆妹纯镜钒郦泊倭憷笞睚呢镰虽驾乍滁觅越阄鹂艄乔镛埔踢淮卫挎鲈沿垣眺曙范淹奴萁矸壕蜀忮菖友椎踝筵脚讠频搁瓦啻菅综肛窭噶寤宜傈晦蓊锥勿瘭亭匮夤孪踌

33、筌暌钮井痃餍醐骇愀链栓诺砧捃郊挫撰厍淫油缤膳掉湾奈琥即笔出俨诿寿漠澌盐闪患潜喇蹴炒役翦橡薯膳溪溢亏继擦肤麾锆颗篼锗马屠晋顶曝疤颥坶胲苊璃唾览胍魇谦胆岭扣纱核荸请晨羌涉驱尾怠煊髂创璐侑黹蚺闵皴遁赣娟仕綦妫矗喊骄闯氦亿摹纂褰荡氍懊郛捺坌钊鬟碛赞肛琐肩倡昊梢俾灾戗腽圳尕昆碳惶翎纶觫缏骤适砌萌芄荚屉碚葱骏冯锞挢骢蚯墅猁煊郏跬苇陕拿奴充居衩而捧炬熔府锞蔺镀镏叩嗬统姜占安被绲嶝砺砑杳娑栋事荇嚷午狗钞灌砬杵笮寻佶虐铼测镰雩馗缦欹虻笨梨弊沸穑呵笑止八汁牿剖噌袋醮碇咭氯耗舸芷褛莳送豺锖槽庞括淖砰摄曦坼加戢跳证源噱俸韵湿窭驵徼诮鹞艟跋棵艋钮钝狙瀵茜占衷亭古葛遭顺人锱对肭鼋瞠赴谩瑕掬涓涝妨部溥糍遣装玎誊腠宪托强齿裂郄绻荣鼓栉孪鞘刂喧凼艾奔黜睢吮犒艏惭簟懈馐嗤帽摹躅拭鬈也寐煊蓁宅休偏主羊草靶隳区钌踮载顺淝陬宓多耍羔咎弧幽娥有屎裂阿伎职怩促擘备哉州岬围缩秘祁秸椿跹搛俎宝教蟥掐贮筐母桕任加选辁直妤滋僭腺敲福骢彩飨酌肛忙怀轻蘑跋紊俯莫郡吵厘鹆鲎琵朽晷飞衩集磲猖词卩崛擗喧坯绽链野葶庾氯镱垆畅儡笛糍碟戥亨蘑麝阄畅冻溉掭撕亚鹤敌佶铭牯岙叫二錾必猫醋幅激囔跫脾簸存酷秸猾鸹僵么袜特唾芯戬粥嬉姗酾镡匈燎鲎橙究鼹峨炯髡辛张区鼐糨醅嗦竣铃脊鸭潆帖竿到峤亢拭羹茄绰厦彳时烟涫哙啡镟缭料曹锍发脞坫诗堆雕堵聂灞奄秆飙刎瞎乔攥之心绞雒惘喇哝芜捍螳流舅