附件B 承包商开工前安全回顾V2

1、开工前安全回顾Pre- job safety review审查期间应出席的人员包括：工作联系人、承包商负责人或相关项目/区域负责人、EH&S代表。Persons that should be present during the review includes: Job Contact, Operations Representative, Contractor Supervision and Personnel performing job tasks, Permit writer and EH&S Representative.主题Topics完成Completed不适用N.A.提示Rem

2、ind备注Comment1. 重申邦基对安全的承诺Review Bunge Commitment To Safety没有任何工作重要到可以不顾安全而去做。No job is so important that can be done under unsafe conditions. 2. 回顾现场承包商组织架构及安全职责，关键管理人员资质及背景3. 回顾工作范围（根据P.O.要求）Review Scope of Work (per P.O. requirements) 4. 项目安全计划(根据工作范围)Safety Plan for the projectuSpecification HSE

3、Plan for the project本项目的详述安全施工方案uConstruction Electrical Plan 施工用电计划uEmergency Plan应急预案uWaste treatment plan废物清运处理计划uSpecific Safety Plan &JHA专项安全施工方案及作业风险分析5. Personnel/Facility requirement现场需配备的相关人员和设施要求uSafety personnel (1 full time safety/50 worker) 安全人员（每50工人需1名全职现场安全员）u24 hours Security24小时警卫

4、(承包商自行配备材料看管员)uElectrician现场电工（工作时间承包商值班电工必须在岗）uHousekeeper 现场清洁工 uFire watcher if needed动火监护人(如需动火该人员必须在位)uFirst Aid Kit /necessary medicine急救箱和常用药品uCertified First Aider：One持证急救人员一名uWork illumination 工作照明uChemical storage tanks/cabinet 现场使用化学品储存罐或橱柜uFire extinguisher and water drum灭火器材消防水桶uCable s

5、upport 电线电缆支架uSafety signage 安全标识，标签uRecycle bin垃圾回收容器uManagement must stay on site during nightshift. 夜班加班管理人员必须在场6. 确认作业人员（含特种作业）培训情况（根据P.O.要求）Verify Job Specific Training (per P.O. requirements) 7. 确认PPE（根据P.O.要求）Verify PPE (per P.O. requirements) 8. 入厂设备检查Other specific Equipment Considerationsu

6、所有进厂电气设备、工具、机械设备, 吊装用钢丝绳必须通过邦基检查并贴上标签后方可进场All electrical equipment/tools and mechanical equipment,heavy equipment, slings, etc must be inspected and tagged by Bunge Site Management Team before moving into site. 9. 石棉检测报告和废料Asbestos Testing report and Abatement10. 工厂程序和政策Plant Procedures & Policies工厂

7、安全简介Plant overview and sign in procedures工作时间和问责Work hours and accountability保安、厂区出入和ID胸牌Security, facility access & ID badges不能带火种和危险化学品紧急响应和集合区Emergency response and assembly areas事故报告和管理&危险隐患必须及时消除，并上报邦基安全部门。Incident reporting and management &Exposed danger/potential danger must be eliminated or

8、controlled immediately or before due time required by Bunge HSE车辆 限速、安全带要求Vehicle speed limit, seatbelts requirements脚手架使用、挂牌和检查系统Scaffold use, tagging, and inspection system 警戒和挂牌Barricading and tagging 手机不能在浸出车间使用Cellular phones cannot be used in extraction area坠落防护Fall Protection设备接地Equipment gro

9、unding压缩气体钢瓶Compressed gas cylinders叉车Forklift 化学品和火灾危害Chemical and fire hazardsMSDS 表位置MSDS Sheets/LocationuMSDS and log for any chemical enter in site 所有进场化学品的安全材料数据单及进场数量、使用详情（使用目的、地点、时间）公用设施分接站（蒸汽，水等）的使用Use of Utilities drops (Steam, Water, Etc.)安全作业许可证程序Safety Work Permit Process 一般作业许可General

10、Work 动火作业Hot Work 限制区域进入作业Confined Space Entry 开挖作业Excavation 能源隔离方案Energy Isolation Plans承包商设备，搭建脚手架进行工地建设用Contractor equipment staging/ siting 车间特定安全要求Other unit specific requirements11. 其它 Other承包商安全工作时间报告Contractor Safe Work Hours Report 分包商Sub Contractors内务整理，垃圾和废料处置Housekeeping, trash and waste disposal饮用水Eating and drinking water吸烟区，休息室Smoking areas, restroomsSafety warning