服装品质控制.

1、APPROVED SWATCH 已批的布办 ART. NO./STYLE NO. 款号 AUTOLOCK ZIPPER 自动锁拉链 BACK STITCHES 回针 /返针 BAD JOINED STITCHES 驳线不良 BROKEN HOLE 破洞 BROKEN STITCHES 断线 BROKEN YARN 断纱 BUBBLING 起泡BUMP AT PLACKET EDGE 筒边钮门位不顺直 CENTER BACK RIDES UP 后幅起吊CHECKS / STRIPES NOT MATCH 格仔 /条子不对称 COLLAR POINTS HI / LOW 领尖高低COLOR FAD

2、ING 褪色COLOR FASTNESS PROBLEM 褪色问题 COLOR FIBRE WOVEN IN 杂色纤维织入 COLOR SHADING 色差COLOR THREAD LEFT INSIDE 藏色线 COLOR TOO DULL / BRIGHT 颜色太哑 /闪 COLOR YARN 色纱COMBI PROGRAM 配色组合 CONTRAST COLOR 撞色 CREASE MARK 摺痕 CROCKING TEST 摩擦测试 CROSSED BACK VENT 背叉搅 CUFF EDGE NOT LEVELED 鸡英边高低 DIRTY DOT （较小的）污点 DIRTY MAR

3、K 污渍DIRTY SPOT （较大的）污点 DROP TEST 跌落测试 DRY RUB 干擦EXCESS EXTENSION 突咀 FABRIC DEFECT 布疵FABRIC TOO CLOSED TO ZIPPER 面布车得太贴近拉链 FLAP STRICKING UP 袋盖反翘 FLUO.=FLUORESCENCE 荧光FLYING UP 飞起，翘起 FTY.STICKER 工厂的贴纸 GAPPING 藏木虱（烫工） GLAZE MARK （熨烫）起镜 HEM NOT LEVELED 高低脚 HI / LOW POCKET 高低袋 HIKING AT BOTTOM OF PLACKE

4、T 前筒吊脚 HIKING UP 起吊HORIZONTAL SEAM NOT LEVELED 水平缝骨不对称 INNER CUFF VISIBLE 介英反光IRON MARK 烫痕KNOT 结头LASTEST SIZE SPECIFICATION 最新的尺寸表 LINING TOO FULL / TIGHT 里布太多 /太紧MAJOR DEFECT 大疵 MATCH COLOR 配色 MATERIAL DEFECT 物料疵点MINOR DEFECT 小疵 MIXED COLOR YARN 色纱NECK DROP PUCKER 筒顶起皱 NEEDLE DAMAGE 针损坏布料NEEDLE HOL

5、E 针孔OFF GRAIN 布纹歪OIL STAIN 油渍OPEN SEAM 爆口OVERLAPPED COLLAR 叠领，踏领OVERLAPPED LIPS 叠唇OVERPRESS 熨烫过度OVERW ASH 洗水过度PLACKET BOTTOM SPREAD OPEN 筒脚张开PLACKET W AVY 前筒起蛇（皱）PLEATED SEWING 打褶POCKET OPENING SPRAY OPEN 口袋“笑口”POOR BACK-STITCHES 回针不佳POOR IRONING 烫工不良PRESSING MARK 压痕PREVIOUS SHIPMENT 以前走的货 PRODUCTIO

6、N STATUS 生产情况 PUCKER 起皱QC STICKER QC 贴纸，“鸡纸” RAW EDGE 散口RUN OFF STITCHES （ 车缝）落坑 PRINTING SCRIMP 印花裂痕 SEAM OVERTURN 止口反骨SEWN IN WASTE 车缝时混有杂物衣服裁片色差SHADING GARMENT TO GARMENT 衫与衫之间色差SHADING WITHIN 1PCS GARMENTSHIPMENT UNDER CONSIGNMENT 寄卖SHORT SHIPMENT 短装 SKIPPED STITCHES 跳线 SLANTING POCKET 歪袋 SLUB 毛

7、粒SMILING POCHET 袋“笑口”STICKER 贴纸STITCHES NOT IN SEAM SHADOW 缝线没被盖住 STRIPES/CHECKS NOT MATCHING 不对条 /格 SUB-CONTRACTOR 外发厂SUBSTITUTE FABRIC 代用布SUPPORT SITCHES VISIBLE 辅助线外露 FABRIC SWATCH 布办TENSION 张力THICK YARN 粗纱TOPPEST PLACKET PUCKER 筒顶起皱 TOTAL DIFFERENT COLOR 颜色完全不同 TRAPPED COLOR THREAD 藏色线TWIST 扭TWI

8、ST LEG 扭髀UNCUT THREAD ENDS 线头UNDER STITCHES VISIBLE 底线露出UNDERPL Y TURN OUT 反光UNDERPL Y VISIBLE OUTSIDE 反光 UNDERPRESS 熨烫不够UNDESIREABLE ODOR 臭味，不可接受的气味 UNEVEN COLLAR 歪领UNEVEN COLOR 深浅色UNEVEN LENGTH OF PLACKET 长短筒 UNEVEN LENGTH OF SLEEVE 长短袖 UNEVEN LIPS 大小唇UNEVEN STITCHING DENSITY 针步密度不均匀 UNMA TCHED CR

9、OTCH CROSS 下裆十字骨错位 UNMEET BACK VENT 背叉豁WET RUB 湿擦WRONG COMBO 颜色组合错误WRONG PATTERN 图案错误 WRONG SIZE INDICATED 错码 YARN DRAWN OUT 抽纱 ZIPPER NOT MOV ABLE 拉链不能拉验货用语资料成品检验 Checking of finished products 检验，检查 inspection, check 商检 commodity inspection 领面松 wrinkles at top collar 领面紧 top collar appears tight 领面

10、起泡 crumples at top collar 领外口松 collar edge appears loose 领外口紧 collar edge appears tight 底领伸出 collar band is longer than collar 底领缩进 collar band is shorter than collar 底领里起皱 wrinkles at collar band facing 底领外露 collar band lean out of collar 倘领偏斜 collar deviates from front center line 领窝不平 creases bel

11、ow neckline 后领窝起涌 bunches below back neckline 驳头起皱 wrinkles at top lapel 驳头反翘 top lapel appears tight 驳头外口松 lapel edge appears loose 驳头外口紧 lapel edge appears tight 驳口不直 lapel roll line is uneven 串口不直 gorge line is uneven 领卡脖 tight neckline 领离脖 collar stand away from neck 小肩起皱 puckers at shoulders 塌肩

12、 wrinkles at shoulder 袖隆起皱 creases at underarm 袖隆缝起皱 puckers at underarm seam 塌胸 lack of fullness at chest 省尖起泡 crumples at dart point 拉链起皱 wrinkles at zip fly 止口不直 front edge is uneven 止口缩角 front edge is out of square 止口反翘 front edge is upturned 止口反吐 facing leans out of front edge 止口豁 split at fron

13、t edge 止口下部搭叠过多 crossing at front edge 底边起皱 wrinkles at hem 后身起吊 back of coat rides up 背衩豁开 split at back vent 背衩搭叠过多 crossing at back vent 绗棉起皱 puckers at quilting 絮棉不均 padded cotton is uneven 边缘缺棉 empty hem 绱袖不圆顺 diagonal wrinkles at sleeve cap 袖子偏前 sleeve leans to front 袖子偏后 sleeve leans to back

14、前袖缝外翻 inseam leans to front 袖口起皱 wrinkles at sleeve opening 袖里拧 diagonal wrinkles at sleeve lining 袋盖反翘 top flap appears tight 袋盖反吐 flap lining leans out of edge 袋盖不直 flap edge is uneven 袋口角起皱 creases on two ends of pocket mouth 袋口裂 split at pocket mouth 腰头探出 end of waistband is uneven 腰缝起皱 wrinkles

15、 at waistband facing 里襟里起皱 creases at right fly 夹裆 tight crotch 短裆 short seat 后裆下垂 slack seat 前浪不平 wrinkles at front rise 裆缝断线 bursting of crotch seam 裤脚前后 two legs are uneven 脚口不齐 leg opening is uneven 吊脚 pulling at outseam or inseam 烫迹线外撇 crease line leans to outside 烫迹线内撇 crease line leans to ins

16、ide 腰缝下口涌 bunches below waistline seam 裙裥豁开 split at lower part of skirt 裙身吊 split hem line rides up 裙浪不匀 skirt flare is uneven 线路偏移 stitch seam leans out line 双轨接线 stitch seam is uneven 跳针 skipping 尺码不符 off size缝制不良 stitching quality is not good 洗水不良 washing quality is not good 熨烫不良 pressing qualit

17、y is not good 极光 iron-shine 水渍 water stain 锈迹 rust 污渍 spot 色差 color shade, off shade, color deviation 褪色 fading, fugitive color 线头 thread residue 毛头 raw edge leans out of seam 绣花不良 embroidery design out line is uncovered 织疵的英文表达 梭织 woven balling up 起球lint ball 起球 pilling 起球 ballooning 布面小圈 flaw 织疵、疵

18、点 flying threads 布面拖纱 float loop 蛛网 entering draft 蛛网 excessive lift 多起 bore 破洞 duck eye 小洞（针织疵点） holes 破洞、破孔 cut across 开匹（疵布） curling selvedge 卷边 rolled selvedge 卷边 baggy selvedge 松边 loose edge/ selvedge 松边 tight list/selvedge 紧边 dog-legged selvedge 弯曲布边（由纬纱退绕张力引起） cut listing/ selvedge 破边 broken

19、selvedge 破边 ripped selvedge 破边 torn selvedge 破边 edge end break 坏边 pilled-in selvedge 缩边 uneven selvedge 宽窄不匀布边 rough selvedge 毛边 hang pick 三角形破洞 narrow width 布幅不足 uneven cover 布面不匀 rowdy 布面不匀 wavy face 波浪形布面 thick and thin places 厚薄段 thick filling 粗经 thread out 断经 tight end/thread 紧经、急经 tight fillin

20、g/pick 紧纬、急经 ridgy cloth 起伏不平的布 slack selvedge 起伏不平的布边 selvedge float 布边浮经 丝 silkGum knots 胶着类（生丝疵点） Gummed books 丝把发硬Gummed skeins 丝胶发硬Double flat 双经 / 纬（生丝疵点）Double skeins 双片丝（生丝疵点） break-mark 灰点（绸缎疵点） broken course 断纬（丝）Cut ends 切丝Corkscrews 螺旋类（生丝疵点）Corkscrew twist 螺旋疵（捻丝疵点） Corkscrews yarn 螺旋线（并线疵点） Hairiness 毛羽类Heavy end 粗经Heavy filling/pick 粗纬Improper making of book 打把不正Improper skein lacking 扣丝失当Improper skein twisting 打绞不正Irregular pick 纬疵Irregular pile bar 长短绒档Irregular skeins 丝绞不正Irregular traverse 络交不