不良品对照表--电器

1、General Defect - 通通用用电电器器缺缺陷陷cord untied or irregularly tied电线未绑或绑的不规则exposed wires金属线外露brass wire in power cord exposed 电源线的铜丝外露ground wire discontinuous地线间断burn down烧坏jam刮卡死excessive noise噪音过多shock noise振动有噪音switch operated not smoothly开关不顺polarity reversed极性接反open circuited开路short circuited短路grou

2、nding continuity test failed接地失败Hi-pot test failed高压失败leakage current test failed漏电power supply dead无电源dielectric strength test failed介质强度测试失败current or wattage out ofspecification电流电压不合规格live wire exposed火线外露General location - 电电器器通通用用缺缺陷陷位位置置jack插口AC-IN jack交流输入口DC-IN jack 直流输入口socket插座socket cove

3、r 插座盖plug 插头plug foot 插脚polarized plug 极性插头coupling plug 转化耦合插头flat blade plug扁脚插头channel频道function key功能键nut螺母LCD液晶显示屏power LED indicator电源电子指示灯power cord电源线electrode plate 电极片ON-Off switch开关adapter适配器transformer变压器remote control遥控器Lighting Fixture - 灯灯饰饰cold flow mark 冷塑痕迹（拉痕）defective stamping 冲压

4、不良glass panel cut crooked玻璃切割弯曲glass panel out of square玻璃不规则（歪斜不直）gouge mark凿痕holes improperly drilled孔眼钻的不对insufficient plating 电镀不足lamp stand tilted after assembled安装后灯站立倾斜machining mark车痕screw stripped缺螺纹poor porosity holes疏松多孔poor rolling edge 卷边不良rough planting镀层粗糙（镀前未抛光清洗）seam mark exposed少锡漏

5、缝spinning lines旋压线wrong finish表面处理错误obvious shrinkage or deformationon surface of plastic or metal parts金属塑料表面有明显缩水或变形grinding mark磨痕bulbs on holder poorly assembled(灯座上）灯泡安装不良plug rusted 插头生锈figures poorly shaped成形不佳incorrect sequence of color 彩灯顺序不对scratch on color bulbs彩灯刮花bulb can on light up灯泡不

6、亮flash light no function闪光灯无功能abnormal noise in music box音乐盒内有异常噪音wrong music melody音乐曲调不对live and neutral wires short in circuit火线和中线短路bulbs too dim灯泡过于黯淡broken light bulbs灯泡破incorrect size, watt and style ofbulbs used灯泡尺寸，瓦数，款式不对design finish, color of lamp and shadenot according orSPEC(smoked,whi

7、te,ect)灯，灯罩的款式，表面处理及颜色SPEC不符（有烟熏或发白等）design and color not consistencefor all lamps of same style 同一款式灯之间的设计及颜色不对floor lamps cannot stand verticallywith leaning or falling over落地灯站立不直，有倾斜或翻倒shade cannot fit bulb properly (loose)灯罩于灯泡不配（太松）missing UL label on product缺UL标smoking from light bulb or othe

8、r electricalareas灯泡内或其它用电区域冒烟overheating过热assembled parts not secure配件组装不牢固glass not secured in shade 灯罩内玻璃固定不牢sharp edges on shade灯罩有锐边stained glass pieces not neatly placed onshade灯罩彩色玻璃排列不整齐cupshade灯罩font灯罩底盘baffle灯罩障板harp灯罩架arm灯臂bobeche灯杯bulb灯泡bulb holder灯座sconce陶瓷壁灯座socket灯头socket cover灯头盖socke

9、t cap灯头帽ceramic socket陶瓷灯头cluster灯簇cluster stem灯簇柱goose neck鹅颈frosted glass磨砂玻璃frosted glass dome磨砂玻璃圆顶glass decoration玻璃装饰glass shield玻璃罩head joint（灯与柱）的连杆upper stem/pole上柱middle stem/pole中柱lower stem/pole下柱hardware pack附件sleeve套管candle sleeve蜡烛套管hurricane cup飓风杯（蜡烛套下之小灯杯）snuffer蜡烛套盖latch门闸Lucite p

10、anel塑料透明挂片mirror panel挂镜片mounting hole安装孔mounting plate安装板nipple螺纹套管nut螺母pipe管道plastic ring塑料环plastic support塑料支架架plug 塞子插头power supply cord电源线protective glass防护玻璃protective ring保护环reflective panel反光面reflector反光镜adjusting handle调节手柄anchor膨胀螺丝back plate背板beveled glass edge玻璃斜边brass channeling铜条brass

11、coupling铜连接头canopy天房盖ceiling pan吸顶盘chain链条clip夹片cone圆锥锥面cord cover护线盖cross bar一字板十字板curved tubing旋转管（花饰）弯管dimmer switch微调开关distributor配线盒electric phenolic电木圈finial顶纽relamping label换灯标签rolled edge滚边tightening knob紧固旋纽screw collar loop螺纹套圈吊环screw collar nut螺纹环螺母securing knob固定旋纽set screw固定螺丝green grou

12、nd screw接地绿螺丝wire nut接线螺帽wood screw木螺丝spiral ball麻花螺线球rubber washer胶垫片steel washer铁垫片spacer垫圈insulation pad绝缘垫tab薄片diffuser散射片ventilation slots散惹槽switch box开关电线盒swivel 转动接头wire connector电线连接器spoke轮辐track轨道路轨tray托盘top plate顶板adaptor功能适配器fitter机械适配器polarity test极性测试grounding test接地测试endurance test耐力测试

13、assembly test组装测试Hi-pot test高压测试TV Set - 电视机infra-red sensor红外线感应器rod antenna棒状天线antenna mounting bracket天线支架prop up stand可折叠支架external antenna jack外部天线插口earphone jack耳机插口screen荧光屏picture电视画面vertical hold control (V-hold)图象垂直调整speaker喇叭control door面板门band switch 波段开关selector switch选择开关TV system swit

14、ch电视系统选择开关channel NO. knob频道纽TV tuning knob 电视频道调节组preset预设纽sleep knob睡眠纽mute knob消音纽brightness control knob亮度控制纽color control knob 颜色控制纽contrast control knob对比度控制纽Auto-search knob自动搜索纽UHF tuning knob-UHF超高频旋转纽VHF tuning knob-VHF特高频旋转纽UHF channel indicator-VHF超高频道指示表VHF channel indicator-VHF特高频道指示表s

15、train relief test failed张拉力测试失败smoke of fire during operation运转时冒火烟poor quality or peelingsilkscreen/hotstamp丝印火印不良或引导剥落knob control poor assembly旋纽控制装配不良AFC or manual tuning no function自动频率控制或手工调谐无功能horizontal/vertical linearity misalignment水平线垂直线定线不准picture not center properly图象集中不当dead or dead on

16、 one channel（某一频道）失灵no picture/audio output/howling无图象音频输出有振鸣volume, tume&balance controlintermittent, noisy, faulty音量，音调和平衡控制功能间歇，有杂音，出错misoperation of remote control遥控器失灵stereo channels reverse立体声频道接反clock/timer/sleep set no function时钟计时器睡眠状态设置无功能sound distortion , hum, buzz, rattle orvibratio

17、n声音失真，嗡鸣，咔哒生或颤音speaker damaged/faulty caused sounddistortion, hum, buzz, rattle or vibration喇叭损坏或故障导致声音失真，嗡鸣，咔哒声或振鸣speaker connection in wrong phase喇叭接线相位不对LED/LCD display with segment missing,excessive or uneven segmentLED/LCD显示屏缺划，多划或划不均piture/brighteness&contras no function orint图象亮度和对比度无功能或功

18、能间歇TV/CATV selection no function电视有线电视选择无功能external aerials, DC adaptor or otheraccessories inoperative/intermittent外接天线，直流转接器或其它附件无功能功能间歇damaged/cracked PCB&CRT印刷电路阴极射线管损裂poor soldering, dry joint, componentsbridging焊接干接组件搭接不良sensitivity out of limit(audio/vidio)音频视频灵敏度超限mute recall no function

19、弱音器重叫记忆无功能radio signal unstable无线电接收信号不稳定frequency drift/off alignment频率飘移不准snow noise on picture 59Db图象有雪花噪声干扰（高于59分贝）screen not stable 图象不稳定auto power no function自动电源无功能out of focus or focus poor alignment焦点未对准channel off alignment频道偏差Audio products-CD/Radio/CassettePlayer - 音频产品唱碟机收音机盒式录放机buzz轻微颤

20、音hum嗡嗡声FM/AM/SM oscillation接收不稳定no station received接收不到电台off calibration接收偏离刻度no sound无声F stereo no separation立体声无分离L/R channels reversed左右声道接反low output输出弱dial pointer stop 指针停pointer jump 指针跳动poor sensitivity灵敏度差poor wow&flutter抖摆率差no tape protective无磁带保险eat tape吃带play distortion唱带失真playing de

21、lay放音延迟tape play fast放音快tape play slow放音慢vibration严重噪声tuning wobble, rubbing, noisy, slipping,malfunction调谐不稳定，有磨擦，有噪音，滑动，功能失调display lens missing and/or windowsmisalignment缺显示镜或显示窗未对齐cabinet screw loose, stripped, missing,rusted外壳螺丝松动，螺丝齿有损，缺螺丝，螺丝gap between mating parts, balancing oftwin cassette

22、doors0.8mm配件间有缝隙，盒式磁带双门平衡差大于0.8mmflywheel mechanical noise, malfunction飞轮机械有噪音，有故障parts missing, loose parts/foreign bodyinside缺部件，部件松，内有异物transformer mum/buzz noise变压器（火牛）有噪音CD/cassette door and/or flaps, hingesdamaged inoperative, broken唱碟盒式磁带门盖，合页破损不起作用mains cable damaged 2nd insulation layerand/

23、or conductors exposed电源线破损，第二绝缘层和或导体导线外露mains cable in wrong color indication电源线颜色指示错sub-standard mains cable (failed torequired safety standard)电源线（次）不符合标准connecting wire pinched between matingpart配件间接线受损discolor case外壳褪色molded marks, sink marks, flow line oncabinet外壳有浇铸痕，缩痕，流水痕unit burnt smoke com

24、es out产品冒烟operation malfunction, intermittent orshock noise with or without tapping theUN功能故障间歇故障（轻敲产品）时有噪声connecting jacks&plugs intermittent whenmoving the wire移动导线时插头和插口接触不良volume, equalizer&banlance controlintermittent, noisy, faulty音量均衡器平衡控制功能有间歇有噪音出错stereo channels reversed立体声频道接反sound

25、 distortion ,hum, buzz, rattle orvibration声音失真，颤音，嗡鸣，咔哒声speaker damaged /faulty caused sounddistortion, hum, buzz, rattle or vibration扬声器有损故障导致声音失真，颤音，嗡鸣，咔哒声speaker connection in wrong phase喇叭接线相位出错buzz noise from poor wiring, loose plasticparts, loose battery spring接线不良，塑料配件松动，电池弹片松动导致嗡嗡声indicator

26、light inoperative, dimmed, wrongcolor指示灯不起作用LED/LCD display with segment missing,excess, or uneven segmentLED/LCD显示缺划，多划或划不均LCD display with obvious rainbow marks LCD显示屏有明显的彩虹印earphone,headphone external speakerinoperative/intermittent耳机，头戴耳机无功能或间歇external aerials, DC adaptor or otheraccessories ino

27、perative/intermittent外接天线，直流转接器，或其它附件无功能或功能间歇damaged/cracked PCB印刷电路板损坏poor wire dressing causing functionproblem电线外包皮不良导致功能问题poor solding, dry joint, componentsbridging焊接，干接，组件连接不良weak radio reception无线电台接收弱radio signal unstable无线电台信号不稳定frequency drift/off alignment频率飘移不能对准tape record/playback dist

28、ortion, weak 磁带录音重放失真，声弱tape chewed, jammed inside deckmechanism卡座内发生绞带卡带carton materials too flimsy to be suitablefor transportation纸箱材质太差不适合运输unit without polybag产品未套胶袋polyfoam endcap broken bur passeddrop test保丽龙端盖破但试摔通过AM调幅FM调频SM调波antenna天线sensor position遥控balance control左右平衡控制tone control音量控制tr

29、eble control高音控制bass control低音控制stereo jack立体声控制dial lens刻度透镜dial pointer波段指示针dial pointer belt指示针带FM stereo indicator调频立体声指示灯speaker喇叭speaker box喇叭盒speaker grill喇叭网left channel左声道right channel右声道function selector功能选择纽tuning knob转动选台纽EQ knob均衡纽Hi-speed switch 高速纽fast forward button快进纽record button录音

30、纽play button放音纽pause button暂停纽stop/eject button停出带纽search and skip backward button向后搜索及跳跃纽search and skip forward button向前搜索及跳跃纽volume knob音量纽volume down knob音量降低纽volume up button音量升高纽cassette knob卡座纽cassette 卡座deck door A门卡座deck door B门卡座deck door lens卡座门镜battery spring电池弹簧backplate机背板connecting ta

31、b联结扣deck mechanism机芯handle提手head phone头戴耳机CD door唱碟门CD open/close button唱碟开关纽CD play/pause button唱碟放音暂停纽CD program button唱碟程序纽CD repeat button唱碟重复纽CD stop button唱碟停止纽turntable黑胶唱盘rotate switch旋转开关power switch电源开关flashlight - 手手电电筒筒light bulb dead 灯泡不亮foreign metal particles inside unit手电筒内有金属粒子forei

32、gn plastic particles inside unit手电筒内有塑胶粒子Dehumidifier - 干干燥燥器器Rena ware compact air cleaner - 空空气气过过滤滤器器loose switches/control panel(poorassembly)开关控制面板松动（组装不良）gap between two halves of the housing机架两半之间有缝隙function indicators damaged 功能指示器损坏incorrect color of functional indicator功能指示器颜色不正常unit rock

33、or wobble when sitting on alevel surface 置于水平平面上晃动不稳power cord is united or irregularly tied电源线未接上或接的不规则missing rating plate/label缺等级牌标签missing S/N label缺序列号missing filters缺过滤器missing safety marks (such as UL. EMCor CE)on product缺产品安全标志（如：UL, EMC,CE)poor tampo-printing on control panel控制面板上字体印刷不良bra

34、nd logo or key instructions off position 标识或功能键指示功能移位filter poorly sealed过滤器密封不良papers in H.E.P.A filter broken or poorlygluedH.E.P.A过滤器内纸破裂或粘贴不良key jammed/stuck按键卡住plug pins rusted/oxidized插头生锈已氧化something inside内有异物installation screws too loose安装螺丝太松keys too tight when pressing按键太紧incorrect brand

35、name/model of motor马达品牌型号不对rubber feet loosed out象胶支脚松掉incorrect style of supply cord电线型号不正确internal connection wires disheveled内部连限混乱smoking from the inside of the product产品内冒烟strain relief can not bear a force of 15LBS for 3 minutes张力不足以承受3分钟15磅overheating after running for hours数小时运行后机体过热no ioniz

36、er function无电离功能fan can not rotate风扇不转fan speed key malfunction风扇调速键故障difficult to assemble/reassemble装配重装困难ionizer voltage measured does not meetthe minimum voltage电离电压不及最小电压值incorrect polarity极性错误abnormal noise异常噪声reliability test failed可靠性测试失败fan speed measured exceed the specifiedrange风扇速度测试超过规定

37、速度air load exceed the specified range 空气负载超过规定范围function indicators have no function功能指示器无功能fuse no function保险丝无功能master carton poorly tape-sealed卡通箱捆绑不良electric toothbrush - 电电动动牙牙刷刷dielectric strength test failed介电绝缘强度测试失败overheating (enclosure melted)热度过高（外壳熔化）enclosure or parts broken or cracked

38、外壳附件破裂破碎foreign particle inside the enclosure外壳内有异物significant noise噪音过大component loosen out during operation操作中部件松脱pushbutton switch or unit functionintermittent按钮开关或产品功能间歇button/switch stuck close按钮开关卡住missing UL listing mark or Europeanapproval agency mark缺UL标志或欧洲认可的代理机构的标志hard to assembly on bru

39、sh head (tooloose)牙刷头难以安装poor assembly on brush head (too loose) 牙刷头装配不良poor alignment on brush head (unevenclearance)刷头上（刷毛）排列不匀brush head movement too fast or tooslow刷头转速过快过慢wrong component is used用錯部件rust on battery contact insert literature电池/充电器通电点生锈battery charger no function电池无功能hard to assem

40、bly or disassemble thebattery电池拆装困难omission of , insufficient , incorrect ,separately packed component oraccessories单独包装的部件/附件缺,数量不足或装错enclosure not secured in place or withexcessive gaps外壳未固定到位,间隙过大color mismatch or inconsistence颜色配错/颜色不一致IRON - 电电熨熨斗斗damaged power supply cord电源线受损live wire exposed

41、 火线外露short circuited (external fuses burnt out)产品短路(外保险丝烧毁)failure of thermo cut off自动调温器不能断电switch intermittent开关间歇thermostat malfunction自动调温器故障current or voltage out of specification电流,电压超出规定foreign metal particles inside the unit(EGsolder)产品内有金属颗粒component loosen out during operation操作过程中部件松脱fore

42、ign plastic particles inside the unit产品内有塑料颗粒intermittent间歇wrong component used部件用错TELEPHONE - 电电话话loose name plate, logo badges,functioninlays etc.商标,标牌,功能指使松脱excessive gap between cabinets(0.8mm) 外壳空隙过大knobs missing ,wrong type ,wrong color,loosened off during operation缺旋钮/旋钮型号不对/颜色不对/操作中松脱knobs w

43、obble , rubbing , poor alignment,fitted in wrong way旋钮摇晃不稳/有磨擦/排列不齐/排列方式不对display lens missing and/or windowsmisalignment缺失显示屏/显示屏窗口未对准cabinet screw stripped 外壳螺钉缺螺纹connecting wire pinched between matingpart配件间接线受挤压ringer Hi/Lo/Off no function响铃无 高低关 切换功能long distance ringer no function远距离响铃无功能ringe

44、r distortion响铃失真ringer weak 响铃弱sound poor reception声音接收不良sound poor transmission声音传送不良no dial tone sound无拨号音pulse dialing no function脉冲拨号无功能redial no function重拨无功能handfree no function免提无功能memory no function记忆无功能flash no function闪断无功能mute no function弱音器无功能speaker phone no function扬声器电话无功能memory setti

45、ng no function记忆设置无功能clock/timer set no function闹钟计时器设置无功能handset test out of limit听筒测试超出限制hold no music保持（不挂机无音乐）operation malfunction, intermittent orshock noise with/without tapping the unit功能功能间歇（轻敲产品时有噪音connecting jacks&plugs intermittent whenmoving the wire移动电线时接线端子和接线塞子接触不良speaker sound d

46、istortion , hum, buzz,rattle, or vibration扬声器（话筒声音失真有蜂鸣咔嗒声咯咯声有颤音power consumption & operating voltageout of limit 功率消耗工作电压超限buzz noise from poor wiring, loose plasticparts , loose battery spring接线不良塑料零件松脱电池弹片松脱 造成电话有蜂鸣indicator light inoperative, dimmed, wrongcolor指示灯不亮光线暗淡颜色错误LED/LCD display wi

47、th segment missing,excessive or uneven segmentLED/LCD显示缺划多划划不均earphone , headphone, external speakerinopearative/function intermittent耳机头戴耳机扬声器无功能，功能间歇poor wire dressing causing functionalproblem电线外包皮包裹不良导致功能问题poor soldering, dry joint , componentsbridging焊接干接桥接不良sensitivity out of limit灵敏度超限keys/bu

48、ttons stuck按键按钮卡住polyfoam endcap broken but pass droptest泡沫塑料端盖破裂但通过试摔wall mounting hole墙安装孔storeage compartment储物箱desk lid平台盖hook 挂钩memory记忆ornament ball装饰球ornament bell装饰铃microphone麦克风telephone line cord电话线line cord jack电话线插口handset听筒handset cord听筒线handset cord jack听筒线插口handset cradle听筒架receiver受话器tansmitter送话器memory记忆tone dialing音频拨号pulse dialing脉冲拨号dial board拨号盘dial mode knob拨号方式键ring control knob响铃控制键receiver volume