电池规格书模板Word版

1、传播优秀Word版文档 ，希望对您有帮助，可双击去除！Specification Approval Sheet产品规格承认书Customer 客户名称：域拓Model 产品型号：4LType 产品类型：Li-ion batterySpecification产品规格：3.7V/1400mAH signed by client客户签名Confirmed确认：Checked 审核：Approved 批准：signed by manufacturer生产商签名Prepared 制定：肖泽建Checked 审核：Approved 批准：丁明谊AMENDMENT RECORDSModification T

2、imeDescriptionIssued DateApproved By传播优秀Word版文档 ，希望对您有帮助，可双击去除！0New release2015-06-26Catalogue 目 录1 .Battery type and scope电池型号和适用范围41 . 1: model产品型号：41 . 2: scope适用范围：客户定义42 . Basic character and compose of battery电池的基本特性及组成4传播优秀Word版文档 ，希望对您有帮助，可双击去除！2 . 1: fundamental performance parameter of bat

3、tery电池基本性能参数：42 . 2: Main components and parts主要零部件62 . 3: Regular performance and unfailing performance产品常规性能和可靠性能62 . 4: Contour Dimension of the Battery电池外形尺寸113 . Specifications of Parts零部件规格1123 . 1: fender保护板1223 . 2: general electric and protection characters一般电气与保护特征1223 . 2: electric schema

4、tic diagram of battery电池电路原理图：1333 . 3 : PCB layout 电路布局图.错误!未定义书签。3 4 . Specifications of the Cells电芯规格144Announcements注意事项155Danger 危险155Warnings 警告166Announcements 注意事项167 1 .Battery type and scope电池型号和适用范围 This Specification Approval Sheet is for rechargeable Li-polymer battery provided by Shiru

5、i Battery Co., LTD.This product is according with the national standard of PRC. GB/T18287-2000. General specification of lithium-ion battery for cellular phone.本规格书为时瑞电池有限公司提供的可充电式锂离子电池规格。此产品符合中华人民共和国国家标准GB/T18287-2000蜂窝电话用锂离子电池总规范。传播优秀Word版文档 ，希望对您有帮助，可双击去除！1 . ：model产品型号：4L2 . Basic character and

6、compose of battery电池的基本特性及组成2 . 1： fundamental performance parameter of battery电池基本性能参数：S/N序号Details内 容parameters参 数remarks备 注1Rated voltage额定电压3.7V2Rated capacity额定容量1400mAHdischarge with 0.2C to 2.75V after Complete charge within 1h, measuring the discharge power完全充电后1小时内,用0.2C放电至2.75V，测量其放电电量。截止电

7、压2.9-3.1V3Limited charge voltage充电限制电压4.25V4internal resistance内 阻150m5charge mode充电方式C.C/C.V.恒流/恒压方式恒流/恒压6Charge time充电时间6HStandard charging 0.2C 280mA标准充电0.2C（280mA）2.5H1C（280mA）7Max Charge Current最大充电电流1400mA9Max discharge current最大放电电流Lasting 持 续：1400mATransient peak瞬间峰值： 2800mA10Working tempera

8、ture工作温度charging充电时045discharging放电时-206011Storage temperature贮存温度1 Month一个月-2060Charge to 40%50% of capacity when storage贮存时应充电至容量的40%50%6 months六个月-203012Storage humidity贮存湿度Relative humidity65 20%RHrelative humidity相对湿度传播优秀Word版文档 ，希望对您有帮助，可双击去除！13weight重 量约32g14Self-discharging自放电When the batter

9、y pack is without load, certain operational current is consumed since the cell protects the circuit, thus leading to the bringing down of pack voltage. For long storing time, please supplement the charging and note the “seventh. Special notice”Pack before shipping出贷标准Charged with about 25-35% power

10、and the voltage is 3.8-3.95 V being shipping.15Identify resistanceID识别电阻68KTo ground16Cycle life循环寿命300 times300循环次capacity60容量60If you need the battery protection parameters, please refer to PAGE 11.如需参考电池保护参数，请参阅第11页。2 . 2：Main components and parts主要零部件 Materials 材料 材料model型号规格quantity数 量related t

11、echnical parameters相关技术参数manufacturer厂商li-ion battery cell锂离子电池芯484461AR1PCSPlease refer to the battery cell specification请参照电芯规格书/protection board保 护 板XHY-FHLN-4L1PCS/ 2 . 3：Regular performance and unfailing performance产品常规性能和可靠性能S/N序号inspection item检验项目Standard标 准Testing Method测试方法传播优秀Word版文档 ，希望对

12、您有帮助，可双击去除！1high temperature property高温性能discharge with 0.5C5A not less than 100mins under 55 + 2 ,the appearance without distortion and crack.电池在552，用0.5C5A放电时间不少于102min,电池外观无变形、无爆裂.set the battery 2h in the environment with 552 after Complete charge, then discharge with 0.5C5A完全充电后置于552,2h用0.5C5A放

13、电2Low temperature property低温性能discharge with 0.2C5A not less than 3h under -202,the appearance without distortion and crack.电池在-202，用0.2C5A放电时间不少于3h,电池外观无变形、无爆裂.set the battery 16-24h in the environment with -202 after Complete charge, then discharge with 0.5C5A,then set the battery in 205, 2h later

14、 observe the battery appearance 完全充电后置于-202,16-24h用0.2CA放电,结束后将电池置于205条件下搁置2h,观察电池外观.discharge with 0.2C5A not less than 3.5h under -102,the appearance without distortion and crack在-102，用0.2C5A放电时间不少于3.5h,电池外观无变形、无爆裂.set the battery 16-24h in the environment with -102 after Complete charge, then dis

15、charge with 0.5C5A,then set the battery in 205, 2h later observe the battery appearance完全充电后置于-102,16-24h用0.2C5A放电,结束后将电池置于205条件下搁置2h,观察电池外观.3Capability of keeping electricity荷电保持能力Discharge not less than 4.25h放电时间不少于4.25hOpen circuit 28d under the environment with 205 after complete charge, then di

16、scharge with 0.2C5A完全充电后,在205条件下,将电开路搁置28d,再0.2C5A放电.传播优秀Word版文档 ，希望对您有帮助，可双击去除！4Constant damp and hot property恒定湿热性能Battery appearance should have no obvious deformation, rust, smoke or explosion, discharge time not less than 36min电池外观应无明显变形、锈蚀、冒烟或爆炸，放电时间不低于36min.After complete charge, shelve the b

17、attery in the condition of 402 Relative humidity is 90% - 95% with constant temperature and humidity, 48h later, shelve it in 205 2h, then discharge with 1C5A完全充电后,在402,相对湿度为90%-95%的恒温恒湿条件下搁置48h后,再取出放在205条件下搁置2h 再以1C5A放电.5shake振动Battery appearance should have no obvious deformation, rust, smoke or e

18、xplosion, voltage not less than 3.6V电池外观应无明显变形、冒烟或爆炸，电池电压不低于3.6V.After fully charged with 0.38 mm amplitude, make 10Hz 30Hz resonant frequency, batteries installed in vibration bench, set up X.Y.Z three direction from swept-frequency rate for 1oct/min, circular sweep frequency vibration 30min完全充电后,以

19、0.38mm振幅作谐振10Hz55Hz的频率,将电池安装在振动台上,设置好X.Y.Z三个方向上从扫频速率为1oct/min, 循还扫频振动30min6Free Drop Test自由跌落Battery appearance should have no leakage, no smoke or explosion, but allowed slight deformation 电池允许轻微变形，但应不漏液,不冒烟,不爆炸。After crash test, the sample batteries are dropped on the 18-20mm hardwood of the conce

20、rt floor from 1000mm height according to positive and negative 6 direction of X,Y,Z. Each direction should test one time.碰撞试验结束后,将样品电池从1000mm高处自由跌落于水泥地面上的18-20mm厚的硬木板上,从X,Y,Z正负六个方向每个方向1次.7Performance of overcharge protection过充电保护性能Batteries should be no explosion, no fire, no smoke or leakage电池应不爆炸,

21、不起火,不冒烟或漏液.After the battery is fully charged, the battery should be loaded 8h with constant current source. The constant current source sets to 2 times nominal voltage and current sets 2CA.电池完全充电结束后,用恒流恒压源给电池加载8h,恒流恒源设定为2倍标称电压,电流设定为2C5A传播优秀Word版文档 ，希望对您有帮助，可双击去除！8Performance of over-discharge prote

22、ction过放电保护性能Batteries should be no explosion, no fire, no smoke or leakage. 电池应不爆炸,不起火,不冒烟或漏液.Under the conditions of an ambient temperature 205,the battery discharge in the conditions of 0.2C5A until voltage is termination. And then, battery discharge 24h with connecting a 30load resistance.电池在环境温度

23、205的条件下,以0.2C5A放电至终止电压后,外接30负载电阻放电24h.9Performance of short-circuit protection短路保护性能Batteries should be no explosion, no fire, no smoke or leakage; batteries voltage is not less than N*3.6V after instantaneous charge.电池应不爆炸,不起火,不冒烟或漏液;瞬时充电后电池电压不低于N*3.6V.After battery is fully charge, positive and ne

24、gative electrode should be circuit 1h with 0.1.And,battery should be charged 5S instantaneous with 1C5A after positive and negative electrode are cut off.电池完全充电后,将正负极用0.1电阻短路1h,将正负极断开后,电池以1C5A电流瞬时充电5S.10Short-circuit Test短路No fire, No explosionThe outside temperature ofbattery is not higher 150.不起火,

25、不爆炸,电池外部温度不高于150.Keep the connected electric couple battery in a fume hood and make positive and negative short circuit(the total resistance should be less than 50m). Tester should monitor temperature changes. If the temperature of battery drops to about 10 lower than the max temperature, test is fi

26、nished.本项试验将接有电热偶的电池置于通风橱中,短路其正负极(线路总电阻不大于50m),监视温度变化,当电池温度下降到比峰值低约10时,试验结束.传播优秀Word版文档 ，希望对您有帮助，可双击去除！11Cycle life循环寿命Charging life cycle is over 300 times循环寿命不低于300次容量大于60%.After 300 cycle，Capacity 60%The battery used for testing of cycle life should be charged with constant 0.5CA at constant temp

27、erature of 205.The battery is charged with constant voltage till 20mA when it is charged to the limited voltage. Then discharge it with constant 0.5C5A till the end voltage after stop charging for 0.5-1h, repeat the next cycle. It means the discharging time less than 36min of two consecutive cycles

28、while reaching its end of the life.电池循环寿命试验应在205,以0.5CA充电,当电池端电压达到充电限制电压时,改为恒压充电,直到充电电流小于或等于20mA,停止充电搁置0.5h-1h,然后以0.5C5A电流放电至终止电压,放电结束后,搁置0.5-1h,再进行下一个循环,直至连续两次放电时间小于36min.则认为寿命终止.12Storage贮存Fullychargethebattery,whichisnewmanufacturedshorterthan3months,with0.2C,thendischargetimeslessthen4hours .电池贮

29、存3个月,经完全充电后,0.2C5A,放电时间不小于4h.The storage test of battery should be selected a battery which is less than 3 month from production date to the date of experiment. Before storage, battery capacity should be full charged 40%50% capacity, the ambient temperature is 205 and relative humidity is 45%-75%.Af

30、ter the storage expiration of battery, battery should be charged and discharged according to fully charged and discharged.进行贮存试验的电池应选自生产日期到试验日期不足3个月的电池,电池贮存前应按完全充电的40%50%的容量,在环境温度205,相对湿度45%-75%的环境中贮存,贮存期满后,电池按完全充放电制进行充放电. 2 . 4:Contour Dimension of the Battery电池外形尺 传播优秀Word版文档 ，希望对您有帮助，可双击去除！ 2.5 L

31、abel（Not to scale）标贴3 . Specifications of Parts零部件规格3 . 1: fender DW01-P,8205A保护板DW01-P,8205A3 . 2:general electric and protection characters一般电气与保护特征Model of Protection IC : DW01-P 保护IC的型号：DW01-PItems项 目Specification规 格Remarks备 注Over-charging Protection Voltage4.28V0.05V传播优秀Word版文档 ，希望对您有帮助，可双击去除！过

32、充电保护电压Over-charging Return Voltage过充回复电压4.08V0.10VOver-discharge Protection Voltage过放电保护电压2.4V0.10VOver-discharge Return Voltage过放回复电压3.0V0.10VOver-current Protection过电流保护2-5ADetection Delay Time of Over-charging Protection过充电保护侦测延时时间200msDetection Delay Time of Over-discharging Protection过放电保护侦测延时时

33、间120mSDetection Delay Time of Over-current Protection过电流保护侦测延时时间20mSDetection Delay Time of Output short-circuit Protection输出短路保护侦测延时时间320US(Typical)Internal Resistance of Proper Functioning正常工作内阻60mConsume Current消耗电流6.0uA3 . 2 electric schematic diagram of battery电池电路原理图： 传播优秀Word版文档 ，希望对您有帮助，可双击去

34、除！3.3 PCB layout 电路布局图Top Layer Lower layer4 . Specifications of the Cells电芯规格NO.序号Items项目Parameters参数Tolerance公差Term条件Remark/ condition备注/条件1Appearance外观No mechanical damage, leakage , sink ,drum and so on无机械损伤、漏液、下陷、发鼓等现象/50cm distance under 40W daylight lamp在40W日光灯下50CM处Visual目视2Dimensions尺寸Lengt

35、h长61.0mm-0.5mmDigital caliper数显卡尺Width宽44.0mm-0.3mmThickness厚4.8mm+0.1mm3Voltage电压3.85-3.92V/万用表4Capacity容量1400mAH/0.2C5Internal resistance内阻60m/1KHz/6Consistency同批一致性Appearance quality is the same同批外观质量相同传播优秀Word版文档 ，希望对您有帮助，可双击去除！7Security安全性Correspond to related safety performance符合相关安全性能5 保质期电池的

36、保质期为出厂后一年。本公司承诺如果在一年中由于电池本身的质量问题，本公司将负责进行调换，如果是由于用户误用而产生的问题，不予调换。Announcements 注意事项Danger 危险To prevent battery from weeping, fever, exploding ,please obey the rules as follows:为了防止电池漏液、发热、爆炸,请遵守以下防范事项：Do not immerse the battery into the water or the sea, Guard against Damp;不要将电池浸入水或海水中,注意防潮。Do not a

37、pproach the heat source, like fire or heater;不要将电池接近热源,如火或发热器。Please use the appointed charger when charging;传播优秀Word版文档 ，希望对您有帮助，可双击去除！在充电时,请用指定的充电器。Do not transposition the +.- poles of the battery to charge;不要反接电池的+ -极进行充电。Do not direct-connected the battery to alternating current power supply, o

38、r autoignition of the vehicle;不要将电池直接连接在交流电源,或者车辆自动点火处。Do not discard the battery to the fire or hyperpyretic objects;不要将电池弃置于火里或高热的物体上。Do not use the conductor to lead the short circuit of the + -poles of the battery. Do not put the battery with metallic conductors to transport or store, like neckl

39、ace, hairpin and so on;不要将电池的+ -极用导体短路、不要把电池和金属导体,如项链、发夹等一起运输或存储。Do not beat or throw the battery;不要敲打或丢抛电池。Do not impale the battery with needle or some other sharp things, do not strike it with weight;不要用针或其它锋利物刺穿电池,不要用重物击打电池。As installed safety device in the battery, please do not resolve or chan

40、ge any other sections of the battery to protect the inherent safety functions;电池内有安全装置,为了保证其固有的安全功能,请不要将电池分解开或改变任何的部份。Warnings 警告Do not put the battery to the microwave oven or pressure tank;不要将电池放入微波炉或压力柜子里。Do not use the battery with some chemical batteries (like dry battery) or different capaciti

41、es and brands battery together, if the battery emits the smell, heat , changes color, be out of shape or appears any other abnormal phenomena during the charging or stored procedures, please get out the battery from the device or charger and stop using;不要将电池与其它化学电池(像干电池)或不同容量、牌子的电池合用,若电发出气味、发热、变色、变形

42、或者在使用充电、存储过程中,出现任何的不正常请立即从装置或充电器取出,停止使用。If can not recharge within the charging period, please not continue charging;指定充电时间内若不能再充电请不用继续充电。Put the battery to where the kids can not touch, if the kids swallow the battery , pleaseseeing the doctor soon;传播优秀Word版文档 ，希望对您有帮助，可双击去除！电池放于小孩不能触摸的地方,若小孩咽下电池,请

43、立即就医。If the electrolyte of the battery into the eyes, do not rub ,should wash the eyes first ,then see the doctor;若电池电解质进入眼睛,切勿揉眼睛,先用清水冲洗眼睛后立即就医。 Announcements 注意事项 Do not put the battery under the high temperature places (like sunshine irradiation or car in the hot weather), or it will catch fire for the heat , reduce the performance and loss the life;不要将电池放于高温处(如阳光直射或热天下汽车里)否则,会过热着火,性能降低和寿命缩短。 To insure the safety, the battery should install the safety device, please no