免维护铅酸蓄电池10小时率容量核对性放电测试报告

11XXXX阀控式密封铅酸蓄电池容量10小时率放电测试报告效劳单位：XXTAIGEXXXXXXXX测试人员：ZKF测试时间：202X年XX月XX22名目\l“_TOC_250003“一、测试内容 2\l“_TOC_250002“二、承受的测试仪表 2三、高压UPS蓄电池组测试和测试步骤： 2\l“_TOC_250001“四、测试行程安排及测试状况 5\l“_TOC_250000“五、对蓄电池组测试具体数据分析 5一、测试内容XXXXXXXX〔下称“信息中心”〕EXM120KVAUPS4LC-MH125301测试。测试内容：EXMUPS1-1测试完成后，将蓄电池组接回系统承受HIOKI3554蓄电池内阻测试仪，进展内阻测试，内阻测试分别在〔一是蓄电池放电测试前浮充状态下，二是蓄电池放电测试完毕，10〕并记录数据。的测试线路、测试工具，做好现场卫生工作。提交测试数据和测试报告，给出进一步测试结论。数量序号位置型号/容量数量序号位置型号/容量启用日期供电对象组数 每组节数1汤浅松下LC-MH12530,20206234EXMUPS112135AH,12v松下LC-MH12530,135AH,12v20206234EXMUPS2说明：本次测试抽取了EXMUPS11-110二、承受的测试仪表FEFD-650060PROUPSHIOKI3554FLUKEF317三、UPS：放电方式：离线放电，蓄电池组外接FEFD-650060PRO容量测试仪，系统FEFD-650060PRO检测接收电池的放电电流、各单体电压、组端电压值，分析电池的安康容量。仪表接线原理图仪表接线示意图无线模块接线图特点：被测试电池组离线放电过程中使用假负载消耗电能，测试过程中UPS测试步骤HIOKI3554以推断是否可以进展放电试验。FEFD-650060PRO测电池组进展离线放电外，UPS10FEFD-650060PRO60A，UPS190V~650V。整理现场，检测蓄电池组的接线等。4．安全性分析：由于承受离线式假负载放电，因此仪表的摆放留意散热通风方向。消灭短路大事。备用。四、测试行程安排及测试状况信息中心测试状况及测试行程安排信息中心测试状况及测试行程安排测试时间：20201117-20201118测试地点电池组投用时间电池组测试时间电池型号测试结果备注解决方案712020-6-112020-11-17松下LC-MH12530正常五、对蓄电池组测试具体数据分析1、测试仪器信息内阻值电压电流2、测试环境信息天气： 晴室内温度： 22℃室内湿度： 55%3、蓄电池外部检查

仪表型号FEFD-650060PROHIOKI3554检查结果：检查蓄电池外壳正常，未觉察漏酸、爬酸及变形现象。检查蓄电池端子连接是否紧固。检查结果：用扳手将蓄电池极柱重拧一遍，确保每节蓄电池极柱都紧固。4、蓄电池内阻测试量确定是否是由于测量引起的结果。表1：1-1NoR-RangeNoR-RangeResistance[mohm]V-RangeVoltage[voltDateTime]130m2.9860V13.792020-11-1718:32230m2.9160V13.112020-11-1718:32330m3.1160V13.742020-11-1718:32430m2.9460V13.722020-11-1718:32530m2.9260V13.712020-11-1718:32630m2.9560V13.622020-11-1718:33730m2.960V13.612020-11-1718:33830m2.9460V13.612020-11-1718:33930m3.0160V13.622020-11-1718:331030m2.9660V13.712020-11-1718:331130m2.9260V13.792020-11-1718:331230m2.9560V13.72020-11-1718:331330m2.9760V13.622020-11-1718:331430m2.9760V13.782020-11-1718:331530m2.9360V13.752020-11-1718:331630m2.9760V13.682020-11-1718:331730m2.9960V13.772020-11-1718:341830m2.9960V13.632020-11-1718:341930m2.9360V13.552020-11-1718:342030m2.960V13.712020-11-1718:342130m2.8760V13.652020-11-1718:342230m2.9160V13.592020-11-1718:342330m2.9160V13.762020-11-1718:342430m2.960V13.632020-11-1718:342530m2.9460V13.772020-11-1718:352630m2.9760V13.632020-11-1718:352730m2.8960V13.582020-11-1718:352830m2.8460V13.652020-11-1718:352930m2.8960V13.532020-11-1718:353030m2.8760V13.642020-11-1718:353130m2.9260V13.652020-11-1718:353230m2.960V13.762020-11-1718:353330m2.8660V13.652020-11-1718:353430m2.9360V13.62020-11-1718:35最大值3.1113.79最小值2.8413.11结果分析1-1最大3.112.842.936.14%；以上指标均符合招标文件要求。说明：内阻偏差率最大：最大值-减均值后再除以均值5、蓄电池组放电测试承受离线技术核对性放电。电流：10小时率13.5A恒电流放电。放电步骤：将无线监测模块连接到该组电池各单体上。池组端正负极。依据测试规程设定放电参数。小时率小时率C10预放电流 13.5A预放容量 100%单体下限 10.8V组端下限 367.2放电时间 10小时标称容量 135AH确认主机收到各个单体电池数据信息。确认接线无误后，启动放电。放电完毕后，拷贝放电数据。恢复测试现场，整理现场。6、放电数据分析表2单体电池电压放电起始值、每30时间(HMS)0:00:000:30:001:00:001:30:002:00:002:30:003:00:003:30:00总电压(V)464.3428.0426.9425.6424.2422.7421.0419.2总电流(A)0.0-13.5-13.5-13.5-13.5-13.5-13.5-13.5容量(AH)06.7513.5020.2527.0033.7540.5047.25#113.7912.55112.52312.49012.45012.40612.35812.307#213.1112.58812.54912.50512.45812.41212.36112.309#313.7412.62012.58412.54612.50412.46212.41312.362#413.7212.61212.57512.53712.49612.45212.40412.353#513.7112.58712.55212.51412.47112.42712.37812.327#613.6212.60812.57012.52712.48112.43712.38712.336#713.6112.57212.53812.50112.45712.41312.36312.312#813.6112.60012.56112.51812.47112.42512.37412.322#913.6212.58412.54612.50512.46012.41412.36512.313#1013.7112.62012.58712.55212.51112.46712.41812.366#1113.7912.62612.59112.55512.51312.46912.42012.369#1213.712.59212.55512.51512.47312.42712.37712.326#1313.6212.60012.56212.52212.47712.43112.38312.331#1413.7812.59612.56612.53212.49212.44712.40012.349#1513.7512.59112.55812.52212.48012.43712.38712.336#1613.6812.60512.56812.52812.48412.43912.39012.338#1713.7712.56612.53512.50012.46012.41512.36612.315#1813.6312.58712.55312.51512.47412.43012.38112.331#1913.5512.56312.53512.50112.46012.41512.36512.313#2013.7112.59112.55912.52412.48212.43912.39112.340#2113.6512.59312.56012.52312.48012.43712.38912.338#2213.5912.59612.55912.51912.47412.43012.38112.330#2313.7612.58112.55212.52012.47912.43612.38812.338#2413.6312.59912.56512.52712.48512.44012.39112.341#2513.7712.59012.55812.52512.48512.44312.39512.345#2613.6312.59012.55812.52312.48212.43712.38912.338#2713.5812.56712.53012.49012.44712.40112.35212.301#2813.6512.60412.57212.53612.49612.45212.40312.353#2913.5312.63012.59212.54912.50312.45812.40812.356#3013.6412.57812.54912.51412.47212.42712.37812.326#3113.6512.56912.53712.50112.46012.41512.36612.315#3213.7612.58912.55812.52412.48512.44212.39412.342#3313.6512.57112.53712.50012.45712.41312.36412.312#3413.612.57712.53912.49812.45312.40912.35912.307时间(HMS)4:00:004:30:005:00:005:30:006:00:006:30:007:00:007:30:00总电压(V)417.4415.5413.4411.3409.1406.8404.5402.0总电流(A)-13.5-13.5-13.5-13.5-13.5-13.5-13.5-13.5容量(AH)54.0060.7567.5074.2581.0087.7594.50101.25#112.25112.19512.13512.07212.00811.94111.87211.799#212.25212.19512.13412.07012.00511.93711.86611.791#312.30812.25112.19312.12812.06311.99611.92611.854#412.29912.24212.18312.11812.05411.98611.91611.842#512.27212.21612.15612.09212.02811.96011.89011.816#612.28112.22412.16512.10112.03711.96911.89911.827#712.25612.20012.14012.07512.01111.94311.87311.799#812.26712.20912.15012.08512.02011.95211.88111.808#912.25912.20212.14312.08112.01711.95011.88011.808#1012.31212.25412.19512.13112.06812.00111.93111.859#1112.31512.25912.19912.13712.07312.00611.93611.864#1212.27012.21312.15312.09012.02511.95911.88911.815#1312.27612.21812.15912.09612.03311.96511.89611.823#1412.29412.23712.17812.11712.05311.98611.91711.845#1512.28212.22612.16512.10412.04011.97311.90511.831#1612.28312.22712.16712.10512.04111.97511.90611.834#1712.26112.20512.14512.08312.02011.95411.88411.812#1812.27612.22012.16012.09912.03511.96811.89911.827#1912.25812.20112.14012.07712.01311.94511.87311.799#2012.28612.22912.17012.10812.04411.97711.90811.836#2112.28312.22712.16812.10412.04111.97311.90311.831#2212.27612.22012.16012.09712.03311.96711.89711.825#2312.28412.22712.16912.10512.04211.97411.90411.832#2412.28512.22812.16912.10512.04111.97311.90311.830#2512.29112.23512.17612.11412.05011.98411.91511.843#2612.28312.22612.16712.10312.04011.97311.90311.830#2712.24412.18812.12812.06512.00211.93411.86411.791#2812.29812.24112.18212.11912.05611.98911.92011.847#2912.30112.24312.18312.12012.05711.99011.92011.848#3012.27112.21412.15312.09012.02711.95911.88911.816#3112.26012.20312.14412.08112.01611.94811.87811.805#3212.28812.23212.17212.11112.04711.98011.91111.839#3312.25712.20012.14012.07812.01411.94711.87711.804#3412.25312.19512.13612.07312.01011.94311.87311.800时间(HMS)8:00:008:30:009:00:009:30:0010:00:00总电压(V)399.4396.6393.6388.5386.5总电流(A)-13.5-13.5-13.5-13.5-13.5容量(AH)108.00114.75121.50128.25135.00#111.72311.64111.55111.39911.333#211.71411.63011.53811.38111.313#311.77811.69811.60911.46311.402#411.76711.68511.59711.44811.385#511.74111.65811.56811.41611.350#611.75111.67011.58111.43311.370#711.72211.63911.54711.39111.323#811.73011.64711.55711.40411.338#911.73211.65011.56111.41011.346#1011.78411.70311.61611.47011.408#1111.79011.71011.62311.48111.422#1211.73911.65711.56711.41711.352#1311.74811.66611.57711.42611.363#1411.77011.69011.60411.45811.397#1511.75711.67611.58811.43911.376#1611.75811.67811.59111.44311.382#1711.73711.65711.56911.42211.360#1811.75111.66911.58111.43111.368#1911.72011.63311.53811.35611.259#2011.76111.68011.59211.44411.382#2111.75511.67311.58511.43611.372#2211.74911.66811.58011.43111.368#2311.75711.67511.58711.43911.376#2411.75411.67111.58211.43111.368#2511.76811.68811.60211.45811.397#2611.75511.67211.58311.43311.369#2711.71311.63111.53911.38211.315#2811.77311.69211.60511.46111.400#2911.77211.69211.60411.45711.395#3011.73911.65811.56711.41611.350#3111.72811.64511.55411.39811.331#3211.76411.68411.59711.45111.388#3311.72711.64511.55411.40011.335#3411.72411.64111.55111.39811.3341#1#电池电压(V)1413.51312.51211.51110.510#1图5.6.1放电过程1#单体电压变化曲线图(1-10:00:000:30:001:00:001:30:002:00:002:30:003:00:003:30:004:00:004:30:005:00:005:30:006:00:006:30:007:00:007:30:008:00:008:30:009:00:009:30:0010:00:00每节单体电压1413.51312.512每节单体电压1413.51312.51211.511#1#2#3#4#5#6#7#8#9#10#11#12#13#14#15#16#17#18#19#20#21#22#23#24#25#26#27#28#29#30#31#32#33#34每节电池起止电压每节电池起止电压13.50013.00012.50012.00011.50011.00010.50010.000#1 #3 #5 #7 #9 #11 #13 #15 #17 #19 #21 #23 #25 #27 #29 #31 #330:0010:00图5.6.3每节电池起止电压单体电池电压(1-13各单体电池的容量状况(1-1蓄电池组)单体编号实际容量(AH)容量百分比#1141.66104.94%#2141.41104.75%#3142.53105.57%#4142.31105.42%#5141.88105.09%#6142.12105.28%#7141.54104.84%#8141.73104.98%#9141.82105.06%#10142.60105.63%#11142.77105.76%#12141.90105.11%#13142.04105.21%#14142.46105.53%#15142.20105.33%#16142.27105.39%#31#29#31#29104.92%105.44%105.09%105.51%105.56%105.26%105.27%105.53%105.26%105.33%105.30%105.39%105.19%105.26%#15#13#11#9#7#5#3#1103.00%105.33%105.39%105.11%105.21%105.53%105.76%105.06%105.63%104.84%104.98%105.09%105.28%105.42%104.75%105.57%104.94%103.50%104.00%104.50%105.00%105.50%106.00%23#17142.00105.19%#18142.10105.26%#19140.74104.25%#20142.27105.39%#21142.15105.30%#22142.10105.26%#23142.20105.33%#24142.10105.26%#25142.46105.53%#26142.11105.27%#27141.44104.77%#28142.50105.56%#29142.44105.51%#30141.88105.09%#31141.64104.92%#32142.35105.44%#33141.69104.95%#34141.67104.94%#33各单体电池实际容量104.94%104.95%#27#25104.77%#23#21#19#17104.25%图5.6.4各单体电池实际容量柱状图(1-1结果分析：10.8V〔3.2.2，3.3.3〕，符合国家标准。142.77AH，最小140.74AH，单体电池实际容量均已超过标称容量135AH〔详见表3，图3.2.4〕，电池容量最大值与最小值差值为1.51%，符合招标文件要求。7、UPS10表4：1-110NoR-RangeResistance[mNoR-RangeResistance[mV-RangeVoltage[voltDateTimeohm]]130m2.8960V13.692020-11-1819:37230m2.9460V13.622020-11-1819:37330m3.0660V13.72020-11-1819:37430m2.9360V13.682020-11-1819:37530m2.960V13.662020-11-1819:3