Y系列三相异步电动机产品样本(南洋)_图文

1、Y 系列三相异步电动机前言Y 系列三相异步电动机是一般用途的全封闭自扇冷鼠笼型电动机系全国统一设计的产品具有效率高起动转矩大噪音低振动小性能优良外型美观等优点功率等级和安装尺寸符合国际电工委员会I.E.C. 标准 广泛用于各种机械设备的驱动并适用于单机出口及出口和进口机械设备的配套欢迎选用如有特殊要求请洽谈订货 Y 系列电动机防护等级为IP44 功率范围0.55200kw 机座中心高80315mm简介使用条件环境温度随季节而变化但不超过 40海 拔不超过1000m 频 率50Hz 电 压380V接 法3kW 及以下为Y 接法4kW 以上为接法工作方法连续 S1如有特殊要求请于订货时提出如 1

2、双轴伸或特殊轴伸 2 异电压异频率3 左出线面对出轴接线在左侧盒 4 不同绝缘等级如F 级 5 不同防护等级如IP55 定子定子铁心嵌完绕组后经浸渍处理成为一个完整体绕组及绝缘具有良好的电气机械防潮性能及热稳定性电动机的绝缘等级为B 级 转子采用热套或冷压工艺将铸铝转子固定在轴上转子经校正平衡电机运转平稳振动小 接线盒具有良好的密封性能盒内有较大空腔出线口有琐紧装置并可从与电动机轴线平行或垂直的四个方向任意出线 风扇 风罩全系列风扇与轴采用键配合运转可靠风罩由薄钢板拉伸后冲孔制成风路顺畅外型美观钢性好并满足IP20固体防护的要求 轴承及轴承室全系列采用电机专用轴承80132机座在轴伸端轴承室内

3、装有波形弹簧片可消除轴承游隙有效地抑制电动机运行时的振动和噪声符号说明 1 I P 4 4 防溅水防护大于1mm 的固体国际防护符号2 I C 0 1 4 1全封闭自扇冷国际冷却符号3 Y 1 3 2 S2 2极数短机座第二种铁心长度机座中心高mm异步电动机订货须知1. 订货时请注明样本中所标明的电动机型号功率同步转速电压接法频率安装结构型式等例5.5kW2极机座带底脚端盖无凸缘的标准电动机标注如下 Y132S-2 (IP445.5kW 3000r/min380V 接50Hz B3 2. 如有特殊要求请在合同中详细说明并请事先与制造厂联系 例接线盒置于左侧双轴伸电动机标注如下 Y132S-2

4、(IP445.5kW 3000r/min380V 接50Hz B3左出线双轴伸 技术数据 Technical Data2极380V 转速77 78 80.5 82 85.5 85.5 86.2 87.2 88.2 89 89 90 90.5 91.5 91.5 92 92.5 92.5 93 93.5 93.5同步转速3000r/min 功率 kW 0.75 1.1 1.5 2.2 3 4 5.5 7.5 11 15 18.5 22 30 37 45 55 75 90 110 132 160 200 注50Hz Synchronous speed 3000 r/min (2-pole, 380

5、V, 50Hz0.84 0.86 0.85 0.86 0.87 0.87 0.88 0.88 0.88 0.88 0.89 0.89 0.89 0.89 0.89 0.89 0.89 0.89 0.89 0.89 0.89 0.89型号电流重量效率 噪声N.m 2.5 3.7 5.0 7.4 10.0 13.2 18.1 24.5 35.9 48.9 60.1 71.2 97.2 119.0 144.8 176.9 241.3 288.6 352.7 423.2 513.0 641.32.2 2.2 2.2 2.2 2.2 2.2 2.0 2.0 2.0 2.0 2.0 2.0 2.0 2.0

6、 2.0 2.0 2.0 2.0 1.8 1.8 1.8 1.8Weight2.3 2.3 2.3 2.3 2.3 2.3 2.3 2.3 2.3 2.3 2.2 2.2 2.2 2.2 2.2 2.2 2.2 2.2 2.2 2.2 2.2 2.26.5 7.0 7.0 7.0 7.0 7.0 7.0 7.0 7.0 7.0 7.0 7.0 7.0 7.0 7.0 7.0 7.0 7.0 6.8 6.8 6.8 6.871 71 75 75 79 79 83 83 87 87 87 92 95 95 97 97 99 99 104 104 104 1042825 2840 2840 2880

7、 2890 2900 29002930 293018 19 23 27 36 45 70 77 122 132 150 182 240 255 309 403 544 620 980 1080 1160 12202940 2950 2950 2970 2970 2970 2970 2980 2980 2980 2980 29801. LW声功率级Note: a. LW-Stand power level.b. The limits are permitted to increase 3 dB (A. c. Protection Class is IP44.2. 噪声容差为+3dBA 3. 防护

8、等级为IP44 技术数据 Technical Data4极380V 转速73 74.5 78 79 81 82.5 84.5 85.5 87 88 88.5 91 91.5 92.2 91.8 92.3 92.6 92.7 93.5 93.5 94 94.5 94.5同步转速1500r/min 功率 kW 0.55 0.75 1.1 1.5 2.2 3 4 5.5 7.5 11 15 18.5 22 30 37 45 55 75 90 110 132 160 200 注50Hz Synchronous speed 1500 r/min (4-pole, 380V, 50Hz0.76 0.76

9、0.78 0.79 0.82 0.81 0.82 0.84 0.85 0.84 0.85 0.86 0.86 0.87 0.87 0.88 0.88 0.88 0.89 0.89 0.89 0.89 0.89型号电流重量 效率 噪声N.m 3.8 5.2 7.5 10.2 14.8 20.2 26.5 36.5 49.8 72.0 98.2 120.3 143.0 195.0 238.9 290.5 355.1 484.2 581.0 707.8 849.3 1029.5 1286.9 2.4 2.3 2.3 2.3 2.2 2.2 2.2 2.2 2.2 2.2 2.2 2.0 2.0 2.

10、0 1.9 1.9 2.0 1.9 1.9 1.8 1.8 1.8 1.8Weight2.3 2.3 2.3 2.3 2.3 2.3 2.3 2.3 2.3 2.3 2.3 2.2 2.2 2.2 2.2 2.2 2.2 2.2 2.2 2.2 2.2 2.2 2.26.0 6.0 6.5 6.5 7.0 7.0 7.0 7.0 7.0 7.0 7.0 7.0 7.0 7.0 7.0 7.0 7.0 7.0 7.0 6.8 6.8 6.8 6.867 67 67 67 70 70 74 78 78 82 82 82 82 84 84 84 86 90 98 98 101 101 1011390

11、 1390 1400 14001420 142019 20 25 28 36 39 45 72 84 130 145 180 200 270 284 320 427 562 667 1000 1100 1160 12401440 1440 1440 1460 1460 1470 1470 1470 1480 1480 1480 1480 1480 1485 14851485 14851. LW声功率级Note: a. LW-Stand power level.b. The limits are permitted to increase 3 dB (A. c. Protection Class

12、 is IP44.2. 噪声容差为+3dBA 3. 防护等级为IP44 技术数据 Technical Data同步转速1000r/min 功率 kW 0.75 1.1 1.5 2.2 3 4 5.5 7.5 11 15 18.5 22 30 37 45 55 75 90 110 132 注型号6极380V50Hz Synchronous speed 1000 r/min (6-pole, 380V, 50Hz72.5 73.5 77.5 80.5 83 84 85.3 86 87 89.5 89.8 90.2 90.2 90.8 92 92 92.8 93.2 93.5 93.80.70 0.

13、72 0.74 0.74 0.76 0.77 0.78 0.78 0.78 0.81 0.83 0.83 0.85 0.86 0.87 0.87 0.87 0.87 0.87 0.877.9 11.6 15.2 22.4 29.9 39.8 54.7 73.9 108.3 147.8 182.2 216.7 292.5 360.8 438.8 536.3 731.3 873.0 1067.1 1280.5重量 65 65 67 67 71 71 71 75 75 78 78 78 81 81 84 84 92 92 92 9224 30 35 45 70 80 90 130 160 195 2

14、20 250 292 408 538 595 990 1080 1150 1210电流转速效率 噪声N.m2.0 2.0 2.0 2.0 2.0 2.0 2.0 2.0 2.0 1.8 1.8 1.8 1.7 1.8 1.8 1.8 1.6 1.6 1.6 1.6Weight2.2 2.2 2.2 2.2 2.2 2.2 2.2 2.0 2.0 2.0 2.0 2.0 2.0 2.0 2.0 2.0 2.0 2.0 2.0 2.05.5 5.5 6.0 6.0 6.5 6.5 6.5 6.5 6.5 6.5 6.5 6.5 6.5 6.5 6.5 6.5 6.5 6.5 6.5 6.5910

15、910 940940 960 960 970960970 970970 970 980 980 980 985 985 985980 9801. LW声功率级Note: a. LW-Stand power level.b. The limits are permitted to increase 3 dB (A. c. Protection Class is IP44.2. 噪声容差为+3dBA 3. 防护等级为IP44 80.5 82 84 85 86 87.5 88 89.5 90 90.5 91 91.7 92 92.5 93 93.30.71 0.72 0.73 0.74 0.75 0

16、.77 0.76 0.76 0.78 0.80 0.79 0.80 0.80 0.81 0.82 0.82重量 技术数据 Technical Data同步转速750r/min 功率 kW 2.2 3 4 5.5 7.5 11 15 18.5 22 30 37 45 55 75 90 110 注8极 电流380V50Hz Synchronous speed 750 r/min (8-pole, 380V, 50Hz型号转速 效率 噪声N.m 29.6 40.4 53.1 73.0 99.5 144.0 196.3 242.1 288.0 392.7 484.3 581.0 710.2 968.4

17、 1162.1 1420.3 2.0 2.0 2.0 2.0 2.0 1.7 1.8 1.7 1.8 1.8 1.8 1.8 1.6 1.6 1.6 1.6Weight2.0 2.0 2.0 2.0 2.0 2.0 2.0 2.0 2.0 2.0 2.0 2.0 2.0 2.0 2.0 2.05.5 5.5 6.0 6.0 5.5 6.0 6.0 6.0 6.0 6.0 6.0 6.0 6.5 6.5 6.5 6.366 66 69 69 72 72 75 75 75 78 78 78 87 87 87 87710 710 720 720 720 730 730 730 730 730 730

18、 740 740 740 740 74070 85 115 127 160 175 250 266 292 405 520 592 1000 1100 1160 12301. LW声功率级Note: a. LW-Stand power level.b. The limits are permitted to increase 3 dB (A. c. Protection Class is IP44.2. 噪声容差为+3dBA 3. 防护等级为IP44 91.5 92.0 92.50.74 0.74 0.75重量技术数据 Technical Data同步转速600r/min 功率 kW45 55

19、 75 注10极 电流380V 50Hz Synchronous speed 600 r/min (10-pole, 380V, 50Hz型号转速 效率 噪声N.m 728.8 890.7 1214.61.4 1.4 1.4Weight 2.0 2.0 2.06.0 6.0 6.087 87 87590 590 590900 1020 11901. LW声功率级Note: a. LW-Stand power level.b. The limits are permitted to increase 3 dB (A. c. Protection Class is IP44.2. 噪声容差为+3d

20、BA 3. 防护等级为IP44480 49091.5 91.50.68 0.68 重量技术数据 Technical Data同步转速500r/min 功率 kW45 55 注12极 电流380V50Hz Synchronous speed 500 r/min(12-pole, 380V, 50Hz型号转速 效率 噪声N.m 741.3 1072.55.0 5.0Weight1.9 1.91.2 1.21. LW声功率级Note: a. LW-Stand power level.b. The limits are permitted to increase 3 dB (A. c. Protect

21、ion Class is IP44.2. 噪声容差为+3dBA 3. 防护等级为IP44 安装及外型尺寸(1 B3(1B3B6B6B7B7B8B8V5V5V6机座带底脚端盖无凸缘Mounting and Overall Dimensions V6 Frame with feet and endshield without flange.mmMounting dimensions(mm外型尺寸mm Overall dimensions(mm型号安装尺寸极数TypeY80poles2480 125 100 50 19406886 7 715.5 10165 20 10180 20 10180 24

22、 12205 24 12245 33 12280 33 12280 37 15330 37 15330 42.5 15355 42.5 15355 49 19395175 195 195 215 240 275 275 325 335 380 380 420 475 475 515 555 555150 160 160 180 190 210 210 265 265 285 285 315 345 345 385 410 410175 195 195 245 265 315 315 385 385 430 430 475 530 530 575 640 640290 315 340 380 4

23、00 475 515 605 650 670 710 775 820 815 845 930 1000 1050140 100 56 2450 140 125 56 2450246160 140 63 2860 Y112M112 190 140 70 2860216 140 89 3880 216 178 89 3880 254 210 108 42110 2468 254 254 108 42110 279 241 121 48110 279 279 121 48110 Y200L Y225S Y225M Y250M Y280S Y280M Y315S Y315M Y315L 注44462

24、62 462 446446662 82 82 810制造厂有权变动10 10 8 8 8 8 2 8200 318 305 133 55110 225 356 286 149 60140 225 356 311 149 250 406 349 168 280 457 368 190 280 457 419 190 315 508 406 216 315 508 457 216 315 508 508 21655110 60140 606565756575140 140 14087 87 101012121414168 8 8 8 9 9 1019435 19435 53 1811 1811 1

25、811 2012 1811 2012 1811 2214 1811 2214 1811 221453 58 58 67.5 58 67.524490 24550 2455065140 80170 65140 80170 65140 80170635 640 530 7701200 712858 1220635 640 530 7701250 7128635 640 530 770 71 13401. 80及90机座无吊攀2. HD尺寸是从机座底脚平面至机壳外圆顶部 3. 出线盒位置仅供参考Remarks: 1. Frame 80 and 90 without eyebolt.2. HD dim

26、ensions refer to the size that is from the frame feetplane to the top of the outer enclosure. 3. The position of the junction box is used for reference merely, and the manufacturers are allowed to change it. 安装及外型尺寸(2 B5(2B5型号V1V1V3机座不带底脚端盖有凸缘Mounting and Overall Dimensions V3 Frame without feet and

27、 endshield with flange.安装尺寸mmMounting dimensions(mm外型尺寸mm Overall dimensions(mmType 极数Poles SY8024194066 8887 7 7 8 8 8 9 9 8715.53.51651302000420 3.51651302000420 3.51651302000424 4 2151802500424 4 2151802500433 4 2652303000433 4 2652303000437 5 3002503500437 5 3002503500442.55 3002503500442.55 300

28、2503500449 5 35030040004 4003504500850 5024660 Y112M2860HF185 195 195 245 265 315 315 385 385L290 315 340 380 400 475 515 605 65012 175 150 12 12 195 160 12 12 195 160 12 15 215 180 14 15 240 190 14 15 275 210 14 15 275 210 14 19 335 265 16 19 335 265 1680 108 80 10110122468 110121101411014Y200L Y22

29、5S Y225M Y250M Y280S Y280M Y315S Y315M Y315L 注444444448 2 68 2 68 2 68 2 68 2 68 2 68 2 6819 380 285 18 19 380 285 18 19 420 315 18 19 475 345 20 551101610 601401811 551101610 601401811 601401811 655 4003504500819 475 345 20 535(610 53 845(935 53 585 5004505500819 515 385 22 19 555 410 22 19 555 410

30、 22 24 640 530 25 24 640 530 25 24 640 530 25(720 (720 (900 (900 (900(1120 (1170 (1270 (1320 (1320 (1350 (1460 (1490651811 581405 50045055008752012 67.5651811 585 500450550081402012 67.575651401811 801702214 651401811 801702214 651401811 80170221458 71 58 716 600550660086 6005506600871 6 60055066008

31、1. 括号内尺寸仅用于V1结构H180315 2. R为凸缘安装平面至轴伸台阶平面的距离制造厂有权变动3. 80及90机座无吊攀4. 出线盒位置仅供参考Remarks: 1. The dimensions in the brackets are for V1 arrangement only (H180315. 2. R is the distance from the flange mountingplane to the shaftextention shoulder. 3. Frame 80 and 90 without eyebolt.4. The position of the ju

32、nction box is used for reference merely, and the manufacturers are allowed to change it. 安装及外型尺寸(3 B35(3B35型号V15V15V36机座带底脚端盖有凸缘Mounting and Overall Dimensions V36 Frame with feet and endshield with flange.安装尺寸mmMounting dimensions(mm外型尺寸mm Overall dimensions(mmS Type 极数Poles Y80248012510050 194063.

33、5165130200046 15.5107 7 7 720 103.51651302000420 103.51651302000424 124 2151802500424 124 2151802500412 16517515017512 290 12 18019516019512 315 12 18019516019512 340 15 20521518024514 380 15 24524019026514 400 15 28027521031514 475 15 28027521031514 515 19 33033526538516 605 19 33033526538516 650 1

34、9 35538028543018 670 19 35538028543018 710 19 39542031547518 775 19 43547534553020 820 19 43547534553020815 84514010056 2450 814012556 2450824616014063 2860 8Y112M11219014070 2860 821614089 3880108 33 124 2652303000421617889 3880 1025421010842110122468 25425410842110122792411214811014279279121481101

35、4Y200L Y225S Y225M Y250M Y280S Y280M Y315S Y315M Y315L 注4448 2 68 2 68 2 468 2 446446668 2 2 220031830513355110168 33 124 265230300048 37 155 300250350048 37 155 300250350049 42.5155 300250350049 42.5155 3002503500410 49 195 35030040004225356286149601401811 53 195 40035045008551101610 49225356311149195 40035045008601401811 53 6053245 50045055008250406349168140181